Page 1: Table Of Contents
All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise without the prior permission of Philips. Published by CS 0864 BU CD Consumer Care...
Page 2: Technical Specifications, Connections, And Chassis Overview
EN 2 TPM1.3E LA Technical Specifications, Connections, and Chassis Overview 1. Technical Specifications, Connections, and Chassis Overview Index of this chapter: Horizontal scan 1.1 Technical Specifications Horizontal : 30~81kHz 1.2 Connection Overview Vertical : 56~76Hz 1.3 Chassis Overview Product dimension (HxWxD) : 392.27mm x...
Page 3 Technical Specifications, Connections, and Chassis Overview TPM1.3E LA EN 3 Chassis Overview I_17570_007.eps 170408 Figure 1-3 Chassis Overview (19PFL3403D/10) I_17570_008.eps 170408 Figure 1-4 Chassis Overview (22PFL3403D/10)
Page 4: Safety Instructions, Warnings, And Notes
Complete kit ESD3 (small tablemat, wristband, by the workshop during a repair: connection box, extension cable and earth cable) 4822 • Use only lead-free soldering tin Philips SAC305 with order 310 10671. code 0622 149 00106. If lead-free solder paste is required, –...
Page 5: Directions For Use
Mix of lead-free soldering tin/parts with leaded soldering example below it is 2006 week 17). The 6 last digits contain the tin/parts is possible but PHILIPS recommends strongly to serial number. avoid mixed regimes. If this cannot be avoided, carefully clear the solder-joint from old tin and re-solder with new tin.
Page 6: Mechanical Instructions
EN 6 TPM1.3E LA Mechanical Instructions 4. Mechanical Instructions Index of this chapter: 1. Cable Dressing Notes: 2. Service Positions • Figures below can deviate slightly from the actual situation, 3. Assy/Panel Removal due to the different set executions. 4. Re-assembly •...
Page 7 Mechanical Instructions TPM1.3E LA EN 7 I_17570_010.eps 170408 Figure 4-2 Cable dressing (22PFL3403D/10)
Page 8 EN 8 TPM1.3E LA Mechanical Instructions Service Positions Assy/Panel Removal For easy servicing of this set, there are a few possibilities 4.3.1 Stand/Base created: • The buffers from the packaging (see figure “Rear cover”). Remove the screws marked in red to remove the stand or base.
Page 9 Mechanical Instructions TPM1.3E LA EN 9 4.3.2 Rear Cover 1. Remove the screws marked in red, which secure the rear cover. 2. Lift the rear cover from the cabinet. Make sure that wires and flat foils are not damaged during cover removal.
Page 10 EN 10 TPM1.3E LA Mechanical Instructions 4.3.5 Scaler Board 1. Refer to next figure. 2. Unplug connectors marked in blue. 3. Release screws marked in red and remove the scaler board. When defective, replace the whole unit. I_17570_020.eps 180408 Figure 4-13 Speakers (22PFL3403D/10) 4.3.8...
