Outdoor Grill Safety - Nexgrill 820-0062H Owner's Manual

Read the following instructions carefully before attempting to assemble, operate or install the product. Failure to follow these instructions
may result in serious bodily injury and/or property damage. If you have questions regarding the product or need after sales service or
support, please call your Barbeques Galore nearest store on 1300 301 392.
LP gas supply cylinder to be used must be constructed and marked in accordance with the specifications for LP gas cylinders that adhere
to national standards for the country of use.
1.
The appliance must be installed in accordance with the installation instructions provided herein, local gas fitting regulations,
municipal building codes, AS5601/AG 601 gas installation codes, and any other relevant statutory regulations.
2.
Tabletop grill is for outdoor use only. Grill should be operated in a well-ventilated space. Never operate in an enclosed
space, garage or building. Your grill is not intended to be installed in or on recreational vehicles and/or boats .
3.
Heated liquids remain at scalding temperatures long after the cooking process. Do not touch the cooking appliance until
liquids have cooled to 46.11 °C (115 °F) or lower.
4.
Do not install or use grill within 91.44 cm (36 in) of combustible materials from back and sides of grill. Grill shall not be
located under overhead surfaces (closed carport, garage, porch, patio) that can catch fire.
5.
Never attempt to attach this grill to the self-contained LP gas system of a camper trailer or motor home.
6.
It is the responsibility of the assembler/owner to assemble, install and maintain gas grill. Do not let children and pets
play near your tabletop grill. Do not let children operate this appliance. Failure to follow these instructions could result in
serious personal injury and/or property damage.
7.
Always open lid before lighting grill. When grill is not in use, close the LP gas cylinder valve.
8.
Carefully follow instructions in this manual for proper assembly and leak-testing of your grill. Do not use grill until leak
checked. If a leak is detected at any time, it must be stopped and corrected before using grill further.
9.
Appliance area should be kept clear and free from combustible materials, gasoline, bottled gas in any form and other
flammable vapours and liquids. Do not obstruct flow of combustion and ventilation air.
10.
Never try to light grill with lid closed! Buildup of gases is very dangerous and could cause an explosion.
11.
Keep any electrical cord or fuel supply hose away from heated surfaces.
12.
Propane is a flammable gas and improper handling may result in explosion and/or fire and serious accident or injury.
13.
This appliance will be hot during and after use. Use insulated oven mitts or gloves for protection from hot surfaces or
splatter from cooking liquids.
14.
Do not leave your grill unattended while in operation or still hot.
15.
Do not use while under the influence of drugs or alcohol.
16.
Do not store any spare LP (propane) cylinder, full or empty, under or near your grill.
17.
Appliance is not intended for commercial use or rental.
18.
The cylinder must be disconnected when the appliance is not in use. Disconnect at the cylinder. Do not disconnect hose
from the appliance.
19.
Do not spray aerosols in the vicinity of this appliance while it is in operation.
20.
Do not use or store flammable materials in or near this appliance.
21.
Do not place articles on or against this appliance.
22.
Do not modify this appliance.
Operate the grill only on a tabletop no higher than 82 cm and no lower than 60 cm.
Place the gas cylinder on the ground adjacent to the tabletop and with a minimum
clearance of 30.5 cm and no further than 61 cm from the grill.
Failure to follow these instructions could cause the propane cylinder to overheat and
vent propane, which could ignite, causing serious personal injuries or property damage
and/or a tripping hazard over the gas hose or propane tank, pulling the grill off the
tabletop, causing serious personal injuries or property damage.
THE FUEL SYSTEM: Gas grills are used safely by millions of people when following simple safety precautions.
The items in the fuel system are designed for operation with this grill. They must not be replaced with any other brand. (See parts list for
replacement items).
GAS BURNER: The gas burner is constructed of stainless steel and should not require maintenance other than inspection for insects/nests
inside the air intake slots.
LP GAS REGULATOR CAUTION: The gas pressure regulator provided with this appliance must be used. This regulator is set for the required
outlet pressure to safely operate this appliance.
FUEL SUPPLY HOSE: The hose-connected regulator provided with this appliance is 91.44 cm (3 ft) length. Keep the fuel hose away from any
heated surface(s).
PROPANE FUEL:
WARNING: Propane is a flammable gas. Improper handling may result in an explosion and/or fire and serious accident or injury. Your grill is
designed to operate with propane (LP) gas only and is equipped with the proper orifice for propane gas.
CAUTION: Do not connect this grill with any gas supply other than propane. Propane gas is heavier than air and settles in lower areas. Make
certain adequate ventilation is available when using your grill. The gas cylinder may be stored outside in a well-ventilated area out of the reach
of children when the grill is not in use.
IMPORTANT SAFETY INFORMATION

OUTDOOR GRILL SAFETY

61 CM MAX
30.5 CM MIN
WARNING:
82 CM
Hose is a trip
MAX
60 CM hazard
MIN
2