Operation - Hyundai HY3000CI User Manual

5.

OPERATION

ADDING OIL & PETROL TO THE ENGINE
5.1
Be sure the generator is on a leveled surface and the generator has stopped.
5.2
Remove the oil filler cap, and then clean it with cloths Reinsert it into the crankcase, and take
out to check oil level, If the oil level reduces at the bottom of the oil filler cap, add the engine
oil. Using non-detergent or 2-stroke oil could shorten the engines working life.
5.3
ONLY fill the fuel to a level 15mm lower than the top of the fuel tank. DO NOT OVERFILL.
5.4
Use the dipstick to check the oil level. Use SAE10w30 or 15w40 engine oil. Fill to the correct
level before use.
5.5
The engine is shipped without oil. Fill to the top of the oil filler neck before use. Operating the
engine with no oil or oil at low level will cause serious internal damage to the engine, this is
not covered under warranty.
5.6
Carefully use and store the engine oil, avoid getting dirt or dust into the engine oil.
5.7
Mixing different kinds of engine oil is prohibited.
5.8
Before the engine oil reduces below the safety margin, low oil alert system will close the
engine automatically. The oil alert indicator light (red) will be on. (To avoid the inconvenience
caused by unexpected stopping, it is still advisable to check the engine oil level regularly).
5.9
Use unleaded petrol, never use stale or contaminated petrol or an oil/gasoline mixture.
5.10
Avoid getting dirt or water into the fuel tank. DO NOT use a mixture of petrol containing
ethanol or methanol; otherwise, it will seriously damage the engine.
5.11
DO NOT overfill the fuel tank (no fuel above the red upper limit mark). After refueling, make
sure the fuel cap is closed properly and securely.
5.12
DO NOT spill fuel around the fuel tank before starting the engine.
5.13
DO NOT use the machine if you are tired, consumed alcohol, or if you are taking other drugs
or medication that can affect your vision, judgement or coordination.
5.14
NEVER use the machine indoors or in spaces lacking proper ventilation.
5.15
Naked flames or sparks in the vicinity of the machine are strictly forbidden. Petrol is extremely
flammable and carelessness in handling can result in personal injury of fire.
5.16
NEVER use a machine with a deflective exhaust/muffler.
5.17
In very warm and dry climates, generator operation will pose a greater risk of starting fires.
14