All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise without the prior permission of Philips. Published by XjL/MjX/MB/SC 1263 BG TV Quality, the Netherlands...
Table 2-1 Described Model Numbers and Diversity Mechanics Block Diagrams Schematics 32PFL3007D/78 10.1 10.2 10.3 11.1 32PFL3017D/78 10.1 10.2 10.3 11.1 42PFL3007D/78 10.1 10.2 10.3 11.2 Directions for Use Directions for use can be downloaded from the following websites: http://www.philips.com/support http://www.p4c.philips.com back to 2012-Mar-30 div. table...
Technical Specs, Diversity, and Connections TPM9.1L LA EN 3 Connections Rear connectors Side connectors CVBS AUDIO IN DVI/VGA USB 1 ANTENNA ANTENNA IN 1 IN 2 (AIR) (CABLE) USB 2 SERV .U HDMI 3 SPDIF HDMI HDMI 19250_104_120329.eps 120329 Figure 2-1 Connection overview Note: The following connector color abbreviations are used 5, 6 - HDMI: Digital Video - In, Digital Audio - In/Out (acc.
Page 4
EN 4 TPM9.1L LA Technical Specs, Diversity, and Connections 9 - PC IN:VGA Wh - Audio - L 0.5 V / 10 k Rd - Audio - R 0.5 V / 10 k 13 - Cinch: Digital Audio - Out 10000_002_090121.eps / 75 ...
Spare Parts the following points: • Route the wire trees correctly and fix them with the For the latest spare part overview, consult your Philips Spare mounted cable clamps. Part web portal. • Check the insulation of the Mains/AC Power lead for external damage.
Page 6
EN 6 TPM9.1L LA Precautions, Notes, and Abbreviation List result in sets which have the same CTN (Commercial Type 6 = play 16 : 9 format, 12 = play 4 : 3 Number; e.g. 28PW9515/12) but which have a different B.O.M. format number.
Page 7
6.5 MHz. L' is Band (VESA standard for communication I, L is all bands except for Band I channel and display). Using E-DDC, LG.Philips LCD (supplier) the video source can read the EDID Loudspeaker information form the display.
Page 8
SOPS Self Oscillating Power Supply Serial Peripheral Interface bus; a 4-wire synchronous serial data link standard S/PDIF Sony Philips Digital InterFace SRAM Static RAM Service Reference Protocol Small Signal Board Spread Spectrum Clocking, used to reduce the effects of EMI...
Mechanical Instructions TPM9.1L LA EN 9 4. Mechanical Instructions Index of this chapter: Notes: 4.1 Cable Dressing • Figures below can deviate slightly from the actual situation, 4.2 Service Positions due to the different set executions. 4.3 Assembly/Panel Removal 4.4 Set Re-assembly Cable Dressing 19250_100_120321.eps 120321...
Page 10
EN 10 TPM9.1L LA Mechanical Instructions 19250_101_120326.eps 120329 Figure 4-2 Cable dressing (42") Service Positions For easy servicing of a TV set, the set should be put face down on a soft flat surface, foam buffers or other specific workshop tools.
Page 11
Mechanical Instructions TPM9.1L LA EN 11 3 × 16 3 × 7.5 M3 × 8 M4 × 10 19250_102_120319.eps 120319 Figure 4-3 Rear cover removal 4.3.2 Stand Refer to Figure 4-3 for details. 1. Remove fixation screws [4] that secure the base assembly, pull the base assembly downwards away from the catches.
Page 12
EN 12 TPM9.1L LA Mechanical Instructions 4.3.6 Keyboard Control unit 1. Gently release the tape that holds the board’s cable. 2. Gently push inwards the three clips at the PSU side of the unit. Release the unit at the PSU side and turn it away from the PSU.
Service Modes, Error Codes, and Fault Finding TPM9.1L LA EN 13 5. Service Modes, Error Codes, and Fault Finding Index of this chapter: Life Timer 5.1 Test Points During the life time cycle of the TV set, a timer is kept (called 5.2 Service Modes “Op.
Page 14
EN 14 TPM9.1L LA Service Modes, Error Codes, and Fault Finding – Automatic user menu time-out (menu switches controls will not have I+ button, but an “INFO” button back/OFF automatically. instead. – Auto Volume levelling (AVL). How to Exit SDM How to Activate SDM •...
Service Modes, Error Codes, and Fault Finding TPM9.1L LA EN 15 Main Menu Sub-menu 1 Sub-menu 2 Description Download from USB Copy Channel List from USB To download several settings from the USB stick to the TV Copy NVM from USB Copy Readable Info from USB Copy EDID from USB Initialize NVM...
