Table Of Contents - ADC AD-120ES Installation Manual

WARNING
! !
Proposition 65
Use of this product could expose you to substances
from fuel combustion that contain chemicals
known to the State of California to cause cancer,
birth defects and other reproductive harm.
IMPORTANT
You must disconnect and lockout the electric supply and the
gas supply or the steam supply before any covers or guards
are removed from the machine to allow access for cleaning,
adjusting, installation, or testing of any equipment per OSHA
standards. Please observe all safety precautions displayed
on the equipment and/or specified in the installation manual
included with the dryer. Before installation, check that the
local distribution conditions, nature of gas and pressure, and
adjustment of the appliances are compatible.
CAUTION
Dryer(s) should never be left unattended while in operation.
When discarding or storing your old clothes dryer,
remove the door.
Lorsque vous entreposez ou mettez votre sécheuse au
rebut, enlevez-en la porte.
"Caution: Label all wires prior to disconnection when servicing
controls. Wiring errors can cause improper operation."
«Attention: Au moment de l'entretien des commandes,
étiquetez tous les fils avant de les débrancher. Des erreurs
de câblage peuvent entraîner un fonctionnement inadéquat
et dangereux.»
WARNING
Children should not be allowed to play on or near the dryer(s).
Children should be supervised if near dryers in operation.
Under no circumstances should the dryer door switch(es),
lint door/drawer switch(es), or heat safety circuit(s) ever be
disabled.
Do not modify this appliance.
The dryer must never be operated with any of the back
guards, outer tops, or service panels removed. Personal
injury or fire could result.
The dryer must never be operated without the lint filter/screen
in place, even if an external lint collection system is used.
Do not operate this appliance before reading the instruction
booklet.
Do not place articles on or against this appliance.
If the hi-limit switch trips, a service call is required to
investigate the reason and resolve the issue.
FOR YOUR SAFETY
Do not dry mop heads in the dryer. Do not use dryer in
the presence of dry cleaning fumes.
The dryers must not be installed or stored in an area where
it will be exposed to water or weather.
The wiring diagram for the dryer is located in the front
electrical control box area.
113386- 28
In the State of Massachusetts, the following
installation instructions apply:
I Installations and repairs must be performed
I If using a ball valve, it shall be a T-handle
I A flexible gas connector, when used, must

Table of Contents ______________

Safety Precautions ............................................... 4
AD-120ES Specifications ..................................... 6
ADG-120DR Specifications .................................. 9
Component Identification .................................. 11
Installation Procedures ...................................... 11
Location Requirements .......................................... 11
Unpacking / Setting Up .......................................... 12
Dryer Enclosure Requirements .............................. 12
Fresh Air Supply Requirements ............................. 13
Exhaust Requirements ........................................... 13
Electrical Information ............................................. 17
Gas Information ...................................................... 18
Steam Information .................................................. 21
Water Information .................................................. 23
Preparation for Operation ....................................... 25
Preoperational Test ................................................ 26
Preoperational Instructions .................................... 27
Compressed Air Requirements .............................. 28
Shutdown Instructions ............................................ 28
Service / Parts Information ................................ 28
Service ................................................................... 28
Parts ....................................................................... 28
Warranty Information ......................................... 28
Returning Warranty Cards ...................................... 28
Warranty ................................................................. 28
Returning Warranty Parts ....................................... 28
Routine Maintenance ......................................... 29
Cleaning ................................................................. 29
Adjustments ........................................................... 30
Lubrication .............................................................. 30
Data Label Information ...................................... 30
Procedure for Functional Check
of Replacement Components ............................ 31
Manual Reset Burner Hi-Limit Instructions ..... 32
Non-Coin Programming ..................................... 33
List of Acronyms _____________________
DSI
HVAC Heating, Ventilating, and Air-Conditioning
in WC Inches of Water Column
L.E.D. Light Emitting Diode
L.P.
OSHA Occupational Safety and Health Administration
R.M.A. Return Material Authorization
UL
www.adclaundry.com
by a qualified or licensed contractor,
plumber, or gasfitter qualified or licensed by
the State of Massachusetts.
type.
not exceed 3 feet.
Direct Spark Ignition
Liquid Propane
Underwriters Laboratory
3