STEELGREEN SG36 Operator's Manual
Hide thumbs
Also See for SG36:
- Instruction manual (28 pages) ,
- Installation manual (8 pages) ,
- Operator's manual (56 pages)
Table of Contents
Advertisement
Quick Links
OPERATOR'S MANUAL
IMPORTANT: READ SAFETY RULES AND INSTRUCTIONS CAREFULLY
Warning:
This unit is equipped with an internal combustion engine and should not be used on or near
any unimproved forest-covered, brush-covered or grass-covered land unless the engine's exhaust system is
equipped with a spark arrester meeting applicable local or state laws (if any). If a spark arrester is used, it
should be maintained in effective working order by the operator. In the State of California, the above is re-
quired by law (Section 4442 of the California Public Resources Code). Other states may have similar laws.
Federal laws apply on federal lands. A spark arrester for the muffler is available through your nearest engine
authorized service dealer or contact the service department, P.O. Box 361131 Anytown, US 44136-0019.
STEELGREEN LLC, 920 S STATE ROAD 39 LEBANON, IN 46025
PRINTED IN U.S.A.
Advertisement
Table of Contents
Related Manuals for STEELGREEN SG36
Summary of Contents for STEELGREEN SG36
- Page 1 Federal laws apply on federal lands. A spark arrester for the muffler is available through your nearest engine authorized service dealer or contact the service department, P.O. Box 361131 Anytown, US 44136-0019. STEELGREEN LLC, 920 S STATE ROAD 39 LEBANON, IN 46025 PRINTED IN U.S.A.
-
Page 2: Table Of Contents
TABLE OF CONTENTS GENERAL INFORMATION ................................2 SAFE OPERATION ..................................3 CONTROLS AND OPERATION (SPREADER) ..........................4 SPREADER CALIBRATION / RATE CHARTS .......................... 4 SPREADER CLEANING ................................. 5 SPREADER MAINTENANCE ..............................5 CONTROLS AND OPERATION (SPRAYER)............................ 6 SPRAYER ON/OFF CONTROLS ............................6 SPRAYER PUMP CONTROLS ............................... -
Page 3: Safe Operation
SAFE OPERATION THIS SYMBOL POINTS OUT IMPORTANT SAFETY INSTRUCTIONS WHICH, IF NOT FOLLOWED, COULD ENDANGER THE PERSONAL SAFETY AND/OR PROPERTY OF YOURSELF AND OTHERS. READ AND FOLLOW ALL INSTRUCTIONS IN THIS MANUAL BEFORE ATTEMPTING TO OPERATE YOUR UNIT. FAILURE TO COMPLY WITH THESE INSTRUCTIONS MAY RESULT IN PERSONAL INJURY . -
Page 4: Controls And Operation (Spreader)
CONTROLS AND OPERATION (SPREADER) SPREADER CALIBRATION / RATE CHARTS CAUTION! To avoid injury to hand, ensure motor is switched OFF Wear appropriate clothing and safety equipment when applying and handling chemicals . • product placement on the spinner. Placing the product rides the impeller for a longer period. -
Page 5: Spreader Cleaning
Grass Seed Spreading Chart Dial Dial LBS. per Sq. Ft Spread 1000 sq. Rate Once Product Weight Coverage Full Rate Width Size Over Product 5 lbs. 1,000 1 lbs. 1,000 Blue Grass or Red Top Fine Pellets 2lbs. 1,000 5 lbs. 1,000 Park, Merion, Delta, Mixed Fine... -
Page 6: Controls And Operation (Sprayer)
CONTROLS AND OPERATION (SPRAYER) SPRAYER ON/OFF CONTROLS • The Spray System of the SG52, SG46, SG42 and SG36 • Each boom wing holds 1 nozzle. consists of a 3- • The Lever Valve is open in the “UP” is controlled by a dedicated Lever Valve located on the in the “Down”... -
Page 7: Sprayer Pump Controls
SPRAY PUMP CONTROL The Spray Pump is turned on/off by one of two • ways. A constant Rocker Switch is located on the dash panel. This pump will constantly run when A momentary Spot Spray Switch is located on the •... -
Page 8: Hose Reel Operation
Each SG model is also equipped with either a 75’ • Hose Reel (SG52, SG46, SG42) or a 15’ Coil Hose (SG36). This is meant to assist with spot spraying and or areas that are not able to be reached by the Machine. - Page 9 STANDARD VOLUME SPRAY CHART 20” CAPACITY ONE CAPACITY ONE DROP GALLONS PER 1000 SQ FT NOZZLE IN NOZZLE NOZZLE IN SIZE OZ/MIN 4 MPH 5 MPH 3 MPH 4 MPH 5 MPH 0.13 0.29 0.22 0.18 0.15 11.1 0.34 0.26 0.20 AVI-11015 (100)
-
Page 11: Maintenance
MAINTENANCE MAINTENANCE TIPS WINTERIZATION • • freezing. Follow these easy steps. • Blowing off unit is preferred over washing. But if washing unit dry it off as best as possible. • Drain all of the remaining liquid from the tanks and spray system. -
Page 12: Wire Harness
SG Main Wire Harness... -
Page 13: Grease Points
GREASE POINTS There are 5 grease points on this machine. 1 on each of the castor tubes 1 on the idler arm Idler Arm grease point Tire Grease point Castor Tube Grease Point... -
Page 15: Service
SERVICE MAINTENANCE CHART Hours Daily Weekly Monthly Annually Drive system Check Air filter replace as needed Check engine oil level Engine oil and filter Hydraulic oil and filter Check hydraulic oil level Spark plugs Clean oil cooler fins Clean engine debris screen Check valve clearance Replace fuel filter Inspect drive belt... - Page 16 NOTES _____________________________________________________________________________ _____________________________________________________________________________ _____________________________________________________________________________ _____________________________________________________________________________ _____________________________________________________________________________ _____________________________________________________________________________ _____________________________________________________________________________ _____________________________________________________________________________ _____________________________________________________________________________ _____________________________________________________________________________ _____________________________________________________________________________ _____________________________________________________________________________ _____________________________________________________________________________ _____________________________________________________________________________ _____________________________________________________________________________ _____________________________________________________________________________ _____________________________________________________________________________ _____________________________________________________________________________ _____________________________________________________________________________ _____________________________________________________________________________ _____________________________________________________________________________ _____________________________________________________________________________ _____________________________________________________________________________ _____________________________________________________________________________ _____________________________________________________________________________ _____________________________________________________________________________ _____________________________________________________________________________ _____________________________________________________________________________ _____________________________________________________________________________ _____________________________________________________________________________ _____________________________________________________________________________ _____________________________________________________________________________ _____________________________________________________________________________ _____________________________________________________________________________ _____________________________________________________________________________ _____________________________________________________________________________ _____________________________________________________________________________ _____________________________________________________________________________ _____________________________________________________________________________...
Need help?
Do you have a question about the SG36 and is the answer not in the manual?
Questions and answers