Chemical Feeder Equipment; Preparing Chemical Feeder Pumps; Priming Chemical Feeder Pumps - Jackson DishStar HT Installation, Operation And Service Manual

INSTALLATION
CHEMICAL FEEDER
EQUIPMENT
PREPARING
CHEMICAL FEEDER
PRIMING CHEMICAL
FEEDER PUMPS
!
WARNING
WARNING: Some of the
chemicals used in
dishwashing might cause
chemical burns if they
come in contact with skin.
Wear protective gear when
handling these chemicals.
If any contact with skin
occurs, immediately
follow the treatment
instructions provided
with the chemicals.
07610-004-37-13-E
!
CAUTION
The bottom of the chemical container cannot be located any higher than 8" from the
floor. If the unit is equipped with the 6" or 18" table stand, the highest position will be
14" or 26" from the floor, respectively. It is important to remember that if you decide
to operate the unit in chemical-sanitizing mode, you must ensure an appropriate
chlorine-based sanitizer is used in the final rinse line.
The DishStar
feeder pumps.
PUMPS
The DishStar
sanitizer chemical feeder pumps.
Locate the open ends of the chemical tubes with the tube stiffeners and place each
one in the appropriate container.
A. Red Tubing = Detergent
C. White Tubing = Sanitizer
Chemical feeder pumps need priming when the machine is first installed or if the
chemical lines have been removed and air is allowed to enter.
!
CAUTION
1. Verify that the proper chemical tube stiffener inlet is in the proper container.
2. Use the prime switches located on the control panel at the bottom of the unit to
prime each pump. The switches are clearly marked, "D" for detergent and "R"
for Rinse-aid.
3. To prime the pumps:
HT
• Detergent - hold the "D" switch in the momentary position until detergent is
seen entering the wash tank.
• Rinse-aid - hold the "R" switch in the momentary position for one minute.
CAUTION! Chlorine-based sanitizers can be detrimental to this
machine if the chemical solution is too strong. See a chemical
professional to ensure the dispenser is set-up correctly.
®
HT dishmachine is supplied with detergent and rinse-aid chemical
®
LT and LT-H dishmachines are supplied with detergent, rinse-aid, and
CAUTION! Water must be in the sump and wash tank before chemicals
are dispensed.
INSTRUCTIONS
B. Blue Tubing = Rinse-Aid
8