Addison RC/FC Series Installation Operation & Maintenance page 4

RC/FC Series Installation, Operation, and Maintenance Manual
Table of Figures and Tables:
Figures:
Figure 1: Label Placement Drawing .................................. 6
Figure 2: Air Handler Clearances ......................................11
Figure 3: Condensing Section Clearances ..................12
Figure 4: Unit Lifting ................................................................17
Figure 5: Unit Installation Example ..................................18
Figure 6: Lineset Piping with the Air Handler Above
the Condensing Unit ..............................................................29
Figure 7: Lineset Piping with the Air Handler Below
the Condensing Unit ..............................................................30
Figure 8: Circuit Diagram for Standard Compressor
Cooling Only ................................................................................31
Figure 9: Circuit Diagram for Standard Compressor
with Hot Gas Reheat ..............................................................32
Figure 10: Circuit Diagram for Standard Compressor
with Heat Pump Operation and Hot Gas Reheat ....33
Figure 11: Circuit Diagram for Standard Compressor
with Heat Pump Operation, Hot Gas Reheat,
and Subcooling .........................................................................34
Figure 12: Example Electrical Wiring Diagram ..........36
Figure 13: VFD Control Kit Wiring ....................................41
Figure 14: Phase Monitor Data ..........................................43
Figure 15: Typical Air Handler Wiring Diagram ........45
Figure 16: Equipment Touch Display ..............................48
Figure 17: P-Trap Configuration .........................................51
Tables:
Table 1: Recommended Torque Settings .......................14
Table 2: Unit Weights ..............................................................16
Table 3: Lineset Recommended Sizes ..........................22
Table 4: Equivalent Lengths of Fittings and Valves 28
Table 5: Low Voltage Wiring Lengths ............................35
Table 6: FCRA/H Air Handler Standard
Electric Heaters ........................................................................ 47
Table 7: FCOA/H Air Handler Standard
Electric Heaters ........................................................................ 47
Table 8: Hot Water Heating Coil Flow Rate ................54
Table 9: Superheat and Subcooling - 100% OA .......54
Table 10: Superheat and Subcooling - Recirc............54
Table 11: Superheat and Subcooling - Heat Pump ..54
Table 12: Refrigerant Temperature-Pressure ..............55
Table 13: Maintenance Guidelines ...................................64
Table 14.1: Supply Fan.............................................................68
Table 14.2: Compressor .........................................................69
Table 14.3: Refrigeration Circuit .........................................71
Table 14.4: Variable Speed Heat Pressure Control .. 73
Table 14.5: Electric Heater ................................................... 75
Page 4 of 80