Table of Contents
Advertisement
Models:
GO24-IPI-NG or LP-HK
GO30-IPI-NG or LP-HK
GO318-IPI-NG or LP-HK
GO324-IPI-NG or LP-HK
GO330-IPI-NG or LP-HK
Grand Oak Hearth Kits
Check with your local building code agency before you begin installation to ensure compliance with local codes, including
the need for permits and follow-up inspections. If you encounter any problems regarding code approvals, or if you need
clarification of any of the instructions contained here, contact the Technical Services Dept., Hearth & Home Technologies
Inc., www.hearthnhome.com.
•
Important operating
a n d m a i n t e n a n c e
instructions included.
WARNING
If the information in these instruc-
tions is not followed exactly, a
fire may result causing property
damage, personal injury, or death.
• Do not store or use gasoline or other flam-
mable vapors and liquids in the vicinity of
this or any other appliance.
• What to do if you smell gas:
- Do not try to light any appliance.
- Do not touch any electrical switch. Do not
use any phone in your building.
- Immediately call your gas supplier from
a neighbor's phone. Follow the gas
supplier's instructions.
- If you cannot reach your gas supplier, call
the fire department.
• Installation and service must be performed
by a qualified installer, service agency, or
the gas supplier.
Hearth & Home Technologies • Grand Oak Hearth Kits • 4004-323 Rev B . 8/2018
CAUTION
DO NOT DISCARD THIS MANUAL
Read, understand
•
and follow these
instructions for safe
i n s t a l l a t i o n a n d
operation.
•
•
•
•
• Keep clothing, furniture, draperies and other
In the Commonwealth of Massachusetts:
•
•
•
Installation and service of this
appliance should be performed by
qualified personnel. Hearth & Home
Technologies suggests NFI certified
or factory-trained professionals,
o r t e c h n i c i a n s
s u p e r v i s e d b y
an NFI certified
professional.
Leave this manual with
•
party responsible for
use and operation.
WARNING
HOT! DO NOT TOUCH.
SEVERE BURNS MAY RESULT.
CLOTHING IGNITION MAY RESULT.
Glass and other surfaces are hot during
operation and cool down.
Keep children away.
CAREFULLY SUPERVISE children in same room as
appliance.
Alert children and adults to hazards of high
temperatures.
Do NOT operate with protective barriers removed.
combustibles away.
This appliance must be installed by a licensed plumber
or gas fitter.
The chimney flue damper, when used with gas logs, will
be welded open or completely removed.
A CO detector shall be installed in the room where the
appliance is installed.
Installation
Instructions
1
Advertisement
Table of Contents
Related Manuals for Hearth and Home Technologies GO318-IPI-NG
Summary of Contents for Hearth and Home Technologies GO318-IPI-NG
- Page 1 Hearth & Home GO30-IPI-NG or LP-HK Technologies suggests NFI certified GO318-IPI-NG or LP-HK or factory-trained professionals, GO324-IPI-NG or LP-HK o r t e c h n i c i a n s s u p e r v i s e d b y...
-
Page 2: Homeowner Reference Information
Read this manual before installing or operating this appliance. Please retain this owner’s manual for future reference. Congratulations Congratulations on selecting a Hearth & Home Technologies The information contained in this owner’s manual, unless gas log set—an elegant and clean alternative to burning noted otherwise, applies to all models and gas control wood. -
Page 3: Design And Installation Considerations
Review proper placement of logs, rockwool, lava rock A. Design and Installation Considerations and vermiculite. The Gas Log Hearth Kit consists of the following: Check the wiring. Ensure there are no gas leaks. • Log Set (sold separately) Ensure the flow of combustion and ventilation air is not •... -
Page 4: Appliance Certification
• This appliance must have a screen in place while the WARNING appliance is in operation and, unless other provisions for combustion air are provided, the screen shall have an Do NOT use this appliance if any part has been under opening for introduction of combustion air. -
Page 5: Negative Pressure
G. Negative Pressure WARNING Negative pressure results from the imbalance of air avail- able for the fireplace to operate properly. Causes for this Asphyxiation Risk imbalance include: This appliance produces carbon monoxide • Exhaust fans (kitchen, bath, etc.). (CO). • Range hoods. -
Page 6: Inspect The Appliance And Components
H. Inspect the Appliance and Components Figure 3A Control Box for IPI • Remove the contents from the carton labeled “Burner”. Attached to the burner are tags identifying the manufacturer name, serial number, model number (including gas log size), BTU ratings, gas type, etc. •... - Page 7 Tightly pack dime sized pieces of rock wool around the vertical part of the carry over tube to aid lighting Note: For best results, do not pack down the rock wool except around the carry over tube. The placement of rock the bottom burner pan.
