Table of Contents
Advertisement
Service
This manual is to be used by qualified appliance
technicians only. Maytag does not assume any
responsibility for property damage or personal
injury for improper service procedures done by
an unqualified person.
Freestanding
Electric Range
This Base Manual covers general information
Refer to individual Technical Sheet
for information on specific models
This manual includes, but is
not limited to the following:
AER4311AAW
AER5511AAB/Q/W
AER5511ACW
AER5512AAB/Q/W
AER5712AAQ/S/W
AER5712ACW
CE1100AAV
CE35200AAQ/V/W
CE35400ACV
CE35400AAQ/V
CE38600ACV
CE38600AAB/Q/V/W
CE38800ACV
CE38800AAQ/S/V/W
CEL1115AAH/Q/W
CER1115AAH/Q/T/W
CER1125ACW
CER1125AAW
CER3525AAB/Q/W
CER3525ACB/W
CER3725ACW
CER3725AAB/Q/S/W
MER4351AAQ/W
MER5551AAS
MER5551AAB/Q/W
MER5552AAB/Q/S/W
MER5751AAB/Q/S/W
MER5751ACW
MER5752AAB/Q/S/W
MER5752ACW
PER4311ACW
PER5720ACW
PER5720LAQ/W
16023528
October 2004
©
2004 Maytag Services
Advertisement
Table of Contents
Related Manuals for Maytag AER4311AAW
Summary of Contents for Maytag AER4311AAW
- Page 1 Service This manual is to be used by qualified appliance technicians only. Maytag does not assume any This Base Manual covers general information responsibility for property damage or personal Refer to individual Technical Sheet injury for improper service procedures done by an unqualified person.
-
Page 2: Important Information
Customer Service Support Center CAIR Center Web Site Telephone Number WWW.AMANA.COM ..........1-800-843-0304 WWW.MAYTAG.COM ..........1-800-688-9900 CAIR Center in Canada ........... 1-800-688-2002 Amana Canada Product ........... 1-866-587-2002 Recognize Safety Symbols, Words, and Labels DANGER DANGER—Immediate hazards which WILL result in severe personal injury or death. -
Page 3: Table Of Contents
Door Disassembly (No Window) ......22 Quick Test Mode ............. 15 Appendix A Installation Instructions (All Models Except CEL1115AA*, CE11000AA*) ......A-2 Installation Instructions (Models CEL1115AA*, CE11000AA*) ....A-8 Appendix B Use Information ............. B-2 Care and Cleaning ..........B-13 ©2004 Maytag Services 16023528... -
Page 4: Important Safety Information
RANGE, THE RANGE MUST BE SECURED BY connection. Inform consumer of the condition of range PROPERLY INSTALLED ANTI-TIP DEVICES. before leaving. 2. Adhere to all local regulations and codes when performing service. 16023528 ©2004 Maytag Services... -
Page 5: Electrical Requirements
• Never leave range unattended while cooking. Boilovers • Should a grease fire occur in the broiler pan, turn off can cause smoking and may ignite. oven, and keep oven door closed until fire burns out. ©2004 Maytag Services 16023528... -
Page 6: Surface Cooking Units
3. Clean Only Parts Listed in Manual. the range is put into operation. Failure to do 4. Before Self-Cleaning the Oven—Remove broiler pan so can create a possible and other utensils. shock hazard. 16023528 ©2004 Maytag Services... -
Page 7: General Information
Downdraft Cooktop or Warming Drawer Eyelevel Range Grill Range (20") Feature Content Range (36") 1000-3999 Brands Drop In (24") 4000-6999 Maytag/Amana Wall Oven (27") 7000-9999 Jenn Air Range, Free-Standing (30") Slide-In (30") Range Hood Wall Oven RV Range RV Top ©2004 Maytag Services 16023528... -
Page 8: Specifications
The Web Site at www.amana.com number can be found on the oven chassis behind the • For Maytag product call 1-800-688-9900 or visit the service drawer. Open the service drawer to view the data. Web Site at www.maytag.com •... -
Page 9: Extended Service Plan
Range Description Extended Service Plan • Dependability Plus Extended Service Plan is specially designed to supplement Maytag’s strong We offer long-term service protection for this new oven. warranty. This plan covers parts, labor, and travel • Asure Extended Service Plan is specially designed charges. -
Page 10: Troubleshooting Procedures
Normal ............• Minor smoking or order is normal the first few times of oven usage. Oven smokes/odor first few • Ventilate area well and perform times of usage self-clean cycle. Electronically Controlled......... • Refer to specific Technical Sheet Failure Codes for diagnostic checks. 16023528 ©2004 Maytag Services... - Page 11 • Check infinite switch, replace if Failed infinite switch ........failed. Normal............. • Element cycles to maintain Frequent cycling of surface proper heat and to prevent element or warming zone damage to smoothtop. ©2004 Maytag Services 16023528...
