Table Of Contents - Mitsubishi Electric DXK09ZJ-S Technical Manual

Table of Contents

Table Of Contents4
Specifications6
Exterior Dimensions8
Wireless Remote Controller12
Wired Remote Controller (Option Parts)13
Wiring Specifications13
Electrical Wiring14
Outdoor Units14
Noise Level17
Piping System20
Range Of Usage And Limitations21
Capacity Tables23
Application Data24
Installation Manual For Indoor Unit24
Before Installation25
Selection Of Installation Location25
Standard Accessories (Installation Kit)25
Installing The Support Of Piping25
Installation Of Indoor Unit25
Connection Of Refrigerant Pipings26
Fixing Of Indoor Unit26
Open/Close And Detachment/Attachment Of The Air Inlet Panel26
How To Remove And Fit The Front Panel26
Electrical Wiring Work27
How To Relocate Or Dispose Of The Unit27
Installation Test Check Points27
Concerning Terminal Connection For An Interface27
Installation Manual For Outdoor Unit28
Haulage And Installation30
Refrigerant Piping Work31
Restrictions On Unit Installation And Use31
Determination Of Pipe Size31
On-Site Piping Work31
Air Tightness Test32
Evacuation32
Heating And Condensation Prevention32
Drain Piping Work33
Safety Precautions35
Additional Refrigerant Charge39
Power Cable, Indoor - Outdoor Connecting Wire Circuit Diagram41
Power Cable, Indoor-Outdoor Connecting Wires41
Outline Of Operation Control By Microcomputer42
Operation Control Function By Remote Controller42
Unit Display Section42
Unit On/Off Button43
Auto Restart Function43
Custom Cord Switching Procedure43
Flap And Louver Control44
3D Auto Operation45
Timer Operation46
Comfortable Timer Setting (On Timer)46
Installation Location Setting46
Sleep Timer Operation46
Outline Of Heating Operation47
Operation Of Major Functional Components In Heating Mode47
Details Of Control At Each Operation Mode (Pattern)47
Defrosting Operation47
Outline Of Cooling Operation48
Outline Of Automatic Operation48
Determination Of Operation Mode48
Protective Control Function49
Frost Prevention Control49
Cooling Overload Protective Control49
Cooling Low Outdoor Air Temperature Protective Control50
Heating High Pressure Control50
Operating Conditions50
Heating Overload Protective Control51
Heating Low Outdoor Temperature Protective Control52
Compressor Overheat Protection53
Current Safe53
Current Cut53
Outdoor Unit Failure53
Indoor Fan Motor Protection54
Serial Signal Transmission Error Protection54
Outdoor Fan Control At Low Outdoor Temperature54
Refrigeration Cycle System Protection55
Heating55
Maintenance Data56
Troubleshooting Procedures For Electrical Equipment56
If The Air Conditioner Does Not Run At All56
Troubleshooting Procedure (If The Air Conditioner Runs)57
Self-Diagnosis Table58
Service Mode (Trouble Mode Access Function)59
Service Mode Display Procedure59
Self-Diagnosis Data60
Stop Data61
Error Code, Stop Code Table62
Remote Controller Information Tables63
Room Temperature Sensor, Indoor Heat Exchanger Sensor64
Discharge Pipe Sensor Table65
Service Data Record Form66
Inspection Procedures Corresponding To Detail Of Trouble67
Sensor Error67
Indoor Fan Motor Error67
Current Safe Stop68
Over Heat Of Compressor69
Error Of Signal Transmission69
Trouble Of Outdoor Unit70
Outdoor Fan Motor Error70
Rotor Lock71
Phenomenon Observed After Shortcircuit, Wire Breakage On Sensor71
Humidity Sensor Operation71
Checking The Indoor Electrical Equipment71
Indoor Pcb Check Procedure72
Indoor Unit Fan Motor Check Procedure72
Power Transistor Inspection Procedure73
How To Make Sure Of Wireless Remote Controller73
Outdoor Unit Inspection Points74
Check Point Of Outdoor Unit75
Inspection Of Electronic Expansion Valve76
Outdoor Unit Fan Motor Check Procedure76
Option Parts77
Installation Of Wired Remote Controller (Rc-E4)77
Master/ Slave Setting When More Than One Remote Controllers Are Used78
The Indication When Power Source Is Supplied78
The Range Of Temperature Setting79
How To Set Upper And Lower Limit Value79
The Functional Setting80
How To Set Function82
Interface Kit (Sc-Bikn-E)83
Connecting The Indoor Unit's Connection Cable To The Interface83
Installation Of The Interface84
Mounting The Interface Directly On A Wall84
Recessing The Interface In The Wall84
Mounting The Interface With The Mounting Bracket84
Functions Of Cnt Connector85
Connection Of Super Link E Board85
Connection Of Wired Remote Controller86
Installation And Wiring Of Wired Remote Controller86
Control Of Multiple Units By A Single Wired Remote Controller86
How To Set Upper And Lower Limit Of Temperature Sting Range86
Super Link E Board (Sc-Adna-E)87
Super Link E Board Installation88
Super Link E Board Indicator Display88
Parts List90
Panel And Fan Assy Exploded View91
Panel And Fan Assy Parts List92
Heat Exchange And Control Exploded View93
Heat Exchange And Control Parts List94