Troubleshooting - EGO LM2000E Operator's Manual

TROUBLESHOOTING

WARNING:
Always remove the safety key and battery pack when servicing or transporting the mower. Always
protect your hands by wearing heavy gloves or wrapping the cutting edges with rags or other materials when
performing any maintenance on the mower blade.
PROBLEM
The mower fails
to start
The mower cuts
unevenly
The mower stops
while mowing
14
56 VOLT LITHIUM-ION CORDLESS MOWER — LM2000E
CAUSE
◾
The safety key is not inserted in the slot.
◾
The battery pack is depleted.
◾
The battery pack is not attached to the
mower.
◾
The battery or mower circuitry is too hot.
(The power indicator on the mower will
illuminate in orange for 10 seconds)
◾
The side rails are not extended to their
maximum length and the clamps are not
locked in position.
◾
The handle is not set at one of the two
operating positions.
◾
The mower deck is clogged with grass and
debris.
◾
The blade is dull.
◾
The cutting height is not set properly.
◾
The blade is assembled incorrectly.
◾
The battery pack is depleted.
◾
Mower is in overload condition.
◾
Mower deck is clogged with grass and
debris.
◾
The battery or mower circuitry is too hot.
(The power indicator on the mower will
illuminate orange for 10 seconds.)
◾
The side rail is retracted a little by the
pushing force applying on the handle.
SOLUTION
◾
Insert the safety key; press the key while
pulling the bail switch; release the safety
key.
◾
Charge the battery pack.
◾
Attach the battery pack to the mower.
◾
Allow the battery pack or mower to cool
until the temperature drops below 67°C.
◾
Fully extend the handle and lock both
clamps.
◾
Adjust the handle to one of the two operating
positions.
◾
Clean the mower deck and make certain
that the blade has freedom of movement.
◾
Sharpen or replace the blade.
◾
Raise the deck to a higher cutting height
setting.
◾
Reassemble the blade, following the
section "INSTALLING THE BLADE" in this
manual.
◾
Charge the battery pack.
◾
Raise the cutting height or slow down the
mowing.
◾
Unclog the mower deck. Raise the cutting
height, or cut a narrow swath.
◾
Allow the battery pack or mower to cool
until the temperature drops below 67°C.
◾
Unlock the clamps. Fully extend the side
rails and lock the clamps again.