Advertisement
50/75VCPW-VSR
Breaker To Vacuum Starter Replacement Unit
WARNING
IMPROPERLY INSTALLING OR MAINTAINING THESE PRODUCTS CAN
RESULT IN DEATH, SERIOUS PERSONAL INJURY OR PROPERTY DAMAGE.
READ AND UNDERSTAND THESE INSTRUCTIONS BEFORE ATTEMPTING
ANY UNPACKING, ASSEMBLY, OPERATION OR MAINTENANCE OF THE
DEVICE.
INSTALLATION OR MAINTENANCE SHOULD BE ATTEMPTED ONLY
BY QUALIFIED PERSONNEL. THIS INSTRUCTION BOOK SHOULD NOT
BE CONSIDERED ALL INCLUSIVE REGARDING INSTALLATION OR
MAINTENANCE PROCEDURES. IF FURTHER INFORMATION IS REQUIRED,
YOU SHOULD CONSULT EATON'S ELECTRICAL SERVICES & SYSTEMS.
THE UNITS DESCRIBED IN THIS BOOK ARE DESIGNED AND TESTED TO
OPERATE WITHIN THEIR NAMEPLATE RATINGS. OPERATION OUTSIDE OF
THESE RATINGS MAY CAUSE THE EQUIPMENT TO FAIL, RESULTING IN
DEATH, BODILY INJURY AND PROPERTY DAMAGE.
ALL SAFETY CODES, SAFETY STANDARDS AND/OR REGULATIONS AS
THEY MAY BE APPLIED TO THIS TYPE OF EQUIPMENT MUST BE STRICTLY
ADHERED TO.
THESE VACUUM STARTER REPLACEMENT UNITS ARE DESIGNED TO
BE INSTALLED PURSUANT TO THE AMERICAN NATIONAL STANDARDS
INSTITUTE (ANSI). SERIOUS INJURY, INCLUDING DEATH, CAN RESULT
FROM FAILURE TO FOLLOW THE PROCEDURES OUTLINED IN THIS
MANUAL.
This product was manufactured by Eaton Corporation at the
Power Breaker Center (PBC): 310 Maxwell Avenue, Greenwood, SC
29646.
All possible contingencies which may arise during installation,
operation or maintenance, and all details and variations of this
equipment do not purport to be covered by these instructions. If
further information is desired by purchaser regarding his particular
installation, operation or maintenance of particular equipment,
contact a Eaton representative.
Instruction Book IB02707112E
Contents
Sections
INTRODUCTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
SAFE PRACTICES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
RECEIVING, HANDLING, AND STORAGE . . . . . . . . . . . . . . 7
DESCRIPTION AND OPERATION . . . . . . . . . . . . . . . . . . . . .11
INSPECTION, MAINTENANCE, AND INSTALLATION . . . . .16
REPLACEMENT OF COMPONENTS . . . . . . . . . . . . . . . . . 20
REMOVAL OF PHASE BARRIERS AND FUSE . . . . . . . . . . 25
REPLACEMENT PARTS . . . . . . . . . . . . . . . . . . . . . . . . . . . 26
EATON CORPORATION www.eaton.com
August 2015
3
Advertisement
