Koninklijke Philips Electronics N.V. or their respective owners. TP Vision Netherlands B.V. reserves the right to change products at any time without being obliged to adjust earlier supplies accordingly. PHILIPS and the PHILIPS’ Shield Emblem are used under license from Koninklijke Philips Electronics N.V.
EN 2 TPS14.4A LA Revision List 1. Revision List Manual xxxx xxx xxxx.0 • Chapter 5: Updated table 5-1 Factory mode overview. • First release. • Chapter 7: Updated figure 7-2 Power Architecture table 7-1 Connector overview. • Chapter 10: Added circuit diagrams 10.2 A 715G6353...
Page 3
Technical Specs, Diversity, and Connections TPS14.4A LA EN 3 Connections 19740_001.eps Figure 2-1 Connection overview Note: The following connector colour abbreviations are used 5 - USB2 2.0 (acc. to DIN/IEC 757): Bk= Black, Bu= Blue, Gn= Green, Gy= Grey, Rd= Red, Wh= White, Ye= Yellow.
Page 4
EN 4 TPS14.4A LA Technical Specs, Diversity, and Connections - D0+ Data channel - Video Red 0.7 V / 75 W - Shield - Video Green 0.7 V / 75 W - D0- Data channel - Video Blue 0.7 V...
Spare Parts the following points: • Route the wire trees correctly and fix them with the For the latest spare part overview, consult your Philips Spare mounted cable clamps. Part web portal. • Check the insulation of the Mains/AC Power lead for external damage.
Page 6
EN 6 TPS14.4A LA Precautions, Notes, and Abbreviation List result in sets which have the same CTN (Commercial Type 6 = play 16 : 9 format, 12 = play 4 : 3 Number; e.g. 28PW9515/12) but which have a different B.O.M.
Page 7
Precautions, Notes, and Abbreviation List TPS14.4A LA EN 7 DRAM Dynamic RAM a maximum data rate of 270 Mbit/s, Digital Rights Management with a minimum bandwidth of 135 Digital Signal Processing MHz. Dealer Service Tool: special remote Institutional TeleVision; TV sets for control designed for service hotels, hospitals etc.
Page 8
SOPS Self Oscillating Power Supply Serial Peripheral Interface bus; a 4-wire synchronous serial data link standard S/PDIF Sony Philips Digital InterFace SRAM Static RAM Service Reference Protocol Small Signal Board Spread Spectrum Clocking, used to reduce the effects of EMI...
Mechanical Instructions TPS14.4A LA EN 9 4. Mechanical Instructions Index of this chapter: Notes: 4.1 Cable Dressing • Figures below can deviate slightly from the actual situation, 4.2 Service Positions due to the different set executions. 4.3 Assembly/Panel Removal (for 55PFH6009/96) 4.4 Assembly/Panel Removal (for 42"/50"PFH5009 series)
Page 10
EN 10 TPS14.4A LA Mechanical Instructions ECN701 ECN103 CN8101 CN9301 WIFI Module (WiFi01) CN601 CN701 CN403 MAIN POWER SUPPLY (1054) (1053) ECN401 ECN601 ECN401 ECN601 ECN403 LOUDSPEAKER LOUDSPEAKER (1184) (1184) IR/LED BOARD (1056) 19741_101.eps Figure 4-2 Cable dressing (5009 series 50")
Page 11
Mechanical Instructions TPS14.4A LA EN 11 Service Positions 4.3.1 Rear Cover For easy servicing of a TV set, the set should be put face down on a soft flat surface, foam buffers or other specific workshop Refer to Figure 4-4 for details.
Page 12
EN 12 TPS14.4A LA Mechanical Instructions 4.3.2 AmbiLight Panel from the FFC connector that connect with the AmbiLight control panel [3]. 2. Lift the AmbiLight panel from the rear cover. Make sure that Refer to Figure 4-5 for details. wires and flat foils are not damaged while lifting the ambilight panel from the rear cover.
Page 13
Mechanical Instructions TPS14.4A LA EN 13 4.3.4 Power Supply Unit (PSU) 4.4.1 Stand Caution: it is mandatory to remount all different screws at their Refer to Figure 4-7 for details. original position during re-assembly. Failure to do so may result 1.
