Koninklijke Philips Electronics N.V. or their respective owners. TP Vision Netherlands B.V. reserves the right to change products at any time without being obliged to adjust earlier supplies accordingly. PHILIPS and the PHILIPS’ Shield Emblem are used under license from Koninklijke Philips Electronics N.V.
EN 2 TPM16.1E LA Revision List 1. Revision List Manual xxxx xxx xxxx.0 2017/10/20 • First release. • Chapter 6: Updated the PSU standby output value. • Chapter 10: Updated the PSU standby output value. Manual xxxx xxx xxxx.1 •...
Page 3
Technical Specs, Diversity, and Connections TPM16.1E LA EN 3 Connections Side Connectors Rear Connectors SERV .U HDMI 2 ARC TV ANTENNA USB 2 USB 1 NETWORK DIGITAL AUDIO OUT HDMI 1 MHL CVBS/Y 20220_001.eps Figure 2-1 Connection overview Note: The following connector colour abbreviations are used 4- HDMI1 MHL: Digital Video - In, Digital Audio with ARC - (acc.
Page 4
EN 4 TPM16.1E LA Technical Specs, Diversity, and Connections 2.3.2 Rear Connections 8 - Service / UART - Ground - UART_TX Transmit 6 - TV ANTENNA - In - UART_RX Receive Signal input from an antenna, cable or satellite. 9 - Cinch: Digital Audio - Out...
Spare Parts the following points: • Route the wire trees correctly and fix them with the For the latest spare part overview, consult your Philips Spare mounted cable clamps. Part web portal. • Check the insulation of the Mains/AC Power lead for external damage.
Page 6
EN 6 TPM16.1E LA Precautions, Notes, and Abbreviation List result in sets which have the same CTN (Commercial Type 6 = play 16 : 9 format, 12 = play 4 : 3 Number; e.g. 28PW9515/12) but which have a different B.O.M.
Page 7
Precautions, Notes, and Abbreviation List TPM16.1E LA EN 7 Digital Noise Reduction: noise The SDI signal is self-synchronizing, reduction feature of the set uses 8 bit or 10 bit data words, and has DRAM Dynamic RAM a maximum data rate of 270 Mbit/s,...
Page 8
SOPS Self Oscillating Power Supply Serial Peripheral Interface bus; a 4-wire synchronous serial data link standard S/PDIF Sony Philips Digital InterFace SRAM Static RAM Service Reference Protocol Small Signal Board Spread Spectrum Clocking, used to reduce the effects of EMI...
Mechanical Instructions TPM16.1E LA EN 9 4. Mechanical Instructions Index of this chapter: Notes: 4.1 Cable Dressing • Figures below can deviate slightly from the actual situation, 4.2 Service Positions due to the different set executions. 4.3 Assembly/Panel Removal 4.4 Set Re-assembly...
Page 10
EN 10 TPM16.1E LA Mechanical Instructions ECN701 CN8603 CN168 CN9101 MAIN POWER SUPPLY (1053) (1054) LOUDSPEAKER LOUDSPEAKER (1184) WIFI Module (1184) (WiFi01) IR/LED BOARD (1056) 20220_100.eps Figure 4-2 Cable dressing (43" 5301 series) ECN701 CN8603 CN9101 CN168 MAIN POWER SUPPLY...
Page 11
Mechanical Instructions TPM16.1E LA EN 11 Service Positions 4.3.1 Rear Cover For easy servicing of a TV set, the set should be put face down on a soft flat surface, foam buffers or other specific workshop Refer to Figure 4-4 Figure 4-5 for details.
Page 12
EN 12 TPM16.1E LA Mechanical Instructions 4.3.2 Keyboard Control unit 3. Gently take the keyboard out. Refer to Figure 4-6 details. When defective, replace the whole unit. 1. Unplug the connector [2] from the keyboard control panel. 2. Remove the fixation screws [1] that secure the keyboard 20050_106.eps...
