Table of Contents
Advertisement
Buzzaround_SG_REVA_040711
ABOUT THIS SERVICE GUIDE
This service guide provides you with the information necessary to repair Golden Technologies Buzzaround Lite. There are
two parts to the service guide: Troubleshooting and Component Replacement. The Troubleshooting section will assist you
in finding the source of the problem. The Component Replacement section contains step-by-step replacement instructions
for key components.
Before troubleshooting, check the following:
• Make sure that the circuit breaker is reset.
• Visually check terminals for corrosion. Check wires for missing insulation.
• Make sure that the batteries are in good working order. When possible, keep sets of known good batteries of various
ratings in your shop at all times. The GB106 requires 12AH batteries. Problems that surface during troubleshooting are
often due to the fact that the batteries are not fully charged or cannot hold their charge.
• Make sure that the electrical connections are secure. Unplug the connectors and make sure all of the pins are seated
properly. Push the pins back into the connector housing if necessary.
NOTE: If you get to a point during troubleshooting where you cannot continue, call tech support at 800-624-6374.
GB106 COMPONENTS
The GB106 is battery-operated scooter controlled by a P+G Drives S-Drive controller. The S-Drive controller monitors
the systems and displays BEEP codes when it detects a fault in the system. The GB106 was designed to operate with
between 18 – 24 volts (V) of direct current (DC).
The GB106 control system is made up of the following components:
• 12V/12AH Batteries (2) (BAT)
• Main Circuit Breaker (CB)
• Off-Board Battery Charger (BC)
• Charger Harness (CH)
• Intermediate Charger Harness (ICH)
• Power Harness (PH)
• Motor (MT)
• Motor Brake (MB)
• Intermediate Motor Harness (IMH)
• P+G S-Drive Controller (CN)
• Main Harness (MH)
• Top Dashboard (TD)
• Throttle Pot (TP)
• Speed Pot (SP)
• Key Switch (KS)
NOTE: Parts and service must be authorized by Golden Technologies Service Department. Unauthorized parts or
service may void the warranty. For more information, contact the Golden Technologies Service Department at
800-624-6374 or parts@goldentech.com.
4
Hide quick links:
Advertisement
Chapters
Table of Contents
