Download  Print this page

Advertisement

HCD-HDX500/HDX501W
QQ
3 7 63 1515 0

SERVICE MANUAL

Ver. 1.1 2007.03
• HCD-HDX500 is the amplifier, DVD system,
tuner and video section in DAV-HDX500.
• HCD-HDX501W is the amplifier, DVD system,
tuner and video section in DAV-HDX501W.
This product incorporates copyright protection
technology that is protected by U.S. patents and
other intellectual property rights. Use of this
copyright protection technology must be
authorized by Macrovision, and is intended for
home and other limited viewing uses only unless
otherwise authorized by Macrovision. Reverse
TE
engineering or disassembly is prohibited.
L 13942296513
This system incorporates with Dolby* Digital
and Dolby Pro Logic (II) adaptive matrix
surround decoder and the DTS** Digital
Surround System.
* Manufactured under license from Dolby
Laboratories.
"Dolby", "Pro Logic", and the double-D symbol are
trademarks of Dolby Laboratories.
** Manufactured under license from DTS, Inc.
"DTS" and "DTS Digital Surround" are registered
trademarks of DTS, Inc.
www
.
Sony Corporation
9-887-552-02
Home Audio Division
2007C05-1
Published by Sony Techno Create Corporation
© 2007.03
http://www.xiaoyu163.com
AUDIO POWER SPECIFICATIONS
for the US model
POWER OUTPUT AND TOTAL HARMONIC
DISTORTION:
Amplifier section
Surround mode (reference) RMS output power
* Depending on the sound field settings and the source,
there may be no sound output.
Inputs (Analog)
TV (AUDIO IN)
SAT/CABLE (AUDIO IN) Sensitivity: 450/250 mV
AUDIO IN
Inputs (Digital)
SAT/CABLE (COAXIAL IN/OPTICAL IN)
Outputs (Analog)
Phones
x
ao
u163
y
i
http://www.xiaoyu163.com
2 9
8
Photo: HCD-HDX500
Model Name Using Similar Mechanism
DVD Mechanism Type
Optical Pick-up Block Name
SPECIFICATIONS
Q Q
3
6 7
1 3
1 5
With 3 ohms loads, both
channels driven, from 120
- 20,000 Hz; rated 84 watts
per channel minimum
RMS power, with no more
than 0.7 % total harmonic
distortion from 250 milli
watts to rated output.
FL/FR/C/SL/SR*: 143 watts
(per channel at 3 ohms, 1
kHz, 10 % THD)
Subwoofer*: 285 watts (at
1.5 ohms, 80 Hz, 10 %
THD)
Sensitivity: 450/250 mV
Sensitivity: 250/125 mV
Impedance: 75 ohms/–
Accepts low-and high-
impedance headphones.
co
.
9 4
2 8
US Model
HCD-HDX500/HDX501W
Canadian Model
HCD-HDX500
HCD-DX155
CDM81C-DVBU101
KHM-310CAB or
KHM-313CAB
0 5
8
2 9
9 4
2 8
DVD system
Semiconductor laser
Laser
(DVD: λ = 650 nm)
(CD: λ = 790 nm)
Emission duration:
continuous
Signal format system
NTSC
Tuner section
System
PLL quartz-locked digital
synthesizer
FM tuner section
Tuning range
North American models:
87.5-108.0 MHz (100 kHz
step)
Antenna (aerial)
FM wire antenna (aerial)
Antenna (aerial) terminals 75 ohms, unbalanced
Intermediate frequency
10.7 MHz
AM tuner section
Tuning range
North American models:
530 – 1,710kHz (with the
interval set at 10kHz)
531 – 1,710kHz (with the
interval set at 9kHz)
– Continued on next page –
m
DVD RECEIVER
9 9
9 9

Advertisement

Table of Contents

   Related Manuals for Sony hcd-hdx501W

   Summary of Contents for Sony hcd-hdx501W

  • Page 1: Service Manual

    HCD-HDX500 Ver. 1.1 2007.03 • HCD-HDX500 is the amplifier, DVD system, tuner and video section in DAV-HDX500. • HCD-HDX501W is the amplifier, DVD system, Photo: HCD-HDX500 tuner and video section in DAV-HDX501W. This product incorporates copyright protection Model Name Using Similar Mechanism HCD-DX155 technology that is protected by U.S.
  • Page 2 LES DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES PIÈCES SONT CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NE REMPLACER CES COM- POSANTS QUE PAR DES PIÈCES SONY DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL OU DANS LES SUPPLÉMENTS PUBLIÉS PAR SONY.
  • Page 3: Self Diagnosis Function

