Table of Contents
Advertisement
Direct Vent Freestanding Gas Stove
WARNING:
If the information in these instructions are not followed exactly,
a fire or explosion may result causing property damage,
personal injury or loss of life.
FOR YOUR SAFETY
Do not store or use gasoline or other flammable vapors and
liquids in the vicinity of this or any other appliance.
Installation and service must be performed by a qualified
installer, service agency or the gas supplier.
Tested by:
918-027b
FPI FIREPLACE PRODUCTS INTERNATIONAL LTD. 6988 Venture St., Delta, BC Canada, V4G 1H4
www.regency-fire.com
ULTIMATE U39
MODELS:
U39-NG Natural Gas
Installer: Please complete the details on the back cover
and leave this manual with the homeowner.
Homeowner: Please keep these instructions for future reference.
Installation Manual
U39-LP Propane
FOR YOUR SAFETY
What to do if you smell gas:
Do not try to light any appliance
Do not touch any electrical switch:
do not use any phone in your
building.
Immediately call your gas supplier
from a neighbour's phone. Follow
the gas supplier's instructions.
If you
cannot reach your gas
supplier, call the fire department.
Owners &
01/09/06
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for Regency ULTIMATE U39-LP
Summary of Contents for Regency ULTIMATE U39-LP
- Page 1 ULTIMATE U39 Owners & Installation Manual Direct Vent Freestanding Gas Stove MODELS: U39-NG Natural Gas U39-LP Propane WARNING: FOR YOUR SAFETY If the information in these instructions are not followed exactly, What to do if you smell gas: a fire or explosion may result causing property damage, Do not try to light any appliance personal injury or loss of life.
- Page 2 Congratulations! You are the owner of a state-of-the-art ULTIMATE Direct Vent Gas Stove by FPI Fireplace Products International Ltd. The Regency Gas Series of hand crafted appliances has been designed to provide you with all the warmth and charm of a woodstove, at the flick of a switch. The models U39-NG, and U39- LP of this series has been approved by Warnock Hersey for both safety and efficiency.
-
Page 3: Table Of Contents
Converting a Class-A Metal Chimney or Masonry Chimney to a Direct Vent System .......19 Warranty ..................39 - Instructions for Converting a Factory Built Metal Chimney .............19 - Instructions for Converting a Masonry Chimney ...20 Regency U39 ULTIMATE Direct Vent Freestanding Gas Stove... -
Page 4: Safety Labels
Commonwealth of Massachusetts. For the State of Massachusetts, flexible connectors shall not exceed 36 inches in length. For the State of Massachusetts, the appliances individual manual shut-off must be a t-handle type valve. Regency U39 ULTIMATE Direct Vent Freestanding Gas Stove... -
Page 5: Installation
TROL COMPARTMENT, BURNERS tured home installations, see page 11 for Title 24 CFR, Part 3280, or the current Standard of Fire Safety Criteria for Manufactured Home the required vent arrangements. If installed Regency U39 ULTIMATE Direct Vent Freestanding Gas Stove... -
Page 6: General Safety Information
7) Venting terminals shall not be recessed into CAUTION: Any alteration to the product a wall or siding. that causes sooting or carboning that results in damage is not the responsibil- ity of the manufacturer. Regency U39 ULTIMATE Direct Vent Freestanding Gas Stove... -
Page 7: Manufactured Mobile Home Requirements
F) Flush with Wall/ Alcove 2) Unauthorized modification of the Direct Vent System For Vent Termination require- ments, see page 8. 3) Installation of any component part not man- ufactured or approved by Simpson Dura- Regency U39 ULTIMATE Direct Vent Freestanding Gas Stove... -
Page 8: Exterior Vent Terminal Locations
INSTALLATION EXTERIOR VENT TERMINAL LOCATIONS Regency U39 ULTIMATE Direct Vent Freestanding Gas Stove... -
Page 9: Rigid Pipe Venting Components List
Vent Guard (Optional) 946-208/P Vent Guard (Optional) - Riser Vent Terminal 640-530/P Riser Vent Terminal 946-523/P AstroCap Horizontal Cap 946-205 Vinyl Siding Shield for Riser Vent Terminal 946-206 Vinyl Siding Standoff - AstroCap Regency U39 ULTIMATE Direct Vent Freestanding Gas Stove... -
Page 10: Rigid Pipe Venting Systems
GS, American Metal Products, Ameri Vent Direct vent and Selkirk Direct-Temp. FPI , and FPI AstroCap are the proprietary trademarks of FPI Fireplace Products International Ltd. Dura-Vent® and Direct Vent GS are registered and/or proprietary trademarks of Simpson Dura-Vent Co. Inc. Regency U39 ULTIMATE Direct Vent Freestanding Gas Stove... -
Page 11: Safety Precautions For The Installer
Tighten the screws. Vent Restrictor setting at Vent Restrictor setting at 38,000 Btu/h 30,000 Btu/h Regency U39 ULTIMATE Direct Vent Freestanding Gas Stove... -
Page 12: Horizontal And Vertical Venting With Two Elbows
4 feet total vertical and max. 4 feet total horizontal. Please note min. 1 foot between 90 elbows is required. Lengths do not include elbow indicated Vent restrictor position A (fully open), refer to page 11. Regency U39 ULTIMATE Direct Vent Freestanding Gas Stove... -
Page 13: Dv Stove Horizontal Vent Kit
Be sure to check vent able pipe to determine the vertical termination area after snow falls, centerline of the starter collar on the and clear to prevent accidental unit. Regency U39 ULTIMATE Direct Vent Freestanding Gas Stove... - Page 14 13) Install the spring spacers onto the pipe Note: The four screws provided for the high temperature silicone. sections. vent cap should be replaced with appropriate fasteners for stucco, 14) Secure the 4" dia. flex liner with adapter Regency U39 ULTIMATE Direct Vent Freestanding Gas Stove...