Page 11 Mechanical Instructions TPM1.3E LA EN 11 4.3.9 Bracket/Main Frame 1. Refer to next two figures. 2. Remove the screws marked in red. I_17570_023.eps 180408 Figure 4-16 Bracket (19PFL3403D/10) I_17570_024.eps 180408 Figure 4-17 Main Frame (22PFL3403D/10) Set Re-assembly To re-assemble the whole set, execute all processes in reverse order.
Page 12: Service Modes, Error Codes, And Fault Finding
EN 12 TPM1.3E LA Service Modes, Error Codes, and Fault Finding 5. Service Modes, Error Codes, and Fault Finding Index of this chapter: How to Navigate 5.1 Test Points By mean of the “CURSOR-DOWN/UP” knob on the RC- 5.2 Service Mode transmitter on the screen.
Page 13 5.3.1 ComPair Introduction ComPair (Computer Aided Repair) is a Service tool for Philips Consumer Electronics products. and offers the following: 1. ComPair helps you to quickly get an understanding on how to repair the chassis in a short and effective way.
Page 14 EN 14 TPM1.3E LA Service Modes, Error Codes, and Fault Finding Personal Notes: E_06532_012.eps 131004...
Page 15: Block Diagrams, Test Point Overview, And
Block Diagrams, Test Point Overview, and Waveforms TPM1.3E LA 6. Block Diagrams, Test Point Overview, and Waveforms Wiring Diagram 19PFL3403D/10 WIRING DIAGRAM 19” Panel Board 5 Pin CN101 095T8018 3DH06 LVDS Cable 095T 82011X511 11 Pin WIRE HARNESS CN902 30 Pin...
Page 16: Wiring Diagram 22Pfl3403D/10
Block Diagrams, Test Point Overview, and Waveforms TPM1.3E LA Wiring Diagram 22PFL3403D/10 WIRING DIAGRAM 22” Panel Board 5 Pin CN101 095T8018 3XH06 LVDS Cable 095T 82011X503 11 Pin WIRE HARNESS CN902 30 Pin CN802 CN602 CN301 CN801 MT5335PGU Head Phone...
Page 17: Block Diagram Scaler Board
Block Diagrams, Test Point Overview, and Waveforms TPM1.3E LA Block Diagram Scaler Board Audio AMP TDA8932BTW Sub MCU DDR SDRAM WT6702F_OG200WT SB-15 HY5DU121622DTP-D43 3.3V 2.5V Common Interface Controller SB-11 SB-09 PCMCIA MT8295 5V,3.3V 3.3V,1.8V Power SB-18 SB-18 Power Board MT5335PGU 3.3V,2.5V,1.8V,1.2V,1.1V...
Page 18: Circuit Diagrams And Pwb Layouts
Circuit Diagrams and PWB Layouts TPM1.3E LA 7. Circuit Diagrams and PWB Layouts Scaler (19"): VGA IN/L/R VGA IN/L/R SB01 SB01 CN108 CN108 VGA_PLUGPWR R244 R244 NEARLY VGA CON. NEARLY IC U0RX ZD124 C3 ZD121 D3 R245 R245 U0TX C122 B4 C192 C5...
Page 19: Scaler (19"): Ypbpr/L/R & Spdif
Circuit Diagrams and PWB Layouts TPM1.3E LA Scaler (19"): YPbPr/L/R & SPDIF YPbPr/L/R & SPDIF SB02 SB02 NEARLY YPBPR CONNECTOR U401E U401E R105 R105 C104 4700pF C104 4700pF SOY0 DVDD12_VGA SOY1 SOY0 SOY0 DVDD12_VGA L108 L108 0 OHM 1/10W 0 OHM 1/10W...
Page 20: Scaler (19"): S-Video/Cvbs/L/R
Circuit Diagrams and PWB Layouts TPM1.3E LA Scaler (19"): S-Video/CVBS/L/R S-VIDEO/CVBS/L/R SB03 SB03 GND_TUNER U401F U401F Close to MT5382p CN103 CN103 R179 R179 C117 C117 DVDD25_VADC CVBS0 CVBS0 DVDD25_VADC SC1_IN SY1_IN 100 OHM 1/10W 100 OHM 1/10W 0.047uF 0.047uF CVBS1...