    [VER.X.XX] (X is a number) may appear on the TV screen. Although this is not a malfunction and for Sony service use only, normal system operation will not be possible. Turn off the system, and then turn on the system again to operate.
  • Page 4: Table Of Contents

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 TABLE OF CONTENTS SERVICING NOTES 6-29. Printed Wiring Board ..........5 – IO Board (Component Side) – ........58 6-30. Printed Wiring Board GENERAL ..............9 – IO Board (Conductor Side) – ........59 6-31.
  • Page 5: Servicing Notes

    http://www.xiaoyu163.com HCD-HDX500/HDX501W SECTION 1 3 7 63 1515 0 SERVICING NOTES NOTE OF REPLACING THE EEPROM (IC1103) ON NOTES ON HANDLING THE OPTICAL PICK-UP THE MAIN BOARD BLOCK OR BASE UNIT EEPROM (IC1103) on the MAIN board cannot exchange with The laser diode in the optical pick-up block may suffer electrostatic single.
  • Page 6: About This Manual

    • The instructions in this manual are for HCD- (JPEG files) by some record companies. Please be aware that HDX500 and HCD-HDX501W. HCD- among those discs, there are some that do not HDX500 is the model used for illustration conform to the CD standard and may not be purposes.
  • Page 7 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 HOW TO IDENTIFY OPTICAL PICK-UP BLOCK Note: There are two kinds of OPTICAL PICK-UP BLOCK in this set. When replacing the OPTICAL PICK-UP BLOCK, make sure which OPTICAL PICK-UP BLOCK it is following the “How to Identify” in the figure shown below.
  • Page 8 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 MAIN BOARD SERVICE POSITION 1 Remove the back panel with IO board and CCX board . CCX board 2 Remove the MAIN board. IO board 3 Assemble the MAIN board to back panel block. 4 Reverse the back panel block.
  • Page 9: General

    http://www.xiaoyu163.com HCD-HDX500/HDX501W SECTION 2 SECTION 2 This section is extracted from instruction manual. GENERAL GENERAL 3 7 63 1515 0 Front panel A "/1 (on/standby) H VOLUME control B A (open/close) I AUDIO IN/A.CAL MIC jack C Disc operation J DISC 1-5 buttons/indicators D FUNCTION K Disc tray E Front panel display...
  • Page 10 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 Front panel display About the indications in the front panel display A Lights up when the HDMI OUT jack is J Lights up when the child lock function correctly connected to HDCP (high- is set to on.
  • Page 11: Disassembly

    http://www.xiaoyu163.com HCD-HDX500/HDX501W SECTION 3 DISASSEMBLY 3 7 63 1515 0 • This set can be disassembled in the order shown below. 3-1. DISASSEMBLY FLOW Note 1: The process described in can be performed in any order. Note 2: Without completing the process described in , the next process can not be performed.
  • Page 12: Case

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 3-2. CASE 1 two screws 2 five screws (case 3 TP2) (BV3 ) 4 case 3 two screws (case 3 TP2) L 13942296513 3-3. DIAT CON BOARD 9 DIAT CON board 8 screw (BV3) 7 case (diat) 3 two screws (BV3)
  • Page 13: Io Board

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 3-4. IO BOARD 1 wire (flat type) (9 core) (tuner) 4 wire (flat type) (15 core) qa IO board (CN3) 0 connector (CN308) 3 tuner ( FM/AM) 7 wire (flat type) (29 core) (CN601) 6 wire (flat type) (11 core) 5 wire (flat type) (11 core)
  • Page 14: Power Board

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 3-6. POWER BOARD 6 two screws 2 connector (PWH3 × 8) (CN906) 1 connector 7 shield plate (H/P) (CN903) 3 connector (CN907) 8 two screws (PWH3 × 8) 4 connector (CN901) 0 POWER board 5 connector (CN3002) 9 PC board holder...
  • Page 15: Ccx Board

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 3-8. CCX BOARD 2 connector (CN308) 1 wire (flat type) (13 core) (CN301) 3 four screws (BV3) 4 CCX board 3-9. MAIN BOARD 0 screw (BVTP3 × 12) qa two screws (BV3) wa four screws qs heat sink (AMP) L 13942296513 (BV3)
  • Page 16: Cover (md)

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 3-10. COVER (MD) 1 four screws (BV3) 2 cover (MD) L 13942296513 3-11. DVD MECHANISM DECK (CDM81C-DVBU101) 5 DVD mechanism deck (CDM81C-DVBU101) 3 connector (CN1201) 4 five screws 1 wire (flat type) (24 core) (BVTP3 ×...
  • Page 17: Tray (main) Assy

