All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise without the prior permission of Philips. Published by MB/WS 1168 BU TV Consumer Care, the Netherlands...
EN 2 TPM5.1E LA Revision List 1. Revision List Manual xxxx xxx xxxx.0 Manual xxxx xxx xxxx.3 • First release. • Added models 42PFL3405H/12 Manual xxxx xxx xxxx.1 • Chapter 2: Added the new model in Table 2-1. • Added models 47PFL3605H/xx to the manual •...
Page 4
EN 4 TPM5.1E LA Technical Specifications, Connections Note: The following connector colour abbreviations are used - Audio R 0.5 V / 1 kΩ (acc. to DIN/IEC 757): Bk= Black, Bu= Blue, Gn= Green, - Audio R 0.5 V / 10 kΩ...
3.3.3 Spare Parts external damage. • Check the strain relief of the Mains/AC Power cord for For the latest spare part overview, consult your Philips Spare proper function. Part web portal. • Check the electrical DC resistance between the Mains/AC...
Page 6
EN 6 TPM5.1E LA Precautions, Notes, and Abbreviation List The third digit in the serial number (example: Abbreviation List AG2B0335000001) indicates the number of the alternative B.O.M. (Bill Of Materials) that has been used for producing the 0/6/12 SCART switch control signal on A/V specific TV set.
Page 7
Precautions, Notes, and Abbreviation List TPM5.1E LA EN 7 Directions For Use: owner's manual SDI), is a digitized video format used Digital Media Reader: card reader for broadcast grade video. DMSD Digital Multi Standard Decoding Uncompressed digital component or Digital Natural Motion digital composite signals can be used.
Page 8
SOPS Self Oscillating Power Supply Serial Peripheral Interface bus; a 4- wire synchronous serial data link standard S/PDIF Sony Philips Digital InterFace SRAM Static RAM Service Reference Protocol Small Signal Board Spread Spectrum Clocking, used to reduce the effects of EMI...
Mechanical Instructions TPM5.1E LA EN 9 4. Mechanical Instructions Index of this chapter: 4.5 Assembly/Panel Removal 42" 4.1 Cable Dressing 4.6 Returning a defect 32" or 42" Dali styling, LCD panel 4.2 Service Positions 4.7 Assembly/Panel Removal 47" 4.3 Assembly/Panel Removal 32" Dali 4.8 Set...
Page 10
EN 10 TPM5.1E LA Mechanical Instructions 18850_101_100107.eps 100202 Figure 4-2 Cable dressing (32" Dali styling) 18850_100_100107.eps 100209 Figure 4-3 Cable dressing (42" Dali styling) 2011-Sep-02...
Page 11
Mechanical Instructions TPM5.1E LA EN 11 18850_103_100505.eps 100505 Figure 4-4 Cable dressing (47" Dali styling) Service Positions 6. Remove the screws near the HDMI and L/R audio connectors. 7. The SSB can now be shifted sidewards away from the side For easy servicing of a TV set, the set should be put face down connector cover and take out of the shielding.
Page 12
EN 12 TPM5.1E LA Mechanical Instructions 4.3.4 Stand removal 4.3.8 Keyboard Control Panel Figure 4-5. 1. Release the IR/LED/Keyboard Control cable from its Caution: it is mandatory to remount all different screws at their clamps. original position during re-assembly. Be sure to put the set in 2.
Page 13
Mechanical Instructions TPM5.1E LA EN 13 4.4.3 Power Supply Unit (PSU) 3. Release the tape near the tuner from the LCD panel. 4. Release the tape near the processor shielding from the LCD panel. Caution: it is mandatory to remount all different screws at their 5.
Page 14
EN 14 TPM5.1E LA Mechanical Instructions 4.5.7 IR/LED Board 1. Remove the stand as described earlier. 2. Remove the speakers as described earlier. 3. Remove the SSB as described earlier. 4. Remove the clips at the bottom that secure the LCD panel with the bezel.
Page 15
Mechanical Instructions TPM5.1E LA EN 15 Assembly/Panel Removal 47" 4.7.9 LCD Panel 1. Remove the stand as described earlier. 4.7.1 Stand removal 2. Remove the stand support plate as described earlier. 3. Remove the speakers as described earlier. Caution: it is mandatory to remount all different screws at their 4.
EN 16 TPM5.1E LA Service Modes, Error Codes, and Fault Finding 5. Service Modes, Error Codes, and Fault Finding Index of this chapter: 5.1 Service Modes 5.2 Service Tools 5.3 Software Upgrading 5.4 Error Codes 5.5 Fault Finding and Repair Tips...