Page 21: Scaler (19"): Scart Connector
Circuit Diagrams and PWB Layouts TPM1.3E LA Scaler (19"): SCART connector SCART CONNECTOR SB04 SB04 C113 C113 C115 C115 C112 C112 C110 C110 SCT1_AV_IN R142 R142 27 OHM 1/10W 27 OHM 1/10W R143 R143 C138 0.047uF C138 0.047uF C146 C2 R240 A2...
Page 22: Scaler (19"): Lvds Out
Circuit Diagrams and PWB Layouts TPM1.3E LA Scaler (19"): LVDS OUT LVDS OUT SB05 SB05 U401C U401C AV33 FB301 FB301 AVDD33_LVDS AVDD33_LVDS AVDD33_LVDSA AVDD33_LVDS BEAD BEAD AVDD33_LVDSB AVDD33_LVDS AVDD33_LVDSC AVDD33_VPLL C303 C303 C302 C302 C304 C304 CK1N AVDD33_VPLL 1uF/16V 1uF/16V...
Page 23: Scaler (19"): Mt5335 Hdmi/Pll
Circuit Diagrams and PWB Layouts TPM1.3E LA Scaler (19"): MT5335 HDMI/PLL MT5335 HDMI/PLL SB06 AV12 FB411 FB411 AVDD12_PLL BEAD BEAD U401D U401D USB_VRT AVDD12_PLL C502 C502 C503 C503 C504 C504 C505 C505 USB_VRT AVDD12_ADCPLL 1uF/16V 1uF/16V 4.7uF/10V 4.7uF/10V 0.1UF16V 0.1UF16V...
Page 24: Scaler (19"): Mt5335 Control/Ir/Led
Circuit Diagrams and PWB Layouts TPM1.3E LA Scaler (19"): MT5335 Control/IR/LED MT5335 CONTROL/IR/LED/KEY SB07 +3V3SB R446 R446 R447 R447 C488 C488 1K OHM 1/10W 1K OHM 1/10W Y401 Y401 220uF/10V 220uF/10V ORESET# OXTALI OXTALO R449 R449 Q404 Q404 60MHz 60MHz...
Page 25: Scaler (19"): Mt5335 Audio In/Out
Circuit Diagrams and PWB Layouts TPM1.3E LA Scaler (19"): MT5335 Audio In/Out MT5335 AUDIO IN/OUT SB08 SB08 U401G U401G AIN0_L AIN0_L ASPDIF ASPDIF AOMCLK TP402 TP402 ADAC_VCM AIN0_R AIN0_R AOMCLK AOLRCK AIN1_L AOLRCK AIN1_L AOLRCK AOBCK AIN1_R AIN1_R AOBCK AOBCK...
Page 26: Scaler (19"): Ddr1 Memory
Circuit Diagrams and PWB Layouts TPM1.3E LA Scaler (19"): DDR1 MEMORY DDR1 MEMORY SB09 SB09 U401A U401A 12/6 Modify U402A U402A U402B U402B +1V3D RDQS0 DDR SDRAM DDR SDRAM RDQS0 DDR SDRAM DDR SDRAM RDQM0 MEM_WE# RN402 RN402 8P4R 75 OHM +-5% 1/16W...
Page 27: Scaler (19"): Flash/Jtag/Uart/Ir
Circuit Diagrams and PWB Layouts TPM1.3E LA Scaler (19"): FLASH/JTAG/UART/IR FLASH/JTAG/UART/IR/TRAP SB10 SB10 U401J U401J POCE0# U0RX U0RX POCE0_ U0RX POOE# U0TX U404 U404 U0TX POOE_ U0TX PDD0 SPI FLASH SPI FLASH PDD0 PDD1 OIRI_MT5335 PDD1 OIRI 32M bit 32M bit...
Page 28: Scaler (19"): Cec Up
Circuit Diagrams and PWB Layouts TPM1.3E LA Scaler (19"): CEC uP CEC uP SB11 SB11 +3V3SB_uP D402 D402 RB520S-30 RB520S-30 R472 R472 DV33 27K OHM 1/10W 27K OHM 1/10W Q401 Q401 R409 R409 CEC_IRQ 2N7002 SOT-23 2N7002 SOT-23 OSCL0 9,19...
Page 29: Scaler (19"): Hdmi Input Interface
Circuit Diagrams and PWB Layouts TPM1.3E LA Scaler (19"): HDMI Input Interface HDMI INPUT INTERFACE SB12 SB12 DSDA_0 DSCL_0 HPD0_OUT CEC_A DSDA_1 DSCL_1 HPD1_OUT CEC_B D502 D502 D503 D503 D504 D504 D505 D505 D506 D506 D507 D507 D508 D508 +5V_HDMI0...
