Table Of Contents - Regency ULTIMATE U38E Owners & Installation Manual

owner's information
Safety Label for the U38E-11 ........................................5
Before You Start .............................................................6
Lighting Procedure ........................................................7
Shutdown Procedure .....................................................7
Copy of the Lighting Plate Instructions ..........................8
Proflame II Remote Control Operating Instructions .......9
Warranty
Warranty ......................................................................38
installer's information
Dimensions
Dimensions ..................................................................4
Installation
Important Message ....................................................14
General Safety Information ..........................................14
Installation Checklist ....................................................14
Clearances to Combustibles ........................................15
U38E-NG11 & U38E-LP11 Clearances .......................15
U38E-NG11 & U38E-LP11 Reference Dimensions .....15
Optional Outside Air ....................................................15
Outside Air Through Pedestal Bottom .........................15
Outside Air Through Rear of Pedestal .........................15
Draft Hood ...................................................................16
High Elevation ..............................................................16
Venting .........................................................................16
Flue Mounting Bracket .................................................16
Gas Connection ...........................................................17
System Data ................................................................17
Gas Pipe Pressure Testing ..........................................17
885 S.I.T. Valve Description .........................................17
On Demand Pilot Light ................................................17
On Demand Pilot (seven day safety timer)
Important information if using the appliance in CPI (continuous pilot mode) only
This appliance is a ProFlame 2 system fitted with the "On Demand" Pilot, a safety feature which will shut down the gas valve completely by extinguishing the
pilot light in the event of a continuous full seven days of inactivity.
This only applies if the CPI (continuous pilot) switch is in the "on" position in your remote control transmitter.
Each time the main burner shuts down, manually or through the call from the thermostat, the seven day timer starts again.
The seven day inactivity timer is controlled within the circuit board. Therefore, if in CPI mode and when the pilot light is extinguished after seven straight days
of inactivity, the CPI setting on the remote control transmitter will remain in the "CPI" (continuous pilot) position. Therefore, all that is required to relight the pilot
would be to press the on/off button on the remote control transmitter from "on" to "off" and back to "on". Once the pilot has re-established operation will resume
as normal. There is no requirement to do anything with the IPI/CPI mode on the remote control transmitter.
If the unit never goes as long as seven full days without a call for heat, the pilot will remain lit until it is manually shut-off.
If the unit is being operated in IPI (intermittent pilot) mode, neither the above instructions nor the seven day timer will apply.
See the instructions in this manual and on the Lighting Instructions plate on the appliance to light or re-light the pilot.
Conversion Kit# 753-977 from NG to LP .....................18
Conversion to Lower BTU Rating ................................19
Log Set Installation ......................................................20
Driftwood Log Set Installation ......................................23
Front Door Installation .................................................26
Louver Installation .......................................................26
Test for Flue Spillage ...................................................26
Optional Wall Thermostat ...........................................26
Wiring Diagram without Thermostat ............................27
Wiring Diagram with Optional Thermostat ...................28
Operating Instructions
Battery Backup ............................................................29
First Fire ......................................................................30
Operating Instructions .................................................30
Optional Wall Thermostat ............................................30
Operation using an Optional Wall Thermostat .............30
Normal Operating Sounds of Gas Appliances .............31
Maintenance
Maintenance Instructions ............................................31
Aeration Adjustment ....................................................32
Maintenance Instructions ............................................33
Log Replacement ........................................................33
Door and Glass Gasket ...............................................33
Glass Replacement .....................................................33
Panel Door ...................................................................33
Fan Maintenance .........................................................33
Valve Replacement ......................................................34
Parts
U38E-11 Main Assembly .............................................35
U38E-11 Burner & Log Assembly ................................36
U38E-11 Door Assembly .............................................37
Warranty
Warranty ......................................................................38
Regency U38E-11 ULTIMATE Freestanding Gas Stove
®

table of contents

| 3