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 3-12. TRAY (MAIN) ASSY 2 two screws (BTTP M2.6) 1 two screws 3 bracket (top) (BTTP M2.6) 5 tray (main) assy L 13942296513 3-13. MOTOR BOARD 1 screw (BTTP M2.6) 3 screw (BTTP M2.6) 2 bracket 4 MOTOR board 5 Remove two solders.
  • Page 18: Base Unit (dvbu101)

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 3-14. BASE UNIT (DVBU101) 1 two floating screws (PTPWH M2.6) 3 base unit (DVBU101) 2 floating screw (PTPWH M2.6) L 13942296513 3-15. OPTICAL PICK-UP BLOCK (KHM-310CAB/313CAB) qa insulator 7 insulator screw 3 insulator screw qs insulator 9 insulator 8 insulator screw...
  • Page 19: Gear (sub Tray 1)/gear (sub Tray 2)

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 3-16. GEAR (SUB TRAY 1)/GEAR (SUB TRAY 2) PRECAUTION DURING GEAR (SUB TRAY 1/2) INSTALLATION 1 five screws (PTPWH2.6 × 8) Align the marks of the gears as shown in the illustration. 4 three gears (sub tray 1) gear (sub tray 2) 2 gear (sub tray 2)
  • Page 20: Stocker Section

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 3-18. STOCKER SECTION 2 stocker section 1 Rotate the gear (SS3) in the direction of the arrow. L 13942296513 3-19. CAM (STOCKER) PRECAUTION DURING CAM (STOCKER) INSTALLATION Before installing the cams (stocker), fix the gear (stocker 3) in the manner so that the hole of the gear (stocker 3) should be aligned with the hole of the chassis located beneath 4 lever (SW)
  • Page 21: Gear (stocker 3)

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 3-20. GEAR (STOCKER 3) PRECAUTION DURING GEAR (STOCKER 3) INSTALLATION 1 step tapping screw (PWH 2 × 6) Be sure to align the rib of the gear (stocker 3) with the groove of the rotary encoder. 2 gear (stocker 3) groove rotary encoder...
  • Page 22: Gear (bu1)

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 3-22. GEAR (BU1) 1 belt (sub tray) PRECAUTION DURING GEAR (BU2) INSTALLATION 4 screw 2 screw Before re-assembling, slide the cam (BU) in the direction of (PTPWH2.6 × 8) (PTPWH2.6 × 8) the arrow. Assemble the gear (BU2) in such a manner that the groove 3 pulley (BU) of the cam (BU) is aligned with the rib of the gear (BU2).
  • Page 23: Test Mode

    http://www.xiaoyu163.com HCD-HDX500/HDX501W SECTION 4 TEST MODE 3 7 63 1515 0 Releasing Procedure : Note: Incorrect operations may be performed if the test mode is not entered 1. Press the button and the button simultaneously for five properly. In this case, press the button to turn the power off, seconds again.
  • Page 24 http://www.xiaoyu163.com HCD-HDX500/HDX501W Ver. 1.1 3 7 63 1515 0 VOLUME TEST MODE 8. Confirm the output of speakers and monitor TV. (Confirmation Procedure: of analog signal) 1. Press the button to turn the power on. 9. To exit from this mode, press the buttons and turn the [VOLUME] dial in the direction of (+).
  • Page 25 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 DVD SECTION Manual Adjust 1. Track Balance Adjust: 1. DVD SERVICE MODE GENERAL DESCRIPTION 2. Track Gain Adjust: This mode let you make diagnosis and adjustment easily by using 3. Focus Balance Adjust: the remote commander and the TV screen.
  • Page 26 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 To Clear the Laser Hour 2. You can check the total time when the laser is turned on during Press the [ DISPLAY] button on the remote commander and then playback of DVD and CD from the above menu. The maximum press the [CLEAR] button on the remote commander.
  • Page 27 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 5. CHECKING VERSION INFORMATION To check the version information, please follow the following procedure. Procedure: 1. From the top menu of Remocon Diagnosis Menu, select “4. Version Information” by pressing the [4] button on the remote commander.
  • Page 28: Electrical Adjustments

    http://www.xiaoyu163.com HCD-HDX500/HDX501W SECTION 5 ELECTRICAL ADJUSTMENTS 3 7 63 1515 0 DVD SECTION TUNER SECTION When the base unit is replaced, perform the adjustment and the FM TUNE LEVEL CHECK measurement as shown below in this order. signal EXECUTING IOP MEASUREMENT (See page 25) generator Procedure: 1.
  • Page 29: Diagrams

    http://www.xiaoyu163.com HCD-HDX500/HDX501W SECTION 6 3 7 6 3 1 5 1 5 0 DIAGRAMS 6-1. BLOCK DIAGRAM – RF SERVO/VIDEO Section – SPDIF (Page 31) DVDRFIP SPDIF 216 VOA/A ACLK 211 VOB/B ALRCK 209 VOC/C ABCK 210 VOD/D ASDATA0 V_SEL2 (Page 30) DVDA V_SEL3...
  • Page 30: Block Diagram - Changer/hdmi/dmport Section