Page 30: Scaler (19"): Tmds251 Hdmi 2:1 Switch(Sa13)
Circuit Diagrams and PWB Layouts TPM1.3E LA Scaler (19"): TMDS251 HDMI 2:1 Switch TMDS251 HDMI 2:1 SWITCH SB13 SB13 CEC_B DV33 HDMI_3V3 L501 L501 120 OHM 120 OHM C522 C522 10UF16V 10UF16V C523 C523 C524 C524 C525 C525 C526 C526...
Page 31: Scaler (19"): Line Out/Hp
Circuit Diagrams and PWB Layouts TPM1.3E LA Scaler (19"): LINE OUT/HP LINE OUT/HP R629 R629 SB14 10K OHM 1/10W 10K OHM 1/10W CEC_B DV33 CN601 CN601 R630 R630 HPDET# R601 R601 HPDET# 47K OHM 1/10W 47K OHM 1/10W 0 OHM 1/10W...
Page 32: Scaler (19"): Audio Amp Class D
Circuit Diagrams and PWB Layouts TPM1.3E LA Scaler (19"): AUDIO AMP CLASS D AUDIO AMP CLASS D SB15 SB15 For 22" R608,R611 6.8K For 19" R608,R611 5.1K U601 U601 TDA8932BTW TDA8932BTW R603 R603 4.7K OHM 1/10W 4.7K OHM 1/10W C601 1uF/25V...
Page 33: Scaler (19"): Eu Tuner Interface
Circuit Diagrams and PWB Layouts TPM1.3E LA Scaler (19"): EU Tuner Interface TUNER INTERFACE SB16 SB16 TU701 TU701 TUNER_CVBS +5V_TUNER VIDEO OUT AFT OUT DIF2 DIF2 R761 R761 100 OHM 1/10W 100 OHM 1/10W IFT OUT 2 FAT_IN- DIF1 R758...
Page 34: Scaler (19"): Mt5133 Asic
Circuit Diagrams and PWB Layouts TPM1.3E LA Scaler (19"): MT5133 ASIC MT5133 ASIC SB17 C761 C761 22pF 22pF C701 C701 FAT_IN- 1000pF 1000pF L703 L703 C737 C737 NC/0.22uH NC/0.22uH C736 C736 DV12_DM DVDD12 FAT_IN+ 1000pF 1000pF FB706 FB706 Digital 1.8V Bypass Caps...
Page 35: Scaler (19"): Mt8295/Ci Card
Circuit Diagrams and PWB Layouts TPM1.3E LA Scaler (19"): MT8295/CI CARD MT8295/CI CARD SB18 SB18 TH701 TH701 0 OHM +-5% 1/4W 0 OHM +-5% 1/4W CI_VCC CLOSE TO CI CONNECTOR CLOSE TO CI CONNECTOR CI_VPP U705 U705 L702 L702 NC/BEAD...
Page 36: Scaler (19"): Power
Circuit Diagrams and PWB Layouts TPM1.3E LA Scaler (19"): POWER POWER SB19 SB19 FB903 FB903 NC/220 OHM NC/220 OHM AME8810AEGTZ 600mA/3.3V 19",22",26" LCD Power 2.5mm +5VSB +3V3SB_uP Q908 Q908 +3V3SB U902 U902 ME2301 ME2301 VOUT(heat sink) CN902 CN902 CN901 CN901...
Page 37: Scaler (22"): Vga In/L/R
Circuit Diagrams and PWB Layouts TPM1.3E LA Scaler (22"): VGA IN/L/R VGA IN/L/R SB01 SB01 CN108 CN108 VGA_PLUGPWR C135 A4 R188 D2 R196 C2 ZD128 A2 ZD124 C3 C102 D3 ZD129 A2 ZD121 D3 R244 R244 NEARLY VGA CON. NEARLY IC...
Page 38: Scaler (22"): Ypbpr/L/R & Spdif
Circuit Diagrams and PWB Layouts TPM1.3E LA Scaler (22"): YPbPr/L/R & SPDIF YPbPr/L/R & SPDIF SB02 SB02 NEARLY YPBPR CONNECTOR U401E U401E R105 R105 C104 4700pF C104 4700pF SOY0 DVDD12_VGA SOY1 SOY0 L108 L108 SOY0 DVDD12_VGA 0 OHM 1/10W 0 OHM 1/10W...
Page 39: Scaler (22"): S-Video/Cvbs/L/R
Circuit Diagrams and PWB Layouts TPM1.3E LA Scaler (22"): S-Video/CVBS/L/R S-VIDEO/CVBS/L/R SB03 SB03 GND_TUNER U401F U401F Close to MT5382p CN103 CN103 R179 R179 C117 C117 DVDD25_VADC CVBS0 CVBS0 DVDD25_VADC SC1_IN SY1_IN 100 OHM 1/10W 100 OHM 1/10W 0.047uF 0.047uF CVBS1...