Page 17
Service Modes, Error Codes, and Fault Finding TPM5.1E LA EN 17 • 3.7 HDMI video format input stream Per Supported format. e.g. 576i 50 Hz, 576p 50 Hz, 720p 50 Hz, 1080i 50 Hz, 1080p 50 Hz How to Exit CSM Press “MENU”...
Page 18
• When the Hotel mode is active, the service modes CSM, SDM, SAM and ComPair are automatically disabled (this is to prevent hotel guests entering Philips service modes). • In order to use the service modes and ComPair, Hotel mode must be disabled.
Page 19
5.2.1 ComPair Introduction ComPair (Computer Aided Repair) is a Service tool for Philips Consumer Electronics products. and offers the following: 1. ComPair helps to quickly get an understanding on how to repair the chassis in a short and effective way.
Page 20
Software Upgrading 5.3.1 Introduction Philips continuously tries to improve its products, and we recommend that you update the TV software when updates are available. Software update files can be obtained from your dealer or can be downloaded from the following websites: http://www.philips.com/support...
Page 21
Service Modes, Error Codes, and Fault Finding TPM5.1E LA EN 21 Error Codes The error code buffer contains all errors detected since the last time the buffer was erased. The buffer is written from left to right. When an error occurs that is not yet in the error code buffer, it is displayed at the left side and all other errors shift one position to the right.
EN 22 TPM5.1E LA Alignments 6. Alignments Index of this chapter: Alignment: 6.1 General Alignment Conditions 1. At SAM mode menu, select AUTO_COLOR item. Then 6.2 Hardware Alignments press “OK” key to adjust ADC_GAIN_R, ADC_GAIN_G, 6.3 YPbPr Mode display adjustment ADC_GAIN_B and ADC_OFFSET_R, ADC_OFFSET_G, 6.4 PC mode display adjustment...
Page 23
Alignments TPM5.1E LA EN 23 PC mode display adjustment Input requirements: Input Signal Type: PC VGA signal or software built-in test pattern, 1920 × 1080/60 Hz PC mode with “Pixel ON/OFF” 6.4.1 Display quality adjustment pattern, see Figure 6-2. Use timing mode and use the POPO (pixel on pixel off) pattern...
Page 24
EN 24 TPM5.1E LA Alignments 6.6.2 Option Code Overview Enter SAM mode to check the option codes. They can not be edited in the NVM. 6.6.3 Display Code Overview Press the following key sequence on a standard RC transmitter: “062598” directly followed by MENU and “xxx”, where “xxx”...
Diagrams. An overview of the TPM5.1E LA architecture you will find a separate drawing for clarification. can be found in Figure 7-1. Introduction The TPM5.1E LA chassis is used the MT5363LICG main processing. DDR2 1GHz NOR Flash NAND Flash 512 kByte 64 MByte ×...
Page 26
EN 26 TPM5.1E LA Circuit Descriptions LED LCD Panel NOR Flash 512KB TUNER NAND Flash 16MB TTL/ LVDS 24C02 24C64 HDMI EDID 64 MB DDR2 × 2 REAR HDMI REAR HDMI 24C02 HDMI EDID IF BPF SIDE HDMI ADIN4_SRV,ADIN2_SRV CVBS1...
Page 27
Circuit Descriptions TPM5.1E LA EN 27 7.1.3 SSB Cell Layout SERVICE AUDIO CLASS - D ANALOG I/O CONNECTOR TUNER DC/DC DIGITAL I/O MT5363H COMMON INTERFACE TCON 18850_208_100204.eps 100222 Figure 7-3 Dali SSB layout cells (top view) 2011-Sep-02...
Page 28
EN 28 TPM5.1E LA Circuit Descriptions AUDIO CLA SS - D COMMON INTERFACE DC/DC MT5363 ANALOG I/O TUNER DIGITAL I/O DIGITAL I/O ANALOG I/O S ERVICE CONNECTOR 18840_206_100406.eps 100428 Figure 7-4 Smart Choice SSB layout cells (top view) 2011-Sep-02...
Page 30
EN 30 TPM5.1E LA Circuit Descriptions ” 6 18840_205_100324.eps 1004288 Figure 7-6 Smart Choice Power Architecture All power supplies are a black box for Service. When defective, a new board must be ordered and the defective one must be returned, unless the main fuse of the board is broken. Always replace a defective fuse with one with the correct specifications! This part is available in the regular market.
Page 31
Circuit Descriptions TPM5.1E LA EN 31 T-CON Architecture Refer to figure Figure 7-7 for the power architecture of this platform. CN7050 / CN7051 U7000 RML0-5 / RML CLK LML0-5 / LML CLK LVDS In TCON LCD Panel U7052 Level shift...
EN 32 TPM5.1E LA IC Data Sheets 8. IC Data Sheets This section shows the internal block diagrams and pin configurations of ICs that are drawn as “black boxes” in the electrical diagrams (with the exception of “memory” and “logic”...
