mr. steam CT6E Installation, Operation & Maintenance Manual
Club therapy steambath generator systems
Hide thumbs
Also See for CT6E:
- Installation operation & maintenance (27 pages) ,
- Installation, operation & maintenance manual (27 pages) ,
- Instructions (2 pages)
Related Manuals for mr. steam CT6E
Summary of Contents for mr. steam CT6E
- Page 1 Installation, Operation & Maintenance Manual Club Therapy Steambath Generator Systems Installation, Operation & Maintenance Manual Models: CT6E, CT9E, CT12E, CT15E steam Feel Good Inc. ®...
-
Page 2: Table Of Contents
Club Therapy ® Steambath Generator Systems INSTALLATION, OPERATION & MAINTENANCE MANUAL Table of Contents Read Me First! & Warning Placard ........1 Select Your Club Therapy Model ........2 Specification Chart .............2 Before Installing ..............3 Steam Room Guidelines.............3 Locating the Steam Generator Unit ........4 Typical Installation ..............4 Installation: Plumbing, Water Supply, Drain, Steam Outlet Safety Valve, Drip Pan, AromaSteam ....5... -
Page 3: Read Me First! & Warning Placard
steam ® C L U B T H E R A P Y Installation, Operating & Maintenance Manual _________________________________________________________________________________________ When installing and using this electrical equipment, basic safety precautions R E A D M E F I R S T ! should always be followed, including the following: IMPORTANT NOTE: IMPORTANT SAFETY INSTRUCTIONS... -
Page 4: Select Your Club Therapy Model
Amps (for Total Adj Wire Water Usage Shipping Model No. KW 240v/1PH)† Room Vol. Size‡ gallons†† Dimensions* Wt. (lbs)** CT6E 0.80 17"L x 18½"H x 7 ⁄ "D CT9E 17"L x 18½"H x 7 ⁄ "D CT12E 17"L x 18½"H x 7 ⁄... -
Page 5: Before Installing
Failure to mount this placard may result in serious injury or death. For a replacement placard contact Mr. Steam customer 3. If tile-type or other smooth surfaced flooring is used service at 1-800-76-STEAM or hello@mrsteam.com provide suitable anti-skid strips or equivalent, to prevent a slipping hazard. -
Page 6: Locating The Steam Generator Unit
steam ® C L U B T H E R A P Y Installation, Operating & Maintenance Manual _________________________________________________________________________________________ Locating the Steam Generator Unit IMPORTANT NOTE: The control cables should be run in dedicated 1" conduit to facilitate installation and service Select a location as near as practical to the steam room. -
Page 7: Safety Valve, Drip Pan, Aromasteam
8. Install an approved backflow preventer as required by local codes . Drip Pan Drain Mr. Steam strongly recommends the use of a drip pan in (1" N P T the unlikely event of a plumbing leak. Check local plumb- The drain from the generator should not share an undersink ing codes for receptor, trap and vent requirements. -
Page 8: Steam Head Installation
steam ® C L U B T H E R A P Y Installation, Operating & Maintenance Manual _________________________________________________________________________________________ Installing the AromaSteam Steamhead ⁄ " NPT) 1/8" minimum clearance Use Teflon ® required for Acrylic Shield. equal sealant on ⁄ NOTE: A 1 "... -
Page 9: Generator Dimensions
steam ® C L U B T H E R A P Y Installation, Operating & Maintenance Manual _________________________________________________________________________________________ Generator Dimensions Water Inlet Steam Outlet Safety Valve AutoFlush Manual Drain Valve 12” (305) for servicing 17" " " (432) (162) (60) "... -
Page 10: Electrical Specifications & Field Power Wiring
Thermostat AutoFlush Plug and Play Connector Liquid Level Probe (see page 13) Steam Outlet Liquid Level Control Board Models CT6E – CT9E (single phase wiring shown) Power Block Models CT12E & 15E Fuses (single phase wiring shown) Contactor Transformer NOTE: FOR ILLUSTRATIVE... -
Page 11: Wiring Diagrams
Control CONTROL BOARD Heating Element THERMOSTAT Three Phase POWER INPUT Wiring Diagrams TRANSFORMER L E G E N D (All Diagrams) FIELD WIRING Express MODEL CT6E, CT9E FACTORY Steam WIRING & CT12E WATER FEED GROUND SOLENOID VALVE THERMOSTAT CONTACTOR HEATER... -
Page 12: Initial Start-Up & Checkout, Maintenance, Troubleshooting And Operation
steam ® C L U B T H E R A P Y Installation, Operating & Maintenance Manual _________________________________________________________________________________________ Initial Start-Up and Checkout Maintenance 1. Turn on control. Follow specific instructions provided Mr.Steam steambath generators require little maintenance. with controls. Other than draining, maintenance procedures are minimal. -
Page 13: System Status Codes, Liquid Level Control Board
steam ® C L U B T H E R A P Y Installation, Operating & Maintenance Manual _________________________________________________________________________________________ System Status Codes The iTempo/Plus control may display a status code if the steam generator is not functioning properly. Code Code Meaning Probable Cause Suggested Remedy Water level is not... -
Page 14: Autoflush
steam ® C L U B T H E R A P Y Installation, Operating & Maintenance Manual _________________________________________________________________________________________ ® AutoFlush 3 Pin Connector Box Contents for AutoFlush • AutoFlush Valve with Cord • Installation instructions. Operation The AutoFlush System feature automatically drains the CT system following each use. -
Page 15: Drip Pan, Express Steam
Remote Temperature Probe iTempoPlus only licensed plumber and in accordance with applicable national and local codes. Check 100476-2 Contactor 50A 2-pole CT6E & CT9E, local plumbing code for receptor, trap and Single phase vent requirements. 99012 Contactor 50A 3-pole All 3-Phase models Drip pans drain by gravity. -
Page 16: Replacement Parts Diagram
® C L U B T H E R A P Y Installation, Operating & Maintenance Manual _________________________________________________________________________________________ Models CT6E & CT9E shown with cover removed Liquid Level Control Board (103975) Contactor Water Feed Solenoid (100479) Power Supply Transformer... -
Page 17: Controls
An optional 60 foot cable is available, PN 103990-60 for control. The iSteam , iTempo and iTempo/Plus iTempo and PN 104117-60 for iSteam. Contact a Mr. Steam ® ™ ™ controls are designed to be installed inside or out- technical service representative if a 60 foot cable is required. -
Page 18: Ct Steamstop
Note: If an error code is detected by the system the LED indi- cator will flash. Refer to the iTempo/Plus or iSteam display for error code or call a Mr. Steam’s service technician. LED indicator will light up NOTE: For Illustrative Purposes Only. Drawings Not to Scale... -
Page 19: Care Tips For Controls And Steamhead
Plus call Mr.Steam technical service for replacement parts. NOTE: Replacement of the decorative covers requires removal and reinstallation of the control from the mounting surfaces. Warranty To view or download the Mr. Steam Steam Generator Warranty blog.mrsteam.com/wr and register your Product go to:... - Page 20 steam ® Feel Good Inc. www.mrsteam.com Products, information and specifications are subject to change without notice. Please call Sales & Support at 1.800.76.STEAM (East Coast) or 1.800.72.STEAM (West Coast) for more information. steam ® Sussman-Automatic Corporation ® I hello@mrsteam.com I www.mrsteam.com 43-20 34th Street, Long Island City, NY 11101 9410 S.
Need help?
Do you have a question about the CT6E and is the answer not in the manual?
Questions and answers