Page 40: Scaler (22"): Scart Connector
Circuit Diagrams and PWB Layouts TPM1.3E LA Scaler (22"): SCART connector SCART CONNECTOR SB04 SB04 R149 C2 C142 C3 R153 C2 C204 A2 C115 C115 C112 C112 C110 C110 SCT1_AV_IN R142 R142 27 OHM 1/10W 27 OHM 1/10W R143 R143 C138 0.047uF...
Page 41: Scaler (22"): Lvds Out
Circuit Diagrams and PWB Layouts TPM1.3E LA Scaler (22"): LVDS OUT LVDS OUT SB05 SB05 AV33 U401C U401C FB301 FB301 AVDD33_LVDS AVDD33_LVDS BEAD BEAD AVDD33_LVDSA AVDD33_LVDS AVDD33_LVDSB AVDD33_LVDS CN301 B2 AVDD33_LVDSC C303 C303 C302 C302 C304 C304 L303 B5 0.1UF16V 0.1UF16V...
Page 42: Scaler (22"): Mt5335 Hdmi/Pll
Circuit Diagrams and PWB Layouts TPM1.3E LA Scaler (22"): MT5335 HDMI/PLL MT5335 HDMI/PLL SB06 SB06 AV12 FB411 FB411 AVDD12_PLL U401D U401D BEAD BEAD USB_VRT AVDD12_PLL USB_VRT AVDD12_ADCPLL USB_D- AVDD12_PLL USB_D- USB_DM AVDD12_TVDPLL USB_D+ AVDD12_PLL C502 C502 C503 C503 C504 C504...
Page 43: Scaler (22"): Mt5335 Control/Ir/Led
Circuit Diagrams and PWB Layouts TPM1.3E LA Scaler (22"): MT5335 Control/IR/LED MT5335 CONTROL/IR/LED/KEY SB07 SB07 +3V3SB R446 R446 R447 R447 C488 C488 1K OHM 1/10W 1K OHM 1/10W Y401 Y401 220uF/10V 220uF/10V ORESET# OXTALI OXTALO R449 R449 Q404 Q404 60MHz...
Page 44: Scaler (22"): Mt5335 Audio In/Out
Circuit Diagrams and PWB Layouts TPM1.3E LA Scaler (22"): MT5335 Audio In/Out MT5335 AUDIO IN/OUT SB08 SB08 U401G U401G AIN0_L ASPDIF AIN0_L ASPDIF AOMCLK TP402 TP402 AIN0_R AIN0_R AOMCLK AOLRCK AIN1_L AIN1_L AOLRCK AOLRCK AOBCK AIN1_R AOBCK AIN1_R AOBCK MT5133_RESET...
Page 45: Scaler (22"): Ddr1 Memory
Circuit Diagrams and PWB Layouts TPM1.3E LA Scaler (22"): DDR1 MEMORY DDR1 MEMORY SB09 SB09 U401A U401A 12/6 Modify U402A U402A U402B U402B +1V3D RDQS0 DDR SDRAM DDR SDRAM RDQS0 DDR SDRAM DDR SDRAM RDQM0 MEM_WE# RN402 RN402 8P4R 75 OHM +-5% 1/16W...
Page 46: Scaler (22"): Flash/Jtag/Uart/Ir
Circuit Diagrams and PWB Layouts TPM1.3E LA Scaler (22"): FLASH/JTAG/UART/IR FLASH/JTAG/UART/IR/TRAP SB10 SB10 U401J U401J POCE0# U0RX POCE0_ U0RX U0RX POOE# U0TX U404 U404 POOE_ U0TX U0TX PDD0 PDD0 SPI FLASH SPI FLASH PDD1 OIRI_MT5335 PDD1 OIRI 32M bit 32M bit...
Page 47: Scaler (22"): Cec Up
Circuit Diagrams and PWB Layouts TPM1.3E LA Scaler (22"): CEC uP CEC uP SB11 SB11 +3V3SB_uP D402 D402 RB520S-30 RB520S-30 R472 R472 DV33 27K OHM 1/10W 27K OHM 1/10W Q401 Q401 R409 R409 CEC_IRQ 2N7002 SOT-23 2N7002 SOT-23 9,14 OSCL0...
Page 48: Scaler (22"): Hdmi Input Interface
Circuit Diagrams and PWB Layouts TPM1.3E LA Scaler (22"): HDMI Input Interface HDMI INPUT INTERFACE SB12 SB12 DSDA_0 DSCL_0 HPD0_OUT CEC_A DSDA_1 DSCL_1 HPD1_OUT CEC_B CEC_B D502 D502 D503 D503 D504 D504 D505 D505 D506 D506 D507 D507 D508 D508...