-
Page 15: Dura-Vent Termination Kits
FPI Fireplace Products event that you are missing any part, contact International Ltd. your dealer. Dura-Vent® and Direct Vent GS are registered and/or proprietary trademarks of Simpson Dura-Vent Co. Inc. Regency U39 ULTIMATE Direct Vent Freestanding Gas Stove... -
Page 16: Dura-Vent Horizontal Installation
Vent is only for and 90 elbow use in above assembly is de- grade termi- termined by the nations. mounting orien- tation of the Diagram 3a Diagram 2 Regency U39 ULTIMATE Direct Vent Freestanding Gas Stove... -
Page 17: Dura-Vent Vertical Termination Installation
Step 2. Frame the hole as shown in diagram Apply decorative brass or chrome trim if desired. See diagram 7. Diagram 5 Diagram 7 Diagram 10 Regency U39 ULTIMATE Direct Vent Freestanding Gas Stove... -
Page 18: Offset Chart
0/12 - 2/12 4" height may solve the problem. 2/12 - 7/12 5-1/2" 7/12 - 12/12 6-3/4" Diagram 13 12/12 - 24/12 7-1/2" 24/12+ 12-1/2" Diagram 12 Regency U39 ULTIMATE Direct Vent Freestanding Gas Stove... -
Page 19: Support Extension - Round Or Square
Diagram 2. dumps shall be secured in place and sealed before installing a Direct Vent sys- tem within the chimney. Diagram 2 Regency U39 ULTIMATE Direct Vent Freestanding Gas Stove... -
Page 20: Instructions For Converting A Masonry Chimney
Diagram 7. with sections of black direct vent pipe, the connector is centered in the opening and the mounting holes line up with the together with an adjustable length. masonry wall. Regency U39 ULTIMATE Direct Vent Freestanding Gas Stove... -
Page 21: System Data Chart
Retro Connector may be completed with Circulation: Variable speed fan, 125/75 CFM. a section of black direct vent pipe, together Log Set: Ceramic fiber, 7 per set. with an adjustable length pipe section. Regency U39 ULTIMATE Direct Vent Freestanding Gas Stove... -
Page 22: Conversion From Natural Gas To Propane
14) Check inlet and outlet pressures. 6) Pull off the pilot cap to expose the pilot 15) Check operation of flame control. orifice. 16) Check for proper flame appearance and glow on logs. Regency U39 ULTIMATE Direct Vent Freestanding Gas Stove... -
Page 23: Conversion To Lower Btu
Position the Log Bracket Restrictor between testing of the gas supply piping system at test the Rear Log Bracket and the burner. pressures equal to or less than 1/2 psig. (3.45 Regency U39 ULTIMATE Direct Vent Freestanding Gas Stove... -
Page 24: Aeration Adjustment
- do not force into position. front pins as shown. 2) Sprinkle the embers on the left and right sides of the firebox base. C)02-44 Clockwise to open, counter-clockwise to close. Regency U39 ULTIMATE Direct Vent Freestanding Gas Stove... -
Page 25: Front Door Installation
The door latch may require ad- justment as the door gasket mate- Notch Cutout rial compresses after a few fires and after glass replacement. Turn the latch catch inward or outward to loosen or tighten. Regency U39 ULTIMATE Direct Vent Freestanding Gas Stove... -
Page 26: Wiring Diagram
UL approved may be used. that location, use Thermostat Wire Table. CAUTION 2) Connect the wires as per the wiring dia- Do not connect the millivolt gram above. wall thermostat wires to the 120V wires. Regency U39 ULTIMATE Direct Vent Freestanding Gas Stove... -
Page 27: Final Check
6) Turn PILOT knob counter clockwise to on. 7) The unit should never to turned off and on 7) Use the Burner ON/OFF switch to turn on without a minimum of a 60 second wait. the burner. Regency U39 ULTIMATE Direct Vent Freestanding Gas Stove... -
Page 28: Convection Fan Operation
"cracking" and automatically. higher, coun- "ticking" sounds will be heard through- terclockwise out the cycling process. for a lower flame. Regency U39 ULTIMATE Direct Vent Freestanding Gas Stove... -
Page 29: Maintenance
Clean any fingerprints off before turning the PLIANCE. unit on. If the door starts to discolour, check the gasket seal and replace if nec- essary. Regency U39 ULTIMATE Direct Vent Freestanding Gas Stove... -
Page 30: Log Replacement
5) Install door catch plate. (same glass retainers as the the glass should be done by a li- Panel Assembly) 6) Install the 24 nuts loosely, do not tighten yet. censed or qualified service person. Regency U39 ULTIMATE Direct Vent Freestanding Gas Stove... -
Page 31: Fan Maintenance
(grounding) plug for your protection against shock hazard and should be plugged directly into a properly grounded three-prong receptacle. Do not cut or remove the grounding prong from this plug. Regency U39 ULTIMATE Direct Vent Freestanding Gas Stove... -
Page 32: Removing Valve
8) Remove all 18 screws holding the burner tray assembly in place. 9) Carefully lift the burner tray assembly out. 4) Remove the two outside frame pieces by removing two screws per side. See dia- gram below. Regency U39 ULTIMATE Direct Vent Freestanding Gas Stove... -
Page 33: Replacement Parts List
Short Side Panel Door Assy (Left Side) 560-031 Hinge for Side Panel 904-258 Side Panel Door Magnet 948-255 Door Latch c/w Hook Flex Pipe 3" ID Hose Clamp 910-233 Thermodisc - Fan Auto/On/Off Mounting Bracket - Thermodisc Regency U39 ULTIMATE Direct Vent Freestanding Gas Stove... - Page 34 730-550 Burner Assembly (NG/LP) 260-565 Air Shutter Gear Assembly - Female 904-565 Hex Key 3/16" AF 630-009 Gasket-Burner Tray/Air Passage Air Shutter Gear Assembly - Male *Not available as a replacement part. Regency U39 ULTIMATE Direct Vent Freestanding Gas Stove...
-
Page 35: U39 Door Assemblies