- Page 8 WARNING Fire Risk Pour vermiculite into each burner pan to the point where Explosion Risk each pan is completely full. Level the vermiculite from right Personal Injury Risk to left to ensure an even flame pattern. See figure 6. Failure to position the parts in accordance with the diagrams provided with the log packages or failure to use only parts approved with this appliance may result in...
-
Page 9: Inspect The Venting System
A spillage test must be made before the installed appliance is left with the consumer. K. Inspect the Venting System • Close all doors and windows in the home. The fireplace venting system is designed and constructed to • Light the log set (see Lighting Instructions). develop a positive flow adequate to remove flue gases to the •... -
Page 10: Cleaning And Maintenance Instructions
Cleaning M. Cleaning and Maintenance Instructions • Periodic examination and cleaning of the venting system Always remember: of the fireplace should be done before initial use and at • Do not place any combustible material near the least annually by a qualified agency. appliance. -
Page 11: Lighting Instructions (Ipi)
N. Lighting Instructions • IPI Pilot Valve (IPI) FOR YOUR SAFETY READY BEFORE LIGHTING WARNING: If you do not follow these instructions exactly, a fire or explosion may result causing property damage, personal injury or loss of life. A. This appliance is equipped with an intermittent Pilot ignition (IPI) device which automatically lights the burner. -
Page 12: Service Parts
IMPORTANT: THIS IS DATED INFORMATION. Parts must be ordered from a dealer or distributor. Stocked Hearth and Home Technologies does not sell directly to consumers. Provide model number and serial number when requesting service parts from your dealer or distributor. - Page 13 IMPORTANT: THIS IS DATED INFORMATION . Parts must be ordered from a dealer or Stocked Hearth and Home Technologies does not sell directly to consumers distributor. . Provide model number and serial number when requesting service parts from your dealer or distributor.
- Page 14 IMPORTANT: THIS IS DATED INFORMATION . Parts must be ordered from a dealer or Stocked Hearth and Home Technologies does not sell directly to consumers distributor. . Provide model number and serial number when requesting service parts from your dealer or distributor.
- Page 15 IMPORTANT: THIS IS DATED INFORMATION . Parts must be ordered from a dealer or Stocked Hearth and Home Technologies does not sell directly to consumers distributor. . Provide model number and serial number when requesting service parts from your dealer or distributor.
- Page 16 IMPORTANT: THIS IS DATED INFORMATION . Parts must be ordered from a dealer or Stocked Hearth and Home Technologies does not sell directly to consumers distributor. . Provide model number and serial number when requesting service parts from your dealer or distributor.
- Page 17 IMPORTANT: THIS IS DATED INFORMATION . Parts must be ordered from a dealer or Stocked Hearth and Home Technologies does not sell directly to consumers distributor. . Provide model number and serial number when requesting service parts from your dealer or distributor.
- Page 18 IMPORTANT: THIS IS DATED INFORMATION . Parts must be ordered from a dealer or Stocked Hearth and Home Technologies does not sell directly to consumers distributor. . Provide model number and serial number when requesting service parts from your dealer or distributor.
- Page 19 IMPORTANT: THIS IS DATED INFORMATION . Parts must be ordered from a dealer or Stocked Hearth and Home Technologies does not sell directly to consumers distributor. . Provide model number and serial number when requesting service parts from your dealer or distributor.
- Page 20 IMPORTANT: THIS IS DATED INFORMATION . Parts must be ordered from a dealer or Stocked Hearth and Home Technologies does not sell directly to consumers distributor. . Provide model number and serial number when requesting service parts from your dealer or distributor.
- Page 21 IMPORTANT: THIS IS DATED INFORMATION. Parts must be ordered from a dealer or distributor. Stocked Hearth and Home Technologies does not sell directly to consumers. Provide model number and serial number when requesting service parts from your dealer or distributor.
- Page 22 Y. Fequently Asked Questions Can I close the glass doors on my fireplace when using my hearth kit? No. The gas hearth kits are designed for use in fireplaces with all fireplace doors fully opened. Operating your hearth kit with the doors closed will cause overheating, premature failure of valve systems, and will void the warranty of your log set.
- Page 23 Hearth & Home Technologies • Grand Oak Hearth Kits • 4004-323 Rev B . 8/2018...
- Page 24 Hearth & Home Technologies • Grand Oak Hearth Kits • 4004-323 Rev B . 8/2018...
-
Page 25: Contact Information
Contact Information Please contact your Hearth & Home Technologies dealer with any questions or concerns. For the number of your nearest Hearth & Home Technologies dealer, please call 1-800-927-6841 or 1-888-427-3973. - NOTES - CAUTION DO NOT DISCARD THIS MANUAL Read, understand Leave this manual with •...
Need help?
Do you have a question about the GO318-IPI-NG and is the answer not in the manual?
Questions and answers