Page 33
IC Data Sheets TPM5.1E LA EN 33 Pinning information LT 1 RCLK0_ RDQ10 RDQ15 RDQS0_ RDQ14 RDQ12 AO1N AOCKN VCC2IO RCLK0 RDQ8 RDQS1 RDQS0 RDQ11 VCC2IO AO0N AO2N AO3N VCC2IO RDQ13 RDQS1_ DVSS RDQM1 VCC2IO AOCKP AO1P VCC2IO RDQ5 RDQ0...
Page 34
EN 34 TPM5.1E LA IC Data Sheets Pinning information DVSS GPIO32 GPIO26 GPIO17 GPIO9 ETTXD3 ETRXCLK ETRXD1 ETRXDV ETCRS AO4P GPIO36 GPIO28 GPIO22 GPIO11 GPIO4 ETTXD1 ETRXD3 ETMDIO DVSS GPIO34 GPIO27 GPIO18 GPIO10 ETTXEN ETTXCLK ETRXER ETMDC DVSS GPIO30 GPIO20...
Page 35
IC Data Sheets TPM5.1E LA EN 35 Diagram B14 SSB Dali: T-CON power, PF57 TQFN-40 (IC U7053) Block diagram (12V) 3.3V STEP- STEP- PGND DOWN COMP 100k 330pF GND2 AGND FSEL AVDD 3.3V 1.5A PGOOD RESET PGOOD CRST AGND Step-down, Negative...
Page 36
EN 36 TPM5.1E LA IC Data Sheets Diagram B06 SSB Dali: DDR2 memory, NT5TU32M16CG-BD (IC U402, U403) Block diagram Bank3 Bank2 Bank1 CK, CK Mode Registers 8192 Bank0 Data Memory Array (8192 x 256 x 64) Sense Amplifiers Generator LDQ0-LDQ7...
Page 37
IC Data Sheets TPM5.1E LA EN 37 Diagram B12 SSB Dali: Audio Amp/Headphone out, TPA6132A2RTER 25mW QFN-16 (IC U602) Block diagram HPVDD Supply 2.2 F Control PGND HPVDD INL- Resistor OUTL Array INL+ Short-Circuit HPVSS Protection Thermal HPVDD Protection INR-...
Page 38
EN 38 TPM5.1E LA IC Data Sheets Diagram B15 SSB Dali: T-CON main chip, TL2428MC LQPF-176 (IC U7000) Block diagram RLV0~6P/M LLV0~6P/M SOE,POL Source Source Source Source Driver 1 Driver 2 Driver 5 Driver 8 LVDS Internal Input SSIC 1RxA~E...
Page 39
IC Data Sheets TPM5.1E LA EN 39 Diagram B14 SSB Dali: T-CON power, TPS65192RHDR QFN-28 (IC U7052) Block diagram FLK1 FLK2 VGH1 FLK3 OUT1 OUT2 OUT3 OUT4 OUT5 OUT6 OUT7 VSENSE DISCHARGE VGH2 OUT8 OUT9 Pinning information OUT9 OUT8 OUT7...
Styling Sheets TPM5.1E LA EN 96 11. Styling Sheets Styling Sheet Dali 32" DALI 32" Pos No. Description Remarks FRONT CABINET REAR COVER STAND ASSY STAND NECK 1176 REMOTE CONTROL FOR ELECTRICAL PARTS/ASSEMBLIES SEE WIRING DIAGRAM CHAPTER 9 18850_800_100309.eps 100309...
Styling Sheets TPM5.1E LA EN 97 Styling Sheet Smart Choice 32" Smart Choice 32" Pos No. Description Remarks BEZEL ASSY REAR COVER BASE _ASSY BASE _NECK 1176 REMOTE CONTROL NOT DISPLAYED FOR ELECTRICAL PARTS/ASSEMBLIES SEE WIRING DIAGRAM CHAPTER 9 18854_800_110817.eps...
Styling Sheets TPM5.1E LA EN 98 Styling Sheet Dali 42" DALI 42" Pos No. Description Remarks FRONT CABINET REAR COVER STAND ASSY STAND NECK 1176 REMOTE CONTROL FOR ELECTRICAL PARTS/ASSEMBLIES SEE WIRING DIAGRAM CHAPTER 9 18850_801_100309.eps 100309 2011-Sep-2...
Styling Sheets TPM5.1E LA EN 99 Styling Sheet Dali 47" DALI 47" Pos No. Description Remarks FRONT CABINET REAR COVER STAND ASSY 1176 REMOTE CONTROL FOR ELECTRICAL PARTS/ASSEMBLIES SEE WIRING DIAGRAM CHAPTER 9 18850_802_100507.eps 110830 2011-Sep-2...