Page 13
Mechanical Instructions TPM16.1E LA EN 13 3. The PSU can be taken out of the set now. 4.3.5 Speakers 1. Gently release the tapes that secure the speaker cables. 2. Unplug the speaker connector from the SSB. 3. Take the speakers out.
EN 14 TPM16.1E LA Service Modes, Error Codes, and Fault Finding 5. Service Modes, Error Codes, and Fault Finding Index of this chapter: • X is the main version number: this is updated with a major 5.1 Service Modes change of specification (incompatible with the previous 5.2 Stepwise Start-up...
Page 15
Service Modes, Error Codes, and Fault Finding TPM16.1E LA EN 15 Main Menu Sub-menu 1 Sub-menu 2 Description Clear Codes Press [OK] to clean the Error Codes Erases the contents of the error buffer. Select this menu item and press the MENU immediately RIGHT key on the remote control.
Page 16
EN 16 TPM16.1E LA Service Modes, Error Codes, and Fault Finding Default value Item Item value 32" 43" 49" Description NVM VALUE Displays the value at the NVM address of item 5 NVM STORE Press OK Use this option to save the data of item 6 to NVM address of item 5...
Page 17
Service Modes, Error Codes, and Fault Finding TPM16.1E LA EN 17 • 1.2 Production code Displays the production code (the serial number) of the TV. Note that if an NVM is replaced or is initialized after corruption, this production code has to be re-written to NVM.
Page 18
EN 18 TPM16.1E LA Service Modes, Error Codes, and Fault Finding Stepwise Start-up Standby Soft Mode Command Received, Switch previously in Standby Off(Mains Soft Mode (Power tact Standby Power Plug) switch) Digital Digital background background tasks started tasks completed TV Wakeup...
Page 19
It is possible for the user to upgrade the main software via the USB port. This allows replacement of a software image in a stand alone set. A description on how to upgrade the main software can be found in the DFU or on the Philips website. 5.4.2 Introduction 19080_207_110324.eps...
Page 20
EN 20 TPM16.1E LA Service Modes, Error Codes, and Fault Finding 5.4.6 Content and Usage of the One-Zip Software File Below you find a content explanation of the One-Zip file, and instructions on how and when to use it. Only files that are relevant for Service are mentioned here.
Page 21
Service Modes, Error Codes, and Fault Finding TPM16.1E LA EN 21 Error Codes 5.5.2 How to Read the Error Buffer 5.5.1 Introduction You can read the error buffer in three ways: • On screen via the SAM/CSM (if you have a picture).
Page 22
EN 22 TPM16.1E LA Service Modes, Error Codes, and Fault Finding The Blinking LED Procedure 5.7.3 No Picture 5.6.1 Introduction When you have no picture, first make sure you have entered the correct display code. See paragraph 6.4 Option Settings the instructions.
Alignments TPM16.1E LA EN 23 6. Alignments Index of this chapter: In case you have a colour analyser: 6.1 General Alignment Conditions • Measure with a calibrated (phosphor- independent) color 6.2 Hardware Alignments analyser (e.g. Minolta CA-210) in the centre of the screen.
Page 24
EN 24 TPM16.1E LA Alignments Option Settings In case of a display replacement, reset the “Operation hours display” to “0”, or to the operation hours of the replacement display. 6.4.1 Introduction Remark: - After the NVM has been replaced, go to SAM and scroll to the The microprocessor communicates with a large number of I <Reload MAC address>...
7. Circuit Descriptions Index of this chapter: Introduction 7.1 Introduction The TPM16.1E LA is a new chassis launched in Europe in 7.2 Power Supply 2016. The whole range is covered by MT5800 platform. 7.3 DC/DC Converters The major deltas versus its predecessor support DVB-T/C;...
Page 26
EN 26 TPM16.1E LA Circuit Descriptions 7.1.3 SSB Cell Layout COMMON INTERFACE DC/DC MT5800 HDMI HDMI TUNER NETWORK SPDIF OUT ANALOG I/O Headphone 20220_200.eps Figure 7-1 SSB layout cells (top view) back to 2016-Nov-11 div.table...