Page 14
EN 14 TPS14.4A LA Mechanical Instructions M4× 16 19741_103.eps Figure 4-7 Stand removal 4.4.2 Rear Cover Refer to Figure 4-8 for details. Warning: Disconnect the mains power cord before removing the rear cover. 1. Remove the fixation screws [1] and [2] that secure the rear cover.
Page 15
Mechanical Instructions TPS14.4A LA EN 15 M3× 8 M3 × 6 Q3 × 8 19741_102.eps Figure 4-8 Rear cover removal 4.4.3 Keyboard Control Unit Refer to Figure 4-9 for details. 1. Release the connector [2] from the keyboard control panel.
Page 16
EN 16 TPS14.4A LA Mechanical Instructions 19741_104.eps Figure 4-9 Keyboard Control unit removal 4.4.4 Small Signal Board (SSB) Refer to Figure 4-10 for details. Caution: it is mandatory to remount all different screws at their original position during re-assembly. Failure to do so may result in damaging the SSB.
Page 17
Mechanical Instructions TPS14.4A LA EN 17 4.4.6 Speakers 1. Gently release the tapes that secure the speaker cables. 2. Unplug the speaker connector from the SSB. 3. Take the speakers out. When defective, replace the both units. 4.4.7 IR/LED Board 1.
EN 18 TPS14.4A LA Service Modes and Fault Finding 5. Service Modes and Fault Finding Index of this chapter: Note: For the new model range, a new remote control (RC) is 5.1 Test Points used with some renamed buttons. This has an impact on the 5.2 Service Modes...
Page 19
A description on how to upgrade the main check that what the current TV software: software can be found in the DFU or on the Philips website. 1. Press the “Home screen” + “1999” + “Back” button on the remote control to enter the Factory mode.
Page 20
EN 20 TPS14.4A LA Service Modes and Fault Finding 5.4.5 Update the TV software • FUS_clustername_version.zip: Contains the “autorun.bin” which is needed to upgrade the TV main software and the software download application. 1. Turn the TV on and wait for it to boot completely.
Alignments TPS14.4A LA EN 21 6. Alignments Index of this chapter: 6.1 General Alignment Conditions 6.2 Reset of Repaired SSB General Alignment Conditions Perform all electrical adjustments under the following conditions: , 50/ 60 3 Hz. • Power supply voltage: 90 - 264 V •...
7. Circuit Descriptions Index of this chapter: Introduction 7.1 Introduction The TPS14.4A LA is a new chassis launched in Taiwan in 7.2 Power Supply 2014. The whole range is covered by MSD8560QV. The major 7.3 DC/DC Converters deltas versus its predecessor support DVB-T/NTSC, with 7.4 Front-End Analogue ATV reception...
Page 23
Circuit Descriptions TPS14.4A LA EN 23 7.1.3 SSB Cell Layout SPDIF DC/DC Audio Out MSD8560QV HDMI HDMI NETWORK HDMI PC/DVI Analog Input ANALOG I/O 19740_200.eps Figure 7-1 SSB layout cells (top view) back to 2014-Jul-11 div. table...
Page 24
7.2.2 Diversity specifications. This part is available in the regular market. Consult the Philips Service web portal for the order codes of the The diversity in power supply units is mainly determined by the boards. diversity in displays.
Page 25
Circuit Descriptions TPS14.4A LA EN 25 Connector 42" 50" 55" CN8101 CN9101 CN8101 CN9301 CN8501 CN902 Descr. to panel to SSB to panel to SSB to panel to SSB n.c. n.c. LED_10 24VA n.c. n.c. n.c. 24VA n.c. n.c. n.c.
Page 26
EN 26 TPS14.4A LA Circuit Descriptions P24V PANEL LED Driver U601 AD82588B AMP_24V For Audio Am plifier P12V Q403 AO4449-7A PANEL LVDS Pow er USB_5V U703 G5312QN1U For USB Port +5VSB 3V3_STB +5VSB U701 AP1117E33L-13-77 U401 MSD8560QV For MSD8560QV U405 MX25L1606EM2I-12G...
Page 27
Circuit Descriptions TPS14.4A LA EN 27 • DVB-T/DVB-C Front-End Demodulator • 3D Formatter Engine • A Multi-standard A/V Format Decoder • Home Theater Sound Processor • Internet and Variety of Connectivity support • Peripheral and power Management The MSD8560QV integrates DTV/multi-media all-purpose AV decoder, DVB-T/DVB-C demodulator, and sound/Video processor into a single device.