-
Page 12: Component Testing Procedures
Measure voltage at indicator light ... If voltage is present and light does not work, replace light. Surface indicator light If no voltage is present at indicator light check wiring. Rocker switch Measure continuity of switch positions: Closed ..........Continuity Open ........... Infinite 16023528 ©2004 Maytag Services... - Page 13 Refer to Parts Manual for replacement components. NOTE: If latched is moved to LOCK position during Bake Or Broil, the control will cancel that function. Ω Oven temperature Measure resistance....... Approximately 1000 at room ° sensor temperature 80 ©2004 Maytag Services 16023528...
-
Page 14: M1 Oven Control Testing
The last 5 diagnostic codes will be stored Display seconds of powering up the unit. in the non-volatile memory. See "Description of Error Codes" for Cycle through the codes using the explanation. More + or Less - pads. 16023528 ©2004 Maytag Services... -
Page 15: Quick Test Mode
Secondary System: Sequential numbering Oven Cavity: 1 – Upper oven (or single cavity oven) 2 – Lower oven c – Control specific Diagnostic Code Display Mode may be started only within 60 seconds when powering up the control. ©2004 Maytag Services 16023528... - Page 16 4d51 Door switch not open or closed Disables Clean and Lockout functions 4, 5 Nothing Turn off light and disable light from door switch 9d11 Lock switch not closed Disables Clean and Lockout LOCK flashes functions 16023528 ©2004 Maytag Services...
- Page 17 If a function requiring latch movement is attempted while the lock switch is faulted, the control will sound an error tone and the function will be disabled. Bake Timer Broil CANCEL Keep Cook Clock Clean Delay Warm Hold Typical M1 Control ©2004 Maytag Services 16023528...
-
Page 18: Disassembly Procedures
4 . Reverse procedure to reinstall convenience outlet edges and allow control panel to tip forward. and/or circuit breaker. 16023528 ©2004 Maytag Services... -
Page 19: Oven Sensor
Coil Element Terminal spacers. 1. Remove maintop assembly, see "Maintop Assembly" 7. Reverse procedure to reinstall side panel. procedure. 2. Remove screw securing element support bracket to maintop. 3. Label and disconnect wire terminals from element being replaced. ©2004 Maytag Services 16023528... -
Page 20: Backguard
Push the left side down and the right side up to release slide from track and pull forward. 3. When installing warming drawer, align slide with track and push warming drawer into place. 16023528 ©2004 Maytag Services... -
Page 21: Frameless Door Disassembly (Large And Standard Windows)
Window Lining Gasket Inner Glass Door Panel Glass Door Frame Baffle Inner Door Door Door Door Glass Trim Trim Insulation Door Handle Door Gasket Door Door Glass Handle Retainer Glass Door Support Trim Outer Door Glass ©2004 Maytag Services 16023528... -
Page 22: Door Disassembly (No Window)
6. Reverse procedure to reassemble oven door. 2. Place door on a protected surface. 3. Remove screws securing door handle to door panel. Oven Door - No Window Door Seal Door Lining Door Insulation Door Handle Door Panel 16023528 ©2004 Maytag Services... - Page 23 Appendix A ©2004 Maytag Services 16023528 A – 1...
