Table of Contents
Advertisement
Quick Links
Installation/Operator Manual
WARNING:
For your safety the
information in this manual must be
followed to minimize the risk of fire or
explosion and to prevent property
damage, personal injury or death.
— Do not store or use gasoline or other
flammable vapors and liquids in the
vicinity of this or any other appliance.
— WHAT TO DO IF YOU SMELL GAS:
• Do not try to light any appliance.
• Do not touch any electrical switch.
• Do not use any phone in your
building.
• Clear the room, building or area of all
occupants.
• Immediately call your gas supplier
from a neighbor's phone. Follow the
gas supplier's instructions.
• If you cannot reach your gas supplier,
call the fire department.
— Installation and service must be
performed by a qualified installer,
service agency or the gas supplier.
AD22
AVERTISSEMENT: Assurez-vous de
bien suivre les instructions données dans
cette notice pour réduire au minimum le
risque d'incendie ou d'explosion ou pour
éviter tout dommage matériel, toute
blessure ou la mort.
— Ne pas entreposer ni utiliser d'essence
ni d'autres vapeurs ou liquides
inflammables à proximité de cet
appareil ou de tout autre appareil.
— QUE FAIRE SI VOUS SENTEZ UNE
ODEUR DE GAZ:
• Ne pas tenter d'allumer d'appareils.
• Ne touchez à aucun interrupteur. Ne
pas vous servir des téléphones se
trouvant dans le bâtiment.
• Évacuez la pièce, le bâtiment ou la
zone.
• Appelez immédiatement votre
fournisseur de gaz depuis un voisin.
Suivez les instructions du
fournisseur.
• Si vous ne pouvez rejoindre le
fournisseur de gaz, appelez le
service des incendies.
— L'installation et l'entretien doivent être
assurés par un installateur ou un
service d'entretien qualifié ou par le
fournisseur de gaz.
American Dryer Corporation
Fall River MA 02720-4781 USA
Telephone: +1 (508) 678-9000 / Fax: +1 (508) 678-9447
e-mail: techsupport@amdry.com
88 Currant Road
www.adclaundry.com
ADC Part No. 113279- 7
Advertisement
Table of Contents
Related Manuals for ADC AD22
Summary of Contents for ADC AD22
- Page 1 American Dryer Corporation 88 Currant Road Fall River MA 02720-4781 USA Telephone: +1 (508) 678-9000 / Fax: +1 (508) 678-9447 e-mail: techsupport@amdry.com www.adclaundry.com ADC Part No. 113279- 7...
-
Page 2: For Your Safety
Replacement parts can be obtained from your reseller or the ADC factory. When ordering replacement parts from the factory, you can FAX your order to ADC at +1 (508) 678-9447 or telephone your order directly to the ADC Parts Department at +1 (508) 678-9000. Please specify the dryer model number and serial number in addition to the description and part number, so that your order is processed accurately and promptly. -
Page 3: Table Of Contents
WARNING WARNING Children should not be allowed to play on or near the dryer(s). Children should be Proposition 65 supervised if near dryer(s) in operation. Use of this product could expose you to substances Under no circumstances should the dryer door from fuel combustion that contain chemicals switch(es), lint door/drawer switch(es), or heat known to the State of California to cause cancer,... -
Page 4: Safety Precautions
Safety Precautions ___________________ WARNING WARNING Do not use heat for drying articles that contain plastic, foam, sponge rubber, or similarly textured rubber For your safety, the information in this manual must materials. Drying in a heated tumbler may damage be followed to minimize the risk of fire or explosion plastics or rubber and also may be a fire hazard. - Page 5 Use this dryer only for its intended purpose, drying fabrics. The “Cool Down” Cycle of tumble dryers should be used to reduce the temperature of the items. They should not be NOTES _____________________________________________________ removed from the tumble dryer or piled or stacked while hot. ____________________________________________________________ Fabric softeners or similar products should not be used in a tumble dryer to eliminate the effects of the static electricity,...
-
Page 6: Specifications
Specifications _____________________________________________________________________ MAXIMUM CAPACITY (DRY WEIGHT) 22 lb 9.98 kg 65.41 cm TUMBLER DIAMETER 25-3/4” 62.87 cm TUMBLER DEPTH 24-3/4” TUMBLER VOLUME 7-1/2 cu ft 212.38 L 0.25 kW TUMBLER/DRIVE MOTOR 1/3 hp BLOWER/FAN MOTOR B LOWER DRIVE N BY TUMBLER MOTOR DOOR OPENING (DIAMETER) 21-1/2”... - Page 7 Specifications _____________________________________________________________________ NOTE: The manufacturer reserves the right to make changes in specifications at any time without notice or obligation. 113279- 7 www.adclaundry.com...