106) 940-323/P Side Glass 107) 936-243 Glass Gasket 108) 940-322/P Centre Glass 111) * Door Frame Fibre Paper 112) 750-015 Door Glass Extrusion 208) 940-325/P Wrap Glass *Not available as a replacement part. Regency U39 ULTIMATE Direct Vent Freestanding Gas Stove... - Page 36 _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ ____________________________________________________________ __________________________________________________________ ____________________________________________________________ _______________________________________________________ _____________________________________________________ __________________________________________________________ _________________________________________________________ _________________________________________________________ ______________________________________________________ ______________________________________________________ _______________________________________________________________ ___________________________________________________________ __________________________________________________________ ____________________________________________________________ ____________________________________________________________ ____________________________________________________________ _____________________________________________________________ __________________________________________________________ __________________________________________________________ _____________________________________________________ ________________________________________________________ _________________________________________________________ _________________________________________________________ Regency U39 ULTIMATE Direct Vent Freestanding Gas Stove...
- Page 37 _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ ____________________________________________________________ __________________________________________________________ ____________________________________________________________ _______________________________________________________ _____________________________________________________ __________________________________________________________ _________________________________________________________ _________________________________________________________ ______________________________________________________ ______________________________________________________ _______________________________________________________________ ___________________________________________________________ __________________________________________________________ ____________________________________________________________ ____________________________________________________________ ____________________________________________________________ _____________________________________________________________ __________________________________________________________ __________________________________________________________ _____________________________________________________ ________________________________________________________ _________________________________________________________ _________________________________________________________ Regency U39 ULTIMATE Direct Vent Freestanding Gas Stove...
- Page 38 _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ ____________________________________________________________ __________________________________________________________ ____________________________________________________________ _______________________________________________________ _____________________________________________________ __________________________________________________________ _________________________________________________________ _________________________________________________________ ______________________________________________________ ______________________________________________________ _______________________________________________________________ ___________________________________________________________ __________________________________________________________ ____________________________________________________________ ____________________________________________________________ ____________________________________________________________ _____________________________________________________________ __________________________________________________________ __________________________________________________________ _____________________________________________________ ________________________________________________________ _________________________________________________________ _________________________________________________________ Regency U39 ULTIMATE Direct Vent Freestanding Gas Stove...
-
Page 39: Warranty
It is the general practice of FPI to charge for larger, higher priced replacement parts and issue credit once the replaced component has been returned to FPI and evaluated for manufacturer defect. The authorized selling dealer is responsible for all in-field service work carried out on your Regency product. FPI will not be liable for results or costs of workmanship from unauthorized service persons or dealers. - Page 40 Dealer Name & Address: ________________________________________________ ______________________________________________________________________ Installer: ______________________________________________________________ Phone #: ______________________________________________________________ Date Installed: _________________________________________________________ Serial No.: _____________________________________________________________ Regency and Ultimate are trademarks of FPI Fireplace Products International Ltd. © Copyright 2005, FPI Fireplace Products International Ltd. All rights reserved. Printed in Canada...
Need help?
Do you have a question about the ULTIMATE U39-LP and is the answer not in the manual?
Questions and answers