EN 16 TPM9.1L LA Service Modes, Error Codes, and Fault Finding Default value Item Item value 32" 42" Description NVM COPY USB to TV Press OK Use this to store the NVM data from the USB memory stick to the TV. The TV will save the two files which were created in item 8 to the NVM of the set.
Service Modes, Error Codes, and Fault Finding TPM9.1L LA EN 17 • 1.3 Installation date Indicates the date of the first • 3.1 Signal Quality Analog/digital signal strength. installation of the TV. This date is acquired via time • 3.2 Child lock Not active / active. This is a combined item extraction.
A description on how to upgrade the main 1. ComPair helps to quickly get an understanding on how to software can be found in the DFU or on the Philips website. repair the chassis in a short and effective way.
Service Modes, Error Codes, and Fault Finding TPM9.1L LA EN 19 • FUS_clustername_version.zip: Contains the “autorun.upg” which is needed to upgrade the TV main software and the software download application. • NVM_clustername_version.zip: Default NVM content. Must be programmed via ComPair. 5.5.7 How to Copy NVM Data to/from USB When copying data to and from a USB memory stick, the folder...
EN 20 TPM9.1L LA Service Modes, Error Codes, and Fault Finding – ERROR: 034 013 000 000 000: Error code 13 was • It is assumed that the components are mounted correctly detected first and error code 34 is the last detected with correct values and no bad solder joints.
Page 21
Service Modes, Error Codes, and Fault Finding TPM9.1L LA EN 21 5.8.10 Display option code Attention: In case the SSB is replaced, always check the Panel Code in CSM, even when picture is available. Performance with the incorrect display option code can lead to unwanted side-effects for certain conditions.
EN 22 TPM9.1L LA Alignments 6. Alignments Index of this chapter: In case you have a color analyzer: 6.1 General Alignment Conditions • Measure with a calibrated (phosphor- independent) color 6.2 Hardware Alignments analyzer (e.g. Minolta CA-210) in the centre of the screen. 6.3 Software Alignments Consequently, the measurement needs to be done in a 6.4 Option Settings...
Alignments TPM9.1L LA EN 23 Option Settings 6.5.1 SSB Identification 6.4.1 Introduction SSB’s of this chassis are identified by a “715” code on the SSB. 715Axxxx-Nnn-MMM-OOOO • 715 main category, Printed Wiring Board The microprocessor communicates with a large number of I •...
EN 24 TPM9.1L LA Circuit Descriptions 7. Circuit Descriptions Index of this chapter: Introduction 7.1 Introduction The TPM9.1L LA platform is covering the 3000 series styling. It 7.2 Power Supply uses the MT5366 main microprocessor. The major difference 7.3 DC/DC Converters compared to its predecessors is ISDB support.
Page 25
Circuit Descriptions TPM9.1L LA EN 25 7.1.3 SSB Cell Layout DC/DC AV OUT AV IN MT5366 AUDIO AMP TUNER ANALOG I/O HDMI SWITCH SERVICE CONNECTOR HDMI 19260_200_120321.eps 120323 Figure 7-1 SSB layout cells (top view) back to 2012-Mar-30 div. table...
This part is available in the regular market. PSL stands for Power Supply with integrated LED-drivers. Consult the Philips Service web portal for the order codes of the PSLS stands for a Power Supply with integrated LED-drivers boards.
Page 27
Circuit Descriptions TPM9.1L LA EN 27 Front-End Analogue and Connector ISDB-T reception 3xPFL35x7 42PFL35x7 CN801 CN802 CN8503 CN9901 7.4.1 Front-End Analogue Descr. to panel to panel to panel Mains inlet The Front-End for the analogue tuner consist of the following key components: •...
EN 28 TPM9.1L LA Circuit Descriptions Integrated Backlight Tcon CCFL MT5366CVNG 50/60 Hz SIL9185A ASIC R3X R2X Backlight-PWM CN503 MT5366 Lamp-ON 19260_206_120327.eps 120328 19260_207_120327.eps Figure 7-6 HDMI input configuration 120330 The Sil9185ACTU has the following specifications: Figure 7-7 LED back lit power scheme. •...
IC Data Sheets TPM9.1L LA EN 29 8. IC Data Sheets This chapter shows the internal block diagrams and pin configurations of ICs that are drawn as “black boxes” in the electrical diagrams (with the exception of “memory” and “logic” ICs).