-
Page 8: Installation Procedures
Installation Procedures ______________ Unpacking / Setting Up ________________ Installation should be performed by competent professional Remove protective shipping material (i.e., plastic wrap and in accordance with local, state, and country codes. In the optional shipping box) from the dryer. absence of these codes, the installation must conform to applicable American National Standards: ANSI Z223.1- IMPORTANT: Dryer must be transported and handled in an LATEST EDITION (National Fuel Gas Code) or ANSI/NFPA... -
Page 9: Fresh Air Supply Requirements
Domestic Type I A = 10-inches (25.4 cm) B = 6-inches (15.24 cm) EXAMPLE: For a bank of four dryers, two unrestricted openings measuring 10-inches by 6-inches (25.4 cm by 15.24 A = 6-inches (15.24 cm) B = 10-inches (25.4 cm) cm) are acceptable. - Page 10 Vertical Venting IMPORTANT: It is recommended that exhaust or booster fans not be used in the exhaust ductwork system. When vertical dryer venting is used, the length of the ductwork Exhaust back pressure measured by a manometer/ from the dryer to the outside exhaust outlet, must not exceed magnehelic in the exhaust duct must be no less than 0 and 12 feet (3.66 meters).
-
Page 11: Electrical Information
IMPORTANT: No more than four dryers should be Each dryer should be connected to an independently connected to one main common duct. protected branch circuit. The dryer must be connected with copper wire only. Do not use aluminum wire, which could The illustration below shows the minimum cross-sectional cause a fire hazard. -
Page 12: Gas Models Only
Electrical Service Specifications For added personal safety, when possible, it is suggested that a separate ground wire (size per local codes) be Gas Models Only connected from the ground connection of the dryer to a grounded cold water pipe. Do not ground to a gas pipe or ELECTRICAL SERVICE SPECIFICATIONS (PER POCKET) hot water pipe. -
Page 13: Gas Information
Single-Phase (1ø) Failure to isolate or disconnect the dryer from supply as Wiring Connections / Hookup noted can cause irreparable damage to the gas valve, voiding the warranty. The electrical input connections are made into the rear service box located at the upper right area of the dryer. To gain NOTE: The dryer must be isolated from the gas supply access, the service box cover must be removed. -
Page 14: Converting From One Family Of Gas To Another
Heat Input / Gas Consumption / Orifice (Injector) Data (For Non-CE [European] and Non-AGA [Australia] Models Only) Gas Specifications for Non-CE and Non-AGA Approved Dryers** Nominal Supply Gross Burner Orifice Orifice Size Heating Value Pressure Heat Input Pressure (Injector) Type Quantity B tu /ft in WC... - Page 15 The following conversion allows the dryer to be operated with rating (data) label/plate. either propane, butane, or LPG. The use of gas valve kit (ADC P/N 140414) disables the internal regulator of the gas CE Dryers valve. Therefore, the gas supply is ungoverned and an external regulator must be provided at the source of the Affix new data plate label that came with the conversion kit.
-
Page 16: Preparation For Operation / Start-Up
(refer to the illustration on page 15). screw (under vent cap). Remove spring under screw 60 Hz dryers: Install pressure tap and attach manometer (refer and replace with spring from kit (ADC P/N 140415). to the illustration on page 15). Replace regulator adjustment screw. -
Page 17: Preoperational Test
Tumbler Coating • Be sure all back panels (guards) and electric box covers are in place. The tumbler is treated with a protective coating. We suggest • Be sure the service doors are closed and securely in dampening old garments or cloth material with a solution of place. -
Page 18: Shutdown Instructions
NOTE: Be sure to include the installation date when Shipping charges are not the responsibility of ADC. All returns returning the warranty card(s). should be “prepaid” to the factory. Any “C.O.D.” or “COLLECT”... -
Page 19: Routine Maintenance
IMPORTANT: No replacements, credits, or refunds will be NOTE: To prevent damage, avoid cleaning and/or touching issued if the claim cannot be processed due to insufficient ignitor/flame-probe assembly. information. The party filing the claim will be notified in Every 6 Months writing, either by “FAX”... -
Page 20: Data Label Information
Data Label Information ____________________________________________________________ Standard Label CE Label AGA Label When contacting ADC, the information on the data label is required to ensure proper service/parts assistance. The data label is located at the upper left rear of the dryer behind the back guard. - Page 21 NOTES __________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ 113279- 7 www.adclaundry.com...
- Page 22 ADC Part No. 113279 7 - 10/30/13...