Polaris PTV 4x4 Series 10 Owner's Manual page 75

MAINTENANCE AND LUBRICATION
Periodic Maintenance Schedule
Item
Oil Filter
"
L
Engine breather
L
hose
Carburetor float
bowl
Throttle Cable/ETC
J
Switch
Choke (enricher)
L
cable
Coolant strength/
pressure test sys-
tem
Front hubs/fluid
"
check
Shift linkage
Drive belt
J
Steering
"
Front suspension
"
Rear suspension
"
Spark plug
L
Rear axle
"
Ignition Timing
J
L
Fuel system
J
L
Fuel filter
J
More often under severe use, such as dirty or wet conditions
"
Emission Control System Service (California)
L
Dealer service item
J
Hours/ Frequency Remarks
Miles
100 hrs./ 6 months
1000 mi.
100 hrs. 6 months
50 hrs. 6 months
50 hrs. 6 months
50 hrs. 6 months
100 hrs. 6 months
50 hrs. 6 months
50 hrs. 6 months
50 hrs. 6 months
50 hrs. 6 months
50 hrs. 6 months
50 hrs. 6 months
100 hrs. 12 months
50 hrs. 6 months
100 hrs. 12 months
100 12 months
hours
100 hrs. 12 months
Replace with oil change
Inspect
Drain bowl periodically and
prior to storage
Inspect; adjust; lubricate;
replace if necessary
Inspect; adjust; lubricate;
replace if necessary
Inspect strength seasonal-
ly; pressure test system
annually
Check monthly
Inspect; adjust
Inspect; replace as needed
Inspect daily; lubricate
Inspect; lubricate; tighten
fasteners
Inspect; tighten fasteners
Inspect; replace as needed
Inspect bearings; lube
Inspect; adjust as needed
Check for leaks at tank
cap, lines, fuel valve, filter,
pump and carburetor; re-
place lines every two years
Replace annually
73