Page 27
- direct-view LED with 2D-dimming: PSDL power panel. specifications! This part is available in the regular market. Consult the Philips Service web portal for the order codes of the boards. PSL stands for Power Supply with integrated LED-drivers.
Page 28
EN 28 TPM16.1E LA Circuit Descriptions • LDO_PWR,DVDD3V3, voltage for EMMC when TV on Connector • VCCK, voltage for DDR when TV on Number CN9101 CN8602 CN9101 CN8603 • AVD3V3,AVDD1V0, supply voltage for scaler MT5593 Description to SSB to panel...
Page 29
Circuit Descriptions TPM16.1E LA EN 29 7.3.1 Power layout SSB U712, 3V3SB U705,AVDD3V3 FB702,+5V_SW FB603,PVDD L703, Vcck U702, Tuner 3.3V D704,LNB Power 20220_204.eps Figure 7-4 Power SSB Top View back to 2016-Nov-11 div.table...
Page 30
EN 30 TPM16.1E LA Circuit Descriptions U707,+1.8V L702,DDRV 20220_205.eps Figure 7-5 Power SSB Bottom View Front-End Analogue and DVB-T/T2, DVB-C; DVB S/S2, ISDB-T reception ST42CS-2-E 7.4.1 Front-End Analogue and DVB T/C reception The Front-End for analogue tuner consist of the following key...
Page 31
Circuit Descriptions TPM16.1E LA EN 31 7.4.2 DTV T2 reception HDMI Refer to figure 7-9 HDMI input configuration for the application. The Front-End for DVT part consist of the following key components: • TUNER EUROPE ST42CS-2-E • SCALER MT5800WUEJ BGA-597 Processor MT5800 •...
Page 32
EN 32 TPM16.1E LA Circuit Descriptions recovers great details for still pictures.The special color processing technology provides a natural, deep colors and true studio quality video. Moreover, the MT5800WUEJ family has built-in high resolution and high-quality audio codec.Rich Features for High Value Products: The MT5800WUEJ family enables true singlechip experience.
IC Data Sheets TPM16.1E LA EN 33 8. IC Data Sheets This chapter shows the internal block diagrams and pin configurations of ICs that are drawn as “black boxes” in the electrical diagrams (with the exception of “memory” and “logic”...
Page 34
EN 34 TPM16.1E LA IC Data Sheets Pinning Information AVDD1 CI_MDI CI_MDO CI_MDO PVR_TS USB_D CI_A6 CI_A7 CI_A12 CI_A11 CI_MDO4 2_HDM M_P0 CI_MDI CI_MC PVR_TS USB_DP CI_A5 CI_RST CI_A9 CI_D6 CI_D5 CI_D4 DATA0 CI_MDI CI_MD CI_MDO PVR_TS SPI_CL USB_D USB_D...
Page 35
IC Data Sheets TPM16.1E LA EN 35 Diagram 10-3-3 Peripheral, B03, MP8124GD (IC U202) Block diagram MP8124 Pinning information 20030_305.eps Figure 8-3 Internal block diagram and pin configuration back to 2016-Nov-11 div.table...
Page 36
EN 36 TPM16.1E LA IC Data Sheets Diagram 10-3-5 Video Interface/YPbPr/CVBS, B05, AD87588 (IC U601) Block diagram AD87588 Pinning information 19790_301.eps Figure 8-4 Internal block diagram and pin configuration back to 2016-Nov-11 div.table...
Circuit Diagrams and PWB Layouts TPM16.1E LA EN 42 10.2 A 715G7574 PSU 10-2-1 AC input AC input HS9801 H O T HS9901 BD9901 C O L D TS10K80-01 R9128 +12V 100 OHM 1/4W D9802 D9803 C9114 R9142 Q9108 470UF 25V...
Page 43
Circuit Diagrams and PWB Layouts TPM16.1E LA EN 43 10-2-2 Power layout top CN9101 CN8603 J909 J901 J903 J905 HS9111 C9310 C9114 J917 J907 D9121 D9111 C8601 FB9301 L9301 L8602 J921 J913 C9121 C9122 C9111 L9100 C8608 C8609 D8601 J930...
