Hartenberger Nano compact Instructions For Use Manual

Underwater hand lamp

Hide thumbs

Table Of Contents

Table of Contents

Quick Links

Download this manual

Hartenberger

Underwater Hand Lamp

H a

r t e

n b

n a

n o

p r e

e r

s s u

c o

r e

g e

i n d

m p

i c a

t o r

a c

L E D

p o w

e r

c o n

t r o

O F

- 2 5

1 s

L E D

e c .

0 . 5

s e c

1 2 5

5 s

u n l

+ 2

e c .

o c k

5 %

S O

l o c

Instruction for use

nano compact

Table of Contents

Summary of Contents for Hartenberger Nano compact

Page 1 - 2 5 L E D e c . 0 . 5 s e c 1 2 5 u n l e c . o c k l o c nano compact...
Page 2: Table Of Contents
If not adhered to the parts of this instruction for use, which are marked with the addition “Warning”, there is a great danger of property damages, physical damages or death. ©Hartenberger Unterwassertechnische Geräte GmbH Rights reserved for technical changes. Issue 01.2011...
Page 3: Safety Warning
Before attempting to use the underwater lamp, carefully read and adhere to these instructions for use. The use of the underwater lamp nano compact calls for the same amount of care and conscientiousness as is necessary in order to practice diving in a safe manner.
Page 4: Article Description Housing
40 x 3,0 and 48x1,6 mm 50° hardness HOUSING / BODY The housing / body is sealed with the front and the rear screw fitting. O-RINGS 40 x 3,0 and 48x1,6 mm 50° hardness. ©Hartenberger Unterwassertechnische Geräte GmbH Rights reserved for technical changes. Issue 01.2011...
Page 5 The handle provides a good hold on the lamp, even when wearing thick neoprene gloves or mittens. If required for video mounting, the handle can be drilled and an M8 thread cut for mounting to video rigs. ©Hartenberger Unterwassertechnische Geräte GmbH Rights reserved for technical changes. Issue 01.2011...
Page 6: Article Description Power Pack
APPROX. BURN TIME IN MINUTES WITH LIMN CELL PACK 7,2V / 3,8AH LED 4x3W LED 9x2,5W (R) Halogen Bulb 6V Time of use at 50% Time of use at 75% Time of use at 100% Time of use at 125% ©Hartenberger Unterwassertechnische Geräte GmbH Rights reserved for technical changes. Issue 01.2011...
Page 7: Front Housing Cover
330 ft FRONT GLASS PLATE The nano compact lamps have a tempered glass plate as standard. This glass plate has a temperature shock resistance of 150° C ( 300° F). It is therefore possible to use the lamps above and under water. A rapid cooling of a heated front glass is no problem (for example if used temporarily above water in order to orientate oneself on the surface of the water).
Page 8: Bulb/Led
O-ring sits correctly into the groove, a blunt tool can be used for pressing the O-ring into the groove. BULB/LED Fig. 4: Removal/Refitting the bulb ©Hartenberger Unterwassertechnische Geräte GmbH Rights reserved for technical changes. Issue 01.2011...
Page 9: The Rear Housing Cover
The plastic components on the rear housing cover should not be exposed to any solvent based agents, such exposure may result in cracks in the components and subsequent leakage/flooding. ©Hartenberger Unterwassertechnische Geräte GmbH Rights reserved for technical changes. Issue 01.2011...
Page 10 The housing is then closed by screwing the components clockwise together. The screw fitting should be tightened by hand only until the parts are mated together. ©Hartenberger Unterwassertechnische Geräte GmbH Rights reserved for technical changes. Issue 01.2011...
Page 11: Power Pack
PREPARATION FOR USE BEFORE THE LAMP IS USED FOR THE FIRST TIME Before the first use, the cells must be charged. Hartenberger underwater lamps are manufactured to a high degree of precision and each lamp is tested to a water pressure of 10 bars. The condition of the lamp and in particular the housing and sealing rings should however be checked before the first use (see page 8).
Page 12: Using The Underwater Lamp