EN 28 TPS14.4A LA IC Data Sheets 8. IC Data Sheets This chapter shows the internal block diagrams and pin configurations of ICs that are drawn as “black boxes” in the electrical diagrams (with the exception of “memory” and “logic”...
Page 29
IC Data Sheets TPS14.4A LA EN 29 Diagram 10-4-9 Karaoke/MIC In/Audio Output B09, WM8782SEDS/RV (IC U602) Block diagram Pinning information MCLK AINL DOUT AINOPL LRCLK DGND DVDD AINR AINOPR BCLK AGND FSAMPEN AVDD FORMAT VREFP VREFGND VMID 19740_302.eps Figure 8-2 Internal block diagram and pin configuration...
Page 30
EN 30 TPS14.4A LA IC Data Sheets Diagram 10-4-9 Karaoke/MIC In/Audio Output B09, YSS952 (IC U603) Block diagram YSS952 Pinning information DVSS GPIO10 GPIO9 IOVDD YSS952 GPIO8 XOUT (QFN32) IOVDD (Top View) GPIO7 PLLVSS DVDD18 PLLVSS GPIO6 IC_N 19740_303.eps Figure 8-3 Internal block diagram and pin configuration...
Page 31
IC Data Sheets TPS14.4A LA EN 31 Diagram 10-4-9 Karaoke/MIC In/Audio Output B09, WM8524CGEDT/R (IC U604) Block diagram WM8524 Pinning information 19740_304.eps Figure 8-4 Internal block diagram and pin configuration back to 2014-Jul-11 div. table...
Page 32
EN 32 TPS14.4A LA IC Data Sheets Diagram 10-4-12 Power B12, G5312QN1U (IC U703) Block diagram G5312QN1U On-Time On-Time PGOOD PGOOD Off-Time Off-Time DISCHG DISCHG controller controller PGND PGND 0.75V 0.75V Reference Reference AGND AGND ILIM ILIM Pinning information ILIM...
Page 33
IC Data Sheets TPS14.4A LA EN 33 Diagram 10-4-12 Power B12, G5196R41D (IC U704) Block diagram G5196R41D VINA Thermal SHDN UVLO Shutdown Logic Enable Boot Comparator Charge 107% Shutdown SHDN Enable Logic Threshold Voltage Reference Current Minimum Boot Sense Clamp...
Page 34
EN 34 TPS14.4A LA IC Data Sheets Personal Notes: 10000_012_090121 back to 2014-Jul-11 div. table...
Block Diagrams TPS14.4A LA EN 35 9. Block Diagrams Block diagram 6009 series Tuner LVDS LCD PANEL TDSH-T070F NOR FLASH ROM CVBS (Share with YPbPr Y) VIDEO MX25L1606EM2I-12G YPbPr YPbPr NAND FLASH ROM THGBM5G6A2JBAIR Hsync, Vsync DDR III x 2...
Circuit Diagrams and PWB Layouts TPS14.4A LA EN 69 10.6 E 715G6316 Keyboard control panel 10-6-1 Direction switch Key function Resistance Voltage Center 2-5 short Menu Right 1-5 short 0.5V Left 4-5 short 0.81V Down 3-5 short VOL- 1.65V CN01...
Page 70
Circuit Diagrams and PWB Layouts TPS14.4A LA EN 70 10-6-2 Key board layout Layout Keyboard control panel (top side) SW01 Layout Keyboard control panel (bottom side) 2013-09-17 Keyboard control panel 715G6316 layout top/bottom 19610_546.eps back to 2014-Jul-11 div.table...
Circuit Diagrams and PWB Layouts TPS14.4A LA EN 71 10.7 AL 715G6280 LED Board 10-7-1 9-LED Side AL01 AL01 9-LED Side D301 R302 D302 R303 D303 CN301 75 OHM +-1% 1/10W 75 OHM +-1% 1/10W Blue Vf=3.2v If=20mA R=300ohm R304...
Page 72
Circuit Diagrams and PWB Layouts TPS14.4A LA EN 72 10-7-2 LED Board layout Layout LED Board (top side) D301 D302 D303 D304 D305 D306 D308 D307 D309 Layout LED Board (bottom side) CN302 CN301 LED Board 715G6280 layout top/bottom 19740_516.eps...