Download Print this page
Hayward Aqua Trol AQ-TROL-HP-TL Owner's Manual

Hayward Aqua Trol AQ-TROL-HP-TL Owner's Manual

Above ground pool chlorine generator
Hide thumbs Also See for Aqua Trol AQ-TROL-HP-TL:

Advertisement

Aqua Trol
Above Ground Pool Chlorine Generator
Owner's Manual
Hayward Pool Products
Hayward Pool Products
620 Division Street, Elizabeth NJ 07207
620 Division Street, Elizabeth NJ 07207
www.hayward.com
www.hayward.com
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
Contents
Introduction....................1
Water Chemistry..............2
Controls..........................7
Installation.....................9
Troubleshooting............13
AQ-TROL-RJ
AQ-TROL-RJ-TL
AQ-TROL-HP
AQ-TROL-HP-TL
092016 RevM

Advertisement

loading
Need help?

Need help?

Do you have a question about the Aqua Trol AQ-TROL-HP-TL and is the answer not in the manual?

Questions and answers

Brenda Procell
April 12, 2025

the manual switch on the timer (on/off/auto) needs to be tightened or replaced. When it is in the auto position and the time to end comes it drops to off and will not come back on. Have to manually turn on. Can this be tightened or does it need to be replaced? This is a Hayward Goldline AquaTrol Salt Chlorine Generator.

Subscribe to Our Youtube Channel

Summary of Contents for Hayward Aqua Trol AQ-TROL-HP-TL

  • Page 1: Table Of Contents

    Above Ground Pool Chlorine Generator Owner’s Manual Contents Introduction....1 Water Chemistry....2 Controls......7 Installation.....9 Troubleshooting....13 AQ-TROL-RJ AQ-TROL-RJ-TL AQ-TROL-HP AQ-TROL-HP-TL Hayward Pool Products Hayward Pool Products 620 Division Street, Elizabeth NJ 07207 620 Division Street, Elizabeth NJ 07207 www.hayward.com www.hayward.com USE ONLY HAYWARD GENUINE REPLACEMENT PARTS...
  • Page 2 3 meters of the pool, spa or hot tub shall be bonded to the equipment grounding bus with copper conductors not smaller than 8 AWG US / 6 AWG Canada. • NOTICE TO USERS: This control product is to be used only in accordance with the directions of this label. It is an offense under the Pest Control Products Act to use a control product under unsafe conditions. SAVE THESE INSTRUCTIONS • USE ONLY HAYWARD GENUINE REPLACEMENT PARTS...
  • Page 3: Introduction

    NOTE: The use of dry acid (sodium bisulfate) to adjust pool pH is discouraged especially in arid regions where pool water is subject to excessive evaporation and is not commonly diluted with fresh water. Dry acid can cause a buildup of by-products that can damage your chlorinator cell. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS...
  • Page 4: Water Chemistry

    If the Si is above +0.2, scaling and staining will occur. Use the equation and chart below to determine the saturation index. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS...
  • Page 5 It is important to use only sodium chloride (NaCl) that is 99% pure. This is common food quality or water softener salt available in 40-80 lb. bags at your local Hayward dealer. It is also acceptable to use water conditioning salt pellets, however, it will take longer for them to dissolve. Do not use rock salt, salt with more than 1% yellow prussiate of soda, salt with more than 1% of anti-caking additives, or iodized salt.
  • Page 6 USE ONLY HAYWARD GENUINE REPLACEMENT PARTS...
  • Page 7 Always check stabilizer (cyanuric acid), when checking salt. These levels will most likely decline together. Use the chart below to determine how much stabilizer must be added to raise the level to 80 ppm. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS...
  • Page 8: Controls

    POWER When illuminated, the Aqua Trol has input power. GENERATING This LED is on steady during normal operation. When flashing, the pool water is too hot or cold to operate. SUPER CHLORINATE Illuminates during Super Chlorination. See description above. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS...
  • Page 9 You may need to lower the setting when the pool water temperature decreases significantly or there are long periods of inactivity. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS...
  • Page 10 Spring Start-up DO NOT turn the Aqua Trol on, until the pool water chemistry has been brought to the proper levels. This information can be found on page 2. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS...
  • Page 11: Installation

    (disperses heat from inside the box), it is important not to block the four sides of the control. Do not mount the Aqua Trol in a panel or tight enclosed area. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS...
  • Page 12 PVC pipe coming from the pools filtration system. Tighten all union nuts BY HAND for a watertight seal. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS...
  • Page 13 Models with the standard 120 VAC line cord should be plugged into a GFCI receptacle. Twist lock models should be plugged into a twist lock receptacle wired to a GFCI circuit breaker. For Canadian installations: Connect to a circuit protected by a Class-A ground fault interruptor. See diagram below. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS...
  • Page 14 Electrolytic Cell and Flow Switch The cell and flow switch plug into connectors on the Aqua Trol electronics unit. Note that return jet units (-RJ option) will NOT have a flow switch. See diagram below. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS...
  • Page 15: Troubleshooting

    Make sure you have at least 12” of straight pipe before the USE ONLY HAYWARD GENUINE REPLACEMENT PARTS...
  • Page 16 “normal” and chlorine tests will show the desired 1-3ppm free chlorine reading. “-Pcb-” displayed and all 4 red/yellow LEDs are illuminated. A possible Printed Circuit Board fault has been detected. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS...
  • Page 17 USE ONLY HAYWARD GENUINE REPLACEMENT PARTS...
  • Page 18 (3) years. Hayward also warrants its Aqua Trol chlorination products to be free of defects in materials and workmanship, under normal use and service for a period of one (1) year. These warranties are ap- plicable from the initial date of purchase on private residential swimming pools in the US and Canada.
  • Page 19: Product Registration

    E-mail Address_____________________________________ Type of Pool: Serial Number (may not be applicable) Gunite/Concrete Vinyl Fiberglass Purchased for: New Installation Replacement Model Number_____________________________________ Installation for: Pool Capacity (US gallons)___________________________ Inground Please include me on all e-mail communications regarding Hayward Equipment or promotions. ® Mail to: Hayward Pool Products, 620 Division Street, Elizabeth, NJ 07207 Attn: Warranty Dept or REGISTER YOUR WARRANTY ON-LINE AT WWW.HAYWARD.COM USE ONLY HAYWARD GENUINE REPLACEMENT PARTS...
  • Page 20 Hayward is a registered trademark and Aqua Trol is a trademark of Hayward Industries, Inc. © 2012 Hayward Industries, Inc. All other trademarks not owned by Hayward are the property of their respective owners. Hayward is not in any way affiliated with or endorsed by those third parties.