Polaris UTV Series 10 2x4 Owner's Manual page 60

MAINTENANCE AND LUBRICATION
Periodic Maintenance Schedule
Item
J Steering
" Front Suspension
" Rear Suspension
Coolant strength/
pressure test system
Engine Mounts
Valve Clearance
J
L
L Spark Plug
Ignition Timing
J
L
J Front Hub Bearings
Fuel System
J
L
J Fuel Filter
Cooling System
hoses
Spark arrestor
" Front Gearcase Oil
J Clutches (drive and
driven)
J Brake fluid
J Front wheel bearings
L Idle Speed
Engine side cover
J Toe adjustment
Headlight Aim
" More often under severe use, such as dirty or wet conditions
L Emission Control System Service (California)
58
Frequency Remarks
50 hrs Inspect; lubricate
50 hrs Inspect; lubricate, tighten fasteners
50 hrs Inspect, tighten fasteners
100 hrs Inspect strength seasonally; pres-
sure test system annually
100 hrs Inspect
100 hrs Inspect; adjust
100 hrs Inspect; replace if necessary
100 hrs Inspect and adjust as needed
100 hrs Check at 100 hours and replace as
required
100 hrs Check for leaks at fuel cap, lines,
fuel valve, filter, pump and carbure-
tor. Replace lines every two years.
100 hrs Replace annually
100 hrs Inspect
100 hrs Clean out
100 hrs Check monthly; change annually
100 hrs Inspect, clean
200 hrs Change every two years
300 hrs Inspect; replace if necessary
As Required Adjust
As required Drain moisture after driving in water
As required Periodic inspection, adjust when
parts are replaced
As required Adjust if necessary