Page 30
EN 30 TPM9.1L LA IC Data Sheets Diagram 10-1-9 Audio Amplifier/Headphone/Subwoofer B09, STA381BWTR (IC U603) Block diagram STA381BW OUT 1A OUT 1B 2.1 Channel Half MCLK OUT 2A Audio Processor Bridges OUT 2B Modulator STAudioFx FFX3A LRCKI STSpeakerSafe FFX3B Parametric EQ BICKI Binary Volume...
Page 31
IC Data Sheets TPM9.1L LA EN 31 Diagram 10-1-11 GPIO Interface & to IR/Keyboard control B13, MT5366SVOG/B PBGA-479 (IC U401) Block diagram VADC × 4 MT5366CV 19080_300_110316.eps 120102 Figure 8-3 Internal block diagram back to 2012-Mar-30 div. table...
Page 32
EN 32 TPM9.1L LA IC Data Sheets Pinning information MT5366CV [1/2] 19080_301_110316.eps 120102 Figure 8-4 Pin configuration [1/2] back to 2012-Mar-30 div. table...
Page 33
IC Data Sheets TPM9.1L LA EN 33 Pinning information MT5366CV [2/2] 19080_302_110316.eps 120102 Figure 8-5 Pin configuration [2/2] back to 2012-Mar-30 div. table...
Page 34
EN 34 TPM9.1L LA IC Data Sheets Diagram 10-1-15 ISDB-T Demodulator B15, CXD2828ER (IC U103) Block diagram TSCLK TSSYNC ISDB-T TSVALID TSDATA[7:0] TAINP TAINM Viterbi TSIF decoder decoder OFDM Demodulator TIFAGC Status Terrestrial TMCC Monitor Tuner Tuner I Host I CXD2828ER TTUSDA TTUSCL...
Block Diagrams TPM9.2L LA EN 35 9. Block Diagrams Wiring diagram 32" (3000 styling) WIRING DIAGRAM 32" (3000 styling) Board Level Repair See note in Chapter 7 about cable position numbers. Component Level Repair Only for authorized workshops to panel CN9902 CN409 CN701...
Block Diagrams TPM9.2L LA EN 36 Wiring diagram 42" (3000 styling) WIRING DIAGRAM 42" (3000 styling) Board Level Repair See note in Chapter 7 about cable position numbers. Component Level Repair Only for authorized workshops MAIN POWER SUPPLY (1054) CN701 CN408 CVBS USB 1...
Circuit Diagrams and PWB Layouts TPM9.2L LA EN 38 10. Circuit Diagrams and PWB Layouts 10.1 B 715G5172 SSB 3000/3500/4000 series 10-1-1 System Power 1 System Power INVERTER_ON_OFF MAIN POWER +5V Switch BRIGHT ADJUST BRIGHT_ADJ +5V_SW DVDD3V3 +5V_SW DVDD3V3 CN701 +5VSB Bright_Adj R702...
Page 41
Circuit Diagrams and PWB Layouts TPM9.2L LA EN 41 10-1-4 Side AV/USB/PC Audio-in Side AV/USB/PC Audio-in DVDD3V3 DVDD3V3 +5V_SW +5V_SW Side AV(CVBS)Video & Audio input VGA Audio Input TP087 TP091 TP092 TP099 TP100 TP103 Side AV Video & Audio R202 CN128 CN102 SIDE_CVBS_IN...
Circuit Diagrams and PWB Layouts TPM9.2L LA EN 59 10-3-2 Keyboard control panel layout Layout Keyboard control panel (Top Side) Layout Keyboard control panel (Bottom Side) 2011-10-21 Keyboard control panel 715G5365 layout top/bottom 19250_501_120321.eps 120330 back to 2012-Mar-30 div. table...
Page 60
Styling Sheets TPM9.2L LA EN 60 11. Styling Sheets 11.1 3000 series 32" 3000 series 32" 1053 1050 0031 1054 1057 0041 1056 0032 Pos No. Description Remarks 0031 Front bezel 0032 Deco bezel 0041 Rear cover 0030 Stand 1050 Display panel 1053 Panel SSB...
Page 61
Styling Sheets TPM9.2L LA EN 61 11.2 3000 series 42" 3000 series 42" 1053 0041 1054 1057 Pos No. Description Remarks 1056 0031 Front bezel 0032 Deco bezel 0041 Rear cover 1050 0050 Stand 0050 1050 Display panel 1053 SSB panel 0032 1054 Power Supply Unit...