Storage - Nexsys Blocs Installed In Equipment; Capacity; Transportation - EnerSys Nexsys 12NXS26 Technical Manual

STORAGE – NEXSYS BLOCS INSTALLED IN EQUIPMENT
Some equipment will continue to draw very low power loads from the bloc when not in
service. This results in bloc self discharge rates greater than shown in Figure 1 and
described in the previous section. Consequently, all sources of electrical power drain must
be removed from the bloc whilst in transit, storage or extended periods of time out of
service. This includes disconnecting the Wi-iQ® (if fitted) & LVA from the bloc.
Failure to comply with the above will result in premature bloc failure and will render the
warranty void
Also refer to comments in opportunity charging section relating to short storage periods
between equipment usage.

CAPACITY

The nominal capacity of the NexSys® bloc series is rated in Ah at the 5 hour discharge rate.
Table 2 provides these ratings and additional C6 and C20 capacity discharge ratings.
Monobloc
@ 30°C/77°F 1.7VPC
Type
12NXS26
12NXS36
12NXS38
12NXS50
12NXS61
12NXS62
12NXS85
12NXS86
12NXS90
12NXS120
12NXS137
12NXS157
12NXS166
12NXS186
Table 2

TRANSPORTATION

NexSys blocs are classified as "non-spillable wet electric storage blocs" and may be shipped
by air or ground transportation without restriction.
NexSys blocs are in compliance with requirements of:
1. US Dept of Transportation - 49 CFR Section 173.159 para d
2. ICAO/IATA Packing Instruction 872, Special Provision A67
3. IMDG Class 8, UN ID 2800 special provisions 238
4. ADR 2011 and RID 2011 Special Provisions 238, 295 and 598
and are classified as Non-spillable and exempt from hazardous goods regulations when
securely packed and protected against short circuits.
C5 Capacity Rating
26
36
38
50
61
62
85
86
90
120
137
157
166
186
C6 Capacity Rating
@ 25°C/77°F 1.75VPC
26
36
38
50
61
62
85
86
90
120
137
157
166
186
7
NexSys Technical Manual
C20 Capacity Rating
@ 25°C/77°F 1.75VPC
29
40
40
55
66
69
103
100
95
130
152
184
186
210