Summary of Contents for ATB AQUAmax CLASSIC Series
Page 1
Innovations for clean water ® BASIC/CLASSIC AQUAmax Installation Instructions...
Page 3
Please observe that the careful installation of the wastewater treatment plant is very important for a good treatment performance. ATB WATER GmbH, Südstraße 2, D-32457 Porta Westfalica, www.atbwater.com / Art.-No.: 9060 0209 / Status: 17.01.2019 / Page 3 from 24...
The correct function can only be guaranteed with the employment of original spare parts or spare parts approved by ATB. Before commissioning, all points of the operating instructions are to be checked. Keep these instructions readily to hand at all times! ATB WATER GmbH, Südstraße 2, D-32457 Porta Westfalica, www.atbwater.com /...
Page 5
Danger due to electrical voltage! Rotating parts. Danger of crushing and being drawn into the area of the submersible aerator! ATB WATER GmbH, Südstraße 2, D-32457 Porta Westfalica, www.atbwater.com / Art.-No.: 9060 0209 / Status: 17.01.2019 / Page 5 from 24...
® Installation instructions AQUAmax BASIC/CLASSIC 1-75 Scope of Delivery ATB goes to great lengths to achieve a complete consignment and product-specific packaging of all equipment and parts supplied. Nevertheless, please check the delivery for transportation damage and completeness. ® ®...
Page 7
Technical Data: All 230 V AC Compressor: JDK-S-80: 0,050 kW JDK-S-100: 0,075 kW JDK-S-120: 0,095 kW Pumps: ATBlift 2: 0,3 kW / 1,3 A ATB WATER GmbH, Südstraße 2, D-32457 Porta Westfalica, www.atbwater.com / Art.-No.: 9060 0209 / Status: 17.01.2019 / Page 7 from 24...
Page 8
JDK 300: 0,23 kW Pumps: ATBlift 2: 0,3 kW / 1,3 A FEKA 600: 1,0 kW / 4,3 A ATB WATER GmbH, Südstraße 2, D-32457 Porta Westfalica, www.atbwater.com / Art.-No.: 9060 0209 / Status: 17.01.2019 / Page 8 from 24...
• The inlet pipeline is connected to the primary settling stage. With retrofitting this, as a rule, has been relaid (Note drawing "Tank preparation" or project sketch). ATB WATER GmbH, Südstraße 2, D-32457 Porta Westfalica, www.atbwater.com / Art.-No.: 9060 0209 / Status: 17.01.2019 / Page 9 from 24...
Here the thick matter is separated from the influent ATB WATER GmbH, Südstraße 2, D-32457 Porta Westfalica, www.atbwater.com / Art.-No.: 9060 0209 / Status: 17.01.2019 / Page 10 from 24...
Page 11
Here the thick matter is separated from the influent. ATB WATER GmbH, Südstraße 2, D-32457 Porta Westfalica, www.atbwater.com / Art.-No.: 9060 0209 / Status: 17.01.2019 / Page 11 from 24...
Page 12
W,min or the wastewater engineering calculations. (see also marking on the side of the carrier frame) ATB WATER GmbH, Südstraße 2, D-32457 Porta Westfalica, www.atbwater.com / Art.-No.: 9060 0209 / Status: 17.01.2019 / Page 12 from 24...
Page 13
. The slope of the tensioned chain should not be more than 45° to the vertical. W,min ATB WATER GmbH, Südstraße 2, D-32457 Porta Westfalica, www.atbwater.com / Art.-No.: 9060 0209 / Status: 17.01.2019 / Page 13 from 24...
Page 14
If required, the immersion pipe must be secured against the ingress of thick matter floating sludge (see below). ATB WATER GmbH, Südstraße 2, D-32457 Porta Westfalica, www.atbwater.com / Art.-No.: 9060 0209 / Status: 17.01.2019 / Page 14 from 24...
Page 15
® Installation instructions AQUAmax BASIC/CLASSIC 1-75 ATB WATER GmbH, Südstraße 2, D-32457 Porta Westfalica, www.atbwater.com / Art.-No.: 9060 0209 / Status: 17.01.2019 / Page 15 from 24...
Page 16
Y-piece in the case of the half- chamber version (see next page). ATB WATER GmbH, Südstraße 2, D-32457 Porta Westfalica, www.atbwater.com / Art.-No.: 9060 0209 / Status: 17.01.2019 / Page 16 from 24...
Page 17
Installation instructions AQUAmax BASIC/CLASSIC 1-75 ® AQUAmax CLASSIC 1-16 ZB (quarter chamber) ® AQUAmax CLASSIC 1-16 ZB (half- and full chamber) ATB WATER GmbH, Südstraße 2, D-32457 Porta Westfalica, www.atbwater.com / Art.-No.: 9060 0209 / Status: 17.01.2019 / Page 17 from 24...
Page 18
Bypass From Outlet ® AQUAmax ATB WATER GmbH, Südstraße 2, D-32457 Porta Westfalica, www.atbwater.com / Art.-No.: 9060 0209 / Status: 17.01.2019 / Page 18 from 24...
Page 20
Attention is to be paid to correct laying of the protective earth conductor up to the earthing of the building. ATB WATER GmbH, Südstraße 2, D-32457 Porta Westfalica, www.atbwater.com / Art.-No.: 9060 0209 / Status: 17.01.2019 / Page 20 from 24...
Page 21
/ menu setback. With temperatures below 0°C a severely limited function of the LC display is to be anticipated. ATB WATER GmbH, Südstraße 2, D-32457 Porta Westfalica, www.atbwater.com / Art.-No.: 9060 0209 / Status: 17.01.2019 / Page 21 from 24...
(shrink hose is also supplied by ATB for cable extension). Whether, in case of electrical power outage, the air intake hose can´t be flood Accident hazard ®...
Need help?
Do you have a question about the AQUAmax CLASSIC Series and is the answer not in the manual?
Questions and answers