Circuit Diagrams and PWB Layouts TPM16.1E LA EN 45 10.3 B 715G8198 SSB 10-3-1 System Power 1 System Power 1 DC POWER INPUT +12V to +5V_SW CN701 12V_AUDIO +12V 12V_AL STB_PWR STB_PWR 12V_AL +12V 12V_AUDIO 3V3SB +12V OPWRSB: FB701 Normal: High...
Page 46
Circuit Diagrams and PWB Layouts TPM16.1E LA EN 46 10-3-2 System Power 2 System Power 2 Panel VCC=12V or 5V +5V_SW +12V PANEL_VCC R761 USB POWER C754 47pF 50V 0R05 1/16W FB713 FB714 R759 100K 1% PANEL VCC FB713 FB714...
Page 47
Circuit Diagrams and PWB Layouts TPM16.1E LA EN 47 10-3-3 Peripheral Peripheral U401-6 OPWRSB 3V3SB 3,4,17 OPWRSB U0TX SY S_EEPROM_WP Reset U0TX SY S_EEPROM_WP U0RX DVDD3V3 OSCL0 U0RX OSCL0 OSDA0 OSDA0 OSDA0 AE26 OPCTRL3 OSDA0 OPCTRL3 AH26 OSCL0 POWE__B R4002...
Page 48
Circuit Diagrams and PWB Layouts TPM16.1E LA EN 48 10-3-4 Audio Interface Audio Interface PWRDN-HP PWRDN-HP U401-3 AR1_ADAC AR1_ADAC AL1_ADAC Analog Power AL1_ADAC AR0_ADAC AIN_R0 HS601 AR0_ADAC AIN_R0 AIN_R0 AL0_ADAC AIN_L0 AIN_R0 AL0_ADAC AIN_L0 AIN_L0 AVDD3V3 AIN_L0 AIN_R1 AR1_ADAC AIN_R1...
Page 49
Circuit Diagrams and PWB Layouts TPM16.1E LA EN 49 10-3-5 Video Interface/YPbPr/CVBS Audio/Video IO/SPDIF Video Interface/YPbPr/CVBS U401-4 OSCL1 OSCL1 OSDA1 OSDA1 ADCINP_DEMOD HSY NC YPbPr & Audio IN ADCINP_DEMOD HSY NC ADCINN_DEMOD VSY NC CVBS2P ADCINN_DEMOD VSY NC CVBS2P AVDD12_DEMOD...
Page 50
Circuit Diagrams and PWB Layouts TPM16.1E LA EN 50 10-3-6 SCART SCART SOY 1 CVBS IN SOY 1 Y 1P Y 1P COM1 SCART (Half SCART) -- CVBS+SV+RGB COM1 PB1P PB1P C1020 PR1P R1019 PR1P SCT2_AV_IN CVBS2P SCART_FS0 C1021 SCART NC_2016-0305...
Page 64
Circuit Diagrams and PWB Layouts TPM16.1E LA EN 64 10-4-2 IR/LED board layout Layout LED Board (top side) Q301 U201 Layout LED Board (bottom side) CN201 2012-10-26 LED Board 715G7055 layout top/bottom 19791_501.eps back to 2016-Nov-11 div.table...
Circuit Diagrams and PWB Layouts TPM16.1E LA EN 65 10.5 E 715G7088 Keyboard control panel 10-5-1 CN01 CN01 KEY1 CONN CONN 0.1uF 50V 0.1uF 50V TACT SW 6P TACT SW 6P SW01 SW01 Right Center Down Left 2014-05-28 Keyboard control panel 715G7088 19791_502.eps...
Page 66
Circuit Diagrams and PWB Layouts TPM16.1E LA EN 66 10-5-2 Key board layout Layout Keyboard control panel (top side) SW01 Layout Keyboard control panel (bottom side) 2014-06-06 Keyboard control panel 715G7088 layout top/bottom 19791_503.eps back to 2016-Nov-11 div.table...