Important Safety - ION 30ACi+ Operation Manual

30ACi+, 30ACi Deluxe,
35ACi+ and 35ACi Deluxe
Battery Backup System
I
ntroductIon
Reasonable care and safe methods should be
practiced. Check local codes and requirements
before installation. This manual contains important
information for the safe use of this product. Read
this manual completely before using this product and
refer to it often for continued safe product use.
Note: This manual covers the installation of the
inverter, regardless of what pump, switch or
controller combination is included in the system you
purchased. For more detailed installation information
and troubleshooting regarding the pump, switch or
controller, please refer to their individual manuals.
Although the inverters for the 30ACi and 35ACi
systems are slightly different, they both operate on 12
volts with identical connections.
DO NOT THROW AWAY OR LOSE THIS MANUAL.
Keep it in a safe place so that you may refer to it when
needed.
I S
mportant afety
Before proceeding further, kindly go through the
safety instructions carefully.
Always disconnect the unit from the receptacle power
source and battery before handling or making any
adjustments to the system.
Battery Backup Warning:
WARNING: Risk of electrical shock this unit
has not been investigated for use in outdoor
areas.
WARNING: Risk of electrical shock. Connect
only to a properly grounded, three pronged
grounding type receptacle. Under any circumstances,
do not remove the grounding prong from the power
cord.
WARNING: Do not smoke, use spark able
electrical devices or open flame when working
on this unit!
WARNING: Do not install unit in locations
classified as hazardous per N.E.C., ANSI/
NFPA 70 - 1999.
Register your product at www.sumpro.com
I
nStrutIonS
OPERATION MANUAL
Dated: 02/10/2015
Document Name: 30-35ACi+&Deluxe_OM
FAILURE TO HEED ABOVE CAUTIONS COULD
RESULT IN INJURY OR DEATH.
WARNING: These systems are designed to
operate only one pump at a time, the one(s)
supplied with the unit. Using anything other than the
pump supplied with the system will cause damage to
the unit and void the warranty.
General Precautions
Before using the inverter, read all instructions and
caution markings on the inverter, the batteries & all
appropriate sections of this instruction manual.
WARNING: Do not expose the inverter to any
type of chemicals. The inverter is designed
for interior use only.
WARNING: Do not disassemble the inverter;
take it to a qualified service center when
service or repair is required. Opening by unqualified
personnel can lead to electrical shock or fire hazard
and void the warranty.
To reduce risk of electric shock, disconnect all wiring
before cleaning.
WARNING: Avoid exposing the inverter or
batteries to any type of explosive gases (in
the vicinity, as batteries generate explosive gases
during normal operation). Provide proper ventilation.
The battery enclosures should be designed to prevent
accumulation and concentration by hydrogen gas in
"pockets" at the top of the compartment. Vent the
battery compartment from the highest point. A sloped
lid can also be used to direct the flow to the vent
opening location. To reduce the risk of the battery
explosion, follow all the instructions of the battery
supplier or any equipment you intend to use in the
vicinity of batteries.
WARNING: Use the correct insulated tools to
make AC/DC wiring connections.
WARNING: Do not install this inverter on or
near flammable
chemicals, gas online etc.)
Page 2 of 12
materials (plywood,