Engine & Pump Warranty - Goldacres Batchmate Operator's & Parts Manual

SYMPTOM
Pump takes in
water, little or no
discharge.
Suction hose leaks
at inlet
Discharge hose
does not stay on
coupling.
Impeller does not
turn, pump is hard
to start.
Engine & Pump
Warranty
Aussie QP 5 year warranty
Australian Pump warrants all Aussie QP self
priming centrifugal pumps, whether used for
domestic or commercial applications, to be
free of faulty workmanship or material for a
period of 5 years from the date of supply to
the end user.
Aussie will replace or repair, at our discretion,
any faulty pump free of charge subject to the
following conditions.
Engine Warranty
Warranty for engines fitted to Aussie Pump
products is the responsibility of the engine
manufacturer or his representative and subject
to their terms and conditions, and operating
instructions included with the product.
The Aussie Pump 5 year warranty naturally
does not cover the following:-
1. Normal wear and tear, misuse, improper
installation, negligent handling, failure to
follow operating instructions or to carry
out maintenance.
2. Pumping of chemicals, salt or corrosive
fluids.
3. Unauthorised repair or attempted repair
(i.e. not authorised by Australian Pump)
POSSIBLE PROBLEM
Engine speed too low?
Suction strainer partially plugged? Clean strainer
Impeller/volute worn?
Fittings/clamps are not sealed
properly?
Hose diameter is too large?
Pressure too high?
Hose kinked or end blocked?
Impeller jammed or blocked?
Impeller and volute binding?
SOLUTION
Increase throttle speed
Adjust clearance by adding shims or
replace impeller/volute
Tighten, replace or add clamp. (Keep
extra seals on pump)
Use smaller diameter hose or replace
hose
Check pressure, add additional clamp
Check hose
Open pump cover and clean dirt and
debris from inside housing
Adjust clearance by removing shim
from behind impeller
4. Shipping or transit damage
5. Use of non-genuine parts.
The warranty is valid only for the original
consumer purchaser and non transferable.
NOTE:- This warranty is limited to the cost of
the product and does not include third party
costs including pump installers, plumbers
etc. unless expressly authorised by Australian
Pump Industries in writing.
Contact your Goldacres Dealer to arrange a
warranty claim
10