Accessories; Warranty - Magura Clara 2002 Manual

w w w . m a g u r a . c o m
s e r v i c e @ m a g u r a . d e
11. Trouble Shooting
problem
not enough brake power
no pressure point
Squealing brake
contaminated brake pads
contaminated rotor
wheel cannot be mounted
rattling noise and rough
deceleration
leaking hose or brake
You will find further tips on our website www.magura.com in the FAQ
section!! Stay tuned.
reason solution
brake was not run it break in the brake (page4)
oil/lubricants on rotor clean the rotor with warm
and/or pads dishwater or alcohol replace
contaminated brake pads
air in the system bleeding the brake (page15)
leaking systems Check hose connections and
hose for leaks; replace hose
if necessary (pages 14/15)
badly aligned frame align brake caliper with
0,2mm spacers (page9)
Paint/powder coating on remove any paint or powder
fitting eyelets coating and care for an even
contact surface without
burrs. (page7)
Wheel q/r skewer insuffi- Increase tightening of q/r
ciently tightened skewer and mount it on
opposite side of caliper.
Insufficiently tightened check for an evenly spoked
wheel spokes wheel with high spoke
tension
carelessness brake pads must be changed
carelessness clean rotor with dish water
or alcohol
Lever blade was pulled with Push back the brake pads
removed wheel with transport device or a
flat blade screwdriver.
(page12)
brake pads worn, holder of brake pad change (page 12)
pads is wearing the rotor
accident, incorrect change hose or defective
installation brake lever or caliper (page
14)
w w w . m a g u r a . c o m
s e r v i c e @ m a g u r a . d e

12. accessories

contains everything that you need for bleeding and repairing a brake. ATTENTION: the kit
does NOT include a spare hose!
easily shortened with a cable cutter, 1700mm
0° fitting:
90°fitting:
Watch out for the genuine hose with yellow MAGURA marker!!
brake pads Clara Type 3.1 (left): code 0721 324
brake pads Julie Type 4.1 (right): code 0721 304
manufacturers like lever blades, hoses or brake pads have not been tested and
approved by MAGURA and consequently nothing can be said about their short
and long-term function. Never use those parts! All warranty and product liability
claims will be void in case of misuse!
might cause total failure of the whole system with possible heavy bodily injury!

13. Warranty

and brake calipers. Watch out for the red order form of the warranty card in this manual
and order your warranty certificate.
following:
abuse
mixing and matching the brake with parts from other manufacturers
damage of the exterior finish caused by improper use
any attempt to disassemble the whole brake
modifications
non-factory changes or improper service
shipping damages or loss (purchase of full value insurance is recommended).
18 19
MAGURA disc brake service kit, code: 0721 294
MAGURA braided hose for all MAGURA disc brakes
code 0721 203
code 0721 337
Use only genuine MAGURA brake pads!
Use only genuine MAGURA accessories! Any parts manufactured by other
Never change the paint, the finish or the consistence of your brake. This
MAGURA is giving a 5 years leak proof warranty on brake levers (master cylinder)
This warranty is void when damage to the brake has occurred from the