Page 49: Scaler (22"): Tmds251 Hdmi 2:1 Switch(Sa13)
Circuit Diagrams and PWB Layouts TPM1.3E LA Scaler (22"): TMDS251 HDMI 2:1 Switch TMDS251 HDMI 2:1 SWITCH SB13 SB13 CEC_B DV33 HDMI_3V3 L501 L501 120 OHM 120 OHM U502 B4 C530 D3 C524 D4 C522 C522 C526 D4 10UF16V 10UF16V...
Page 50: Scaler (22"): Line Out/Hp
Circuit Diagrams and PWB Layouts TPM1.3E LA Scaler (22"): LINE OUT/HP LINE OUT/HP R629 R629 SB14 10K OHM 1/10W 10K OHM 1/10W DV33 CN601 CN601 R630 R630 HPDET# R601 R601 HPDET# 47K OHM 1/10W 47K OHM 1/10W 0 OHM 1/10W...
Page 51: Scaler (22"): Audio Amp Class D
Circuit Diagrams and PWB Layouts TPM1.3E LA Scaler (22"): AUDIO AMP CLASS D AUDIO AMP CLASS D SB15 SB15 U601 U601 TDA8932BTW TDA8932BTW R603 R603 4.7K OHM 1/10W 4.7K OHM 1/10W C601 1uF/25V C601 1uF/25V SPK_L VSSD/HW VSSD/HW R608 R608 6.8K OHM 1/10W...
Page 52: Scaler (22"): Eu Tuner Interface
Circuit Diagrams and PWB Layouts TPM1.3E LA Scaler (22"): EU Tuner Interface TUNER INTERFACE SB16 SB16 TU701 TU701 TUNER_CVBS +5V_TUNER VIDEO OUT AFT OUT DIF2 DIF2 R761 R761 100 OHM 1/10W 100 OHM 1/10W FAT_IN- IFT OUT 2 DIF1 R758...
Page 53: Scaler (22"): Mt5133 Asic
Circuit Diagrams and PWB Layouts TPM1.3E LA Scaler (22"): MT5133 ASIC MT5133 ASIC SB17 SB17 C761 C761 22pF 22pF C701 C701 FAT_IN- 1000pF 1000pF L703 L703 C737 C737 NC/0.22uH NC/0.22uH C736 C736 DV12_DM DVDD12 FAT_IN+ 1000pF 1000pF FB706 FB706 Digital 1.8V Bypass Caps...
Page 54: Scaler (22"): Mt8295/Ci Card
Circuit Diagrams and PWB Layouts TPM1.3E LA Scaler (22"): MT8295/CI CARD MT8295/CI CARD SB18 SB18 TH701 TH701 0 OHM +-5% 1/4W 0 OHM +-5% 1/4W CI_VCC CLOSE TO CI CONNECTOR CLOSE TO CI CONNECTOR CI_VPP U705 U705 L702 L702 NC/BEAD...
Page 55: Scaler (22"): Power
Circuit Diagrams and PWB Layouts TPM1.3E LA Scaler (22"): POWER POWER SB19 SB19 FB903 FB903 NC/220 OHM NC/220 OHM AME8810AEGTZ 600mA/3.3V +5VSB +3V3SB_uP Q908 Q908 +3V3SB U902 U902 19",22",26" LCD Power 2.5mm ME2301 ME2301 VOUT(heat sink) CN902 CN902 CN901 CN901...
Page 56 Circuit Diagrams and PWB Layouts TPM1.3E LA Layout Scaler Board (Top Side) C101 C2 C119 D2 C149 B2 C168 C2 C193 C2 C309 A1 C437 B1 C463 B1 C497 D1 C612 A3 C636 B3 C657 A2 C676 A3 C718 B4...
Page 57 Circuit Diagrams and PWB Layouts TPM1.3E LA Layout Scaler Board (Bottom Side) C110 D3 C179 B2 C408 B2 C419 B2 C432 B2 C478 B2 C498 C2 C511 B2 C523 D1 C622 B3 C680 A3 C730 B4 C754 C4 C789 D4...
Page 58 Circuit Diagrams and PWB Layouts TPM1.3E LA Keyboard & Control Panel KEYBOARD CONTROL PANEL KB01 KB01 +3V3SB R103 R104 R105 R102 2.0K OHM +-1% 1/4W R101 2.0K OHM +-1% 1/4W +3V3SB 0 OHM 1/4W 2.0K OHM +-1% 1/4W 1.0K OHM +-1% 1/4W...
Page 59 Circuit Diagrams and PWB Layouts TPM1.3E LA Layout Keyboard & Control Panel (Top Side) Personal Notes: I_17780_034.eps 170408 E_06532_012.eps 131004...
