Table of Contents
Advertisement
Maintenance
Other Maintenance Checks
The following inspections should be performed by an
authorized service technician, or a properly trained
authorized operator. These maintenance items require a
high level of experience and skill to evaluate and correct.
•
Inspect exhaust pipe sleeve.
Short Term Storage
When the unit will not be in use for three or more months,
follow the guidelines below to properly store the unit:
•
Perform all necessary maintenance or repairs
based on the
Maintenance
sary maintenance is upcoming, perform the main-
tenance action before storing.
•
Fill the fuel tank to FULL.
•
Fill coolant to FULL. Do not drain.
•
Remove all dirt and debris from inside and outside
the enclosure.
•
Lock the unit to prevent any unauthorized opera-
tion.
•
Store in a safe location — do not position near or
on top of any combustible materials; observe any
local, state, or national codes or regulations. Store
in a low moisture, low dust area.
•
Disconnect the negative cable from the battery.
Return to Service
WARNING
CAUTION
Equipment damage. Do not attempt to start or operate
a unit in need of repair or scheduled maintenance.
Doing so could result in serious injury, death, or
equipment failure or damage.
Follow the guidelines below for engines and units that
have not been operated for three to six months:
•
Conduct a thorough inspection of the unit before
starting the engine.
•
Verify the maintenance schedule is up to date.
•
Check all fluids for signs of fouling or degradation.
•
After starting the engine, let it warm up for more
than 10 minutes at idle.
NOTE: Do not start or operate a unit in need of repair or
maintenance. Perform all maintenance tasks and repairs
before starting. Contact a GMP ASD if there is any doubt
as to the unit's usability.
22
Schedule.
If neces-
(000291)
Owner's Manual for Flameless Heat Cart
Advertisement
Table of Contents