-
Page 24: Installation Instructions (All Models Except Cel1115Aa*, Ce11000Aa
Installation Instructions (all models except CEL1115AA*, CE11000AA*) A – 2 16023528 ©2004 Maytag Services... - Page 25 Installation Instructions (all models except CEL1115AA*, CE11000AA*) ©2004 Maytag Services 16023528 A – 3...
- Page 26 Installation Instructions (all models except CEL1115AA*, CE11000AA*) A – 4 16023528 ©2004 Maytag Services...
- Page 27 Installation Instructions (all models except CEL1115AA*, CE11000AA*) ©2004 Maytag Services 16023528 A – 5...
- Page 28 Installation Instructions (all models except CEL1115AA*, CE11000AA*) A – 6 16023528 ©2004 Maytag Services...
- Page 29 Installation Instructions (all models except CEL1115AA*, CE11000AA*) ©2004 Maytag Services 16023528 A – 7...
-
Page 30: Installation Instructions (Models Cel1115Aa*, Ce11000Aa
Installation Instructions (models CEL1115AA*, CE11000AA*) A – 8 16023528 ©2004 Maytag Services... - Page 31 Installation Instructions (models CEL1115AA*, CE11000AA*) ©2004 Maytag Services 16023528 A – 9...
- Page 32 Installation Instructions (models CEL1115AA*, CE11000AA*) A – 10 16023528 ©2004 Maytag Services...
- Page 33 Installation Instructions (models CEL1115AA*, CE11000AA*) ©2004 Maytag Services 16023528 A – 11...
- Page 34 Installation Instructions (models CEL1115AA*, CE11000AA*) A – 12 16023528 ©2004 Maytag Services...
- Page 35 Installation Instructions (models CEL1115AA*, CE11000AA*) ©2004 Maytag Services 16023528 A – 13...
- Page 36 Installation Instructions (models CEL1115AA*, CE11000AA*) A – 14 16023528 ©2004 Maytag Services...
- Page 37 Installation Instructions (models CEL1115AA*, CE11000AA*) ©2004 Maytag Services 16023528 A – 15...
- Page 38 Appendix B B – 1 16023528 ©2004 Maytag Services...
-
Page 39: Appendix B Use Information
Use Information ©2004 Maytag Services 16023528 B – 2... - Page 40 Use Information B – 3 16023528 ©2004 Maytag Services...
- Page 41 Use Information ©2004 Maytag Services 16023528 B – 4...
- Page 42 Use Information B – 5 16023528 ©2004 Maytag Services...
- Page 43 Use Information ©2004 Maytag Services 16023528 B – 6...
- Page 44 Use Information B – 7 16023528 ©2004 Maytag Services...
- Page 45 Use Information ©2004 Maytag Services 16023528 B – 8...
- Page 46 Use Information B – 9 16023528 ©2004 Maytag Services...
- Page 47 Use Information ©2004 Maytag Services 16023528 B – 10...
- Page 48 Use Information B – 11 16023528 ©2004 Maytag Services...
- Page 49 Use Information ©2004 Maytag Services 16023528 B – 12...
-
Page 50: Care And Cleaning
Care and Cleaning B – 13 16023528 ©2004 Maytag Services... - Page 51 Care and Cleaning ©2004 Maytag Services 16023528 B – 14...
- Page 52 Care and Cleaning B – 15 16023528 ©2004 Maytag Services...
- Page 53 Care and Cleaning ©2004 Maytag Services 16023528 B – 16...
- Page 54 Care and Cleaning B – 17 16023528 ©2004 Maytag Services...