Page 60: Ir & Led Panel
Circuit Diagrams and PWB Layouts TPM1.3E LA IR & LED Panel IR LED BOARD IB01 IB01 +3.3V_SUB +3.3V_SUB LED1 LED3 LED1 B4 LED3 B4 CONN 4.7K OHM 1/10W 4.7K OHM 1/10W 2.7K OHM 1/10W STANDBY 2.7K OHM 1/10W TURN_ON +3.3V_SUB...
Page 61 Circuit Diagrams and PWB Layouts TPM1.3E LA Layout IR & LED Panel (Top Side) Personal Notes: I_17780_036.eps 170408 E_06532_012.eps 131004...
Page 62: 19Pfl3403D/10 Power Board: Adapter (Pb01)
Circuit Diagrams and PWB Layouts TPM1.3E LA 19PFL3403D/10 Power Board: Adapter POWER BOARD 19”: ADAPTER PB01 PB01 R918 R918 э ? F902 F902 100 OHM 1/4W 100 OHM 1/4W C921 C921 JUMP RLZ18B R919 R919 +16V 100 OHM 1/4W 100 OHM 1/4W...
Page 63: 19Pfl3403D/10 Power Board: Inverter (Pb02)
Circuit Diagrams and PWB Layouts TPM1.3E LA 19PFL3403D/10 Power Board: Inverter POWER BOARD 19”: INVERTER PT802 PT802 CN801 CN801 PB02 PB02 C819 C819 POWER X'FMR POWER X'FMR CONN CONN 68pF3KV 68pF3KV +16V R805 R805 C820 C820 100R 1/10W 5% 100R 1/10W 5%...
Page 64: 22Pfl3403D/10 Power Board: Adapter (Pb01)
Circuit Diagrams and PWB Layouts TPM1.3E LA 22PFL3403D/10 Power Board: Adapter POWER BOARD 22”: ADAPTER PB01 PB01 R918 R918 100R 1/4W 100R 1/4W C921 C921 F902 F902 0.001uF 0.001uF R919 R919 +16V T901 T901 100R 1/4W 100R 1/4W L904 L904...
Page 65: 22Pfl3403D/10 Power Board: Inverter (Pb02)
Circuit Diagrams and PWB Layouts TPM1.3E LA 22PFL3403D/10 Power Board: Inverter POWER BOARD 22”: INVERTER PT802 PT802 CN801 CN801 PB02 PB02 CONN CONN C819 C819 68pF/3KV 68pF/3KV C817 C2 C823 A2 R805 R805 +16V R839 B2 PT802 D3 100R 1/10W...
Page 66 Circuit Diagrams and PWB Layouts TPM1.3E LA Layout Power Board (Top Side) Layout Power Board (Bottom Side) C801 B2 C807 A2 C814 B2 C919 C3 C927 A4 D804 C2 D909 C4 Q804 D2 R804 C2 R814 B2 R820 A2 R826 B1...
Page 67: Alignments
Alignments TPM1.3E LA EN 67 8. Alignments Index of this chapter: Table 8-1 (x,y) coordinates 8.1 Electrical Instructions 8.2 Serial Number Definition Normal (7200K) Warm (6300K) Cool (9300K) x (center) 0.304 +/- 0.015 0.315 +/- 0.005 0.283 +/- 0.015 Note: The Service Modes are describe in chapter 5. Menu y (center) 0.312 +/- 0.015...
Page 68 EN 68 TPM1.3E LA Alignments I_17550_014.eps 130208 Figure 8-3 "AUTO_COLOR" with five white block pattern. Serial Number Definition BOM Code: Table 8-2 Panel type PANEL SUPPLIER Code LPL (LG Philips)
Page 69: Circuit Descriptions, Abbreviation List, And Ic Data
Circuit Descriptions, Abbreviation List, and IC Data Sheets TPM1.3E LA EN 69 9. Circuit Descriptions, Abbreviation List, and IC Data Sheets Index of this chapter: HDCP, also YPbPr is supported up to 1080i and HDMI can 9.1 Introduction support up to 1080p (both also support down to and 9.2 Block Diagram...
Page 70: Abbreviation List