(50%). Each subsequent push to the right (+) will increase the brightness 25%. Each subsequent push to the left (-) will decrease the brightness 25%. ©Hartenberger Unterwassertechnische Geräte GmbH Rights reserved for technical changes. Issue 01.2011...
Page 13 100 hours is not reduced. Using the lamp at reduced power settings saves energy and extends the burning time in a single charge cycle. Permanently operating the lamp at reduced power settings will however produce a grey coating on the bulb’s ©Hartenberger Unterwassertechnische Geräte GmbH Rights reserved for technical changes. Issue 01.2011...
Page 14 LED display will begin to blink quickly (4 x per second) and the power of the lamp will automatically reduce to 25%. ©Hartenberger Unterwassertechnische Geräte GmbH Rights reserved for technical changes. Issue 01.2011...
Page 15: Transport
This is a precaution in case a defective electronic module turns the lamp on. This heat generated by the halogen bulb my cause damage to items adjacent to the lamp/glass/bulb. ©Hartenberger Unterwassertechnische Geräte GmbH Rights reserved for technical changes. Issue 01.2011...
Page 16: Storage
The lithium manganese cells used in this lamp do not have a memory effect. Warning ! Regularly discharging a multi cell power pack may damage the voltage ©Hartenberger Unterwassertechnische Geräte GmbH Rights reserved for technical changes. Issue 01.2011...
Page 17 This method of charging is advantageous when the ambient conditions are unsuitable for opening the housing, the cell pack is charged via the external connections located on the rear of the housing. ©Hartenberger Unterwassertechnische Geräte GmbH Rights reserved for technical changes. Issue 01.2011...
Page 18 This voids the warranty and any releases the manufacturer of any responsibility and liability for subsequent damage and/or injury. CHARGER OFF-SHORE I/6 Use only manufacturer approved cells, do not connect any non-approved cells. ©Hartenberger Unterwassertechnische Geräte GmbH Rights reserved for technical changes. Issue 01.2011...
Page 19 Charger LED when charging lithium manganese re-chargeable cells: When the cell pack is fully charged (all 4 LEDs on the nano compact display of off) the electronic module in the lamp will cut off the charging current to the lamp.
Page 20: Charger Off-Shore I/6
Trickle charge, cell pack is 100% charged. Charger LED when charging lithium manganese re-chargeable cells: When the cell pack is fully charged (all 4 LEDs on the nano compact display of off) the electronic module in the lamp will cut off the charging current to the lamp.
Page 21: Care And Maintenance
Life expectancy up to 500 operating hours SERVICE LOG O RING / HALAOGEN BULB REPLACEMENT Halogen O-Ring 48x3,0 O-Ring 40x3,0/48x1,6 O-Ring 40x3/48x1,6 bulb Glass plate front cover rear cover Notes: ©Hartenberger Unterwassertechnische Geräte GmbH Rights reserved for technical changes. Issue 01.2011...
Page 22: Fault Diagnosis
Attention; the over pressure indicator requires excessive force for removal. Under certain circumstance, electrolyte may be forced out of the housing (risk of injury/burning/scalding) ©Hartenberger Unterwassertechnische Geräte GmbH Rights reserved for technical changes. Issue 01.2011...
Page 23: Spare Parts
LED-Module (4x3,5 watt, spot beam) ideal for diving in fresh water and low light environments. REPLACEMENT CELL PACK Replacement nano compact 7,2V/3,8Ah Cell pack with lithium manganese cells for quick replacement of a discharged cell pack. Do not throw defective/unwanted cell pack in the normal waste, dispose of them correctly at a suitable recycling point.
Page 24 Instructions for use Hartenberger High-Tech-UW-Lamp nano compact Hartenberger Unterwassertechnische Geräte GmbH Rennebergstr. 19 D - 50939 Köln Germany Tel.:+49 221 415000 Fax.: +49 221 415050 info@hartenberger.de www.hartenberger.de ©Hartenberger Unterwassertechnische Geräte GmbH Rights reserved for technical changes. Issue 01.2011...