Acer Unipack Optronics the customers wishes Asia Pacific LATAM LATin AMerica Aspect Ratio: 4 by 3 or 16 by 9 LC04 Philips chassis name for LCD TV 2004 Automatic Standard Detection project Audio Video Liquid Crystal Display B-TXT Blue teletext...
Page 71 SouND SNDS-VL-OUT Surround sound left variable level out SNDS-VR-OUT Surround sound right variable level out SOPS Self Oscillating Power Supply S/PDIF Sony Philips Digital InterFace SRAM Static RAM STBY Stand-by SVHS Super Video Home System Sub Woofer / SoftWare Total Harmonic Distortion...
Page 72: Ic Data Sheets
EN 72 TPM1.3E LA Circuit Descriptions, Abbreviation List, and IC Data Sheets IC Data Sheets This section shows the internal block diagrams and pin layouts of ICs that are drawn as “black boxes” in the electrical diagrams (with the exception of “memory” and “logic” ICs).
Page 73 Circuit Descriptions, Abbreviation List, and IC Data Sheets TPM1.3E LA EN 73 FUNCTIONAL BLOCK DIAGRAM (32Mx16) 4Banks x 8Mbit x 16 I/O Double Data Rate Synchronous DRAM Write Data Register Mode 2-bit Prefetch Unit Register 8Mx16 BANK 3 8Mx16 BANK 2...
Page 74 EN 74 TPM1.3E LA Circuit Descriptions, Abbreviation List, and IC Data Sheets 9.4.3 Diagram SB11, WT6702F_OG200WT Figure 9-5 Block Diagram...
Page 75 Circuit Descriptions, Abbreviation List, and IC Data Sheets TPM1.3E LA EN 75 9.4.4 Diagram SB13,TMDS251PAGR Figure 9-6 Pin Configuration...
Page 76 EN 76 TPM1.3E LA Circuit Descriptions, Abbreviation List, and IC Data Sheets 9.4.5 Diagram SB15, TDA8932BTW BOOT1 OSCILLATOR DDP1 IN1P DRIVER HIGH OUT1 CTRL MODULATOR DRIVER SSP1 IN1N MANAGER BOOT2 INREF DDP2 IN2P DRIVER HIGH OUT2 CTRL MODULATOR DRIVER SSP2...
Page 77 Circuit Descriptions, Abbreviation List, and IC Data Sheets TPM1.3E LA EN 77 9.4.6 Diagram SB17, MT5133AN I_17570_028.eps 180408 Figure 9-8 Internal Block Diagram...
Page 78 EN 78 TPM1.3E LA Circuit Descriptions, Abbreviation List, and IC Data Sheets 9.4.7 Diagram SB18, MT8295AE Figure 9-9 Internal Block Diagram...
Page 79: Spare Parts List
Spare Parts List TPM1.3E LA EN 79 10. Spare Parts List For the latest spare part overview, please consult the Philips Service website. 11. Revision List Manual xxxx xxx xxxx.0 • First release.

Philips TPM1.3E Service Manual

1 Technical Specifications, Connections, and Chassis Overview

2 Safety Instructions, Warnings, and Notes

3 Directions for Use

4 Mechanical Instructions

5 Service Modes, Error Codes, and Fault Finding

6 Block Diagrams, Test Point Overview, and

7 Circuit Diagrams and PWB Layouts

8 Alignments

9 Circuit Descriptions, Abbreviation List, and IC Data

10 Spare Parts List

Quick Links

Colour Television

Related Manuals for Philips TPM1.3E

Summary of Contents for Philips TPM1.3E

Table of Contents