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 6-2. BLOCK DIAGRAM – CHANGER/HDMI/DMPORT Section – HDMI TRANSMITTER IC1701 • R-CH is omitted due to same as L-CH. • SIGNAL PATH CHANGER CONTROL, TX27M LD/ST MOTOR DRIVER CHANGER CONTROL AUDIO/VIDEO CONTROL (Page 29) : AUDIO...
  • Page 31: Block Diagram - Audio Section

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 6-3. BLOCK DIAGRAM – AUDIO Section – AUDIO SELECTOR A/D CONVERTER IC303 IC772 J305 (2/2) LINE AMP 13 VinL IC306 SAT/CABLE DOUT AUDIO IN R-CH 11 X3 R-CH 14 VinR SPDIF 14 X1 8 BCK...
  • Page 32: Block Diagram - Amp Section

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 6-4. BLOCK DIAGRAM – AMP Section – AMP BUS (Page 31) HPOUTL1 HEADPHONE D FLIP-FLOP • R-CH is omitted due to same as L-CH. HPOUTL2 J800 IC782 HPOUTR1 IC3001 PHONES •...
  • Page 33: Block Diagram - Panel/power Supply Section

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 6-5. BLOCK DIAGRAM – PANEL/POWER SUPPLY Section – T902 A+9V REGULATOR M+13V SUB POWER DIAG DC DETECT (Page 32) IC307 TRANSFORMER Q631, 632 +12V RECT A+12V, M+12V REGULATOR D941 IC941 FLUORESCENT INDICATOR TUBE DRIVER...
  • Page 34 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 • Note for Printed Wiring Boards and Schematic Diagrams • Circuit Boards Location Note on Printed Wiring Board: Note on Schematic Diagram: CCX board • X : parts extracted from the component side. •...
  • Page 35: Schematic Diagram - Main Board (1/13)

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 • See page 72 for IC Block Diagrams. 6-6. SCHEMATIC DIAGRAM – MAIN Board (1/13) – MAIN BOARD (1/13) R3906 C3911 0.01 C3901 1000p L3901 0.6uH C3912 0.01 C3902 1000p 0.6uH TB3901 L3902...
  • Page 36: Schematic Diagram - Main Board (2/13)

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 6-7. SCHEMATIC DIAGRAM – MAIN Board (2/13) – • See page 72 for IC Block Diagrams. CN3100 MAIN BOARD (2/13) Q3101,3102,3151,3152,3201,3202,3401,3402 OVER LOAD DETECT 1000p C3173 FL + 1000p C3172 R3225 R3425...
  • Page 37: Schematic Diagram - Main Board (3/13)

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 6-8. SCHEMATIC DIAGRAM – MAIN Board (3/13) – • See page 72 for IC Block Diagrams. MAIN BOARD NSPMUTE (3/13) P-GND R3045 R3044 R3046 R3501 100 R3912 SWR+ R3502 100 R3911 C3033 SWR-...
  • Page 38: Schematic Diagram - Main Board (4/13)

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 • See page 70 for Waveforms. • See page 72 for IC Block Diagrams. 6-9. SCHEMATIC DIAGRAM – MAIN Board (4/13) – MAIN BOARD (4/13) FR-A FR-B FL-B FL-A SR-A MAIN SR-B...
  • Page 39: Schematic Diagram - Main Board (5/13)

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 • See page 70 for Waveforms. • See page 72 for IC Block Diagrams. • See page 82 for IC Pin Function Description. 6-10. SCHEMATIC DIAGRAM – MAIN Board (5/13) – MAIN BOARD (5/13) D3.3V...
  • Page 40: Schematic Diagram - Main Board (6/13)

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 • See page 72 for IC Block Diagrams. 6-11. SCHEMATIC DIAGRAM – MAIN Board (6/13) – (Page MAIN MAIN BOARD (6/13) 3.3V BOARD IC504 Q631,632 (4/13) DC DETECT +5V REGULATOR MAIN (Page A12V...
  • Page 41: Schematic Diagram - Main Board (7/13)

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 • See page 70 for Waveforms. • See page 72 for IC Block Diagrams. 6-12. SCHEMATIC DIAGRAM – MAIN Board (7/13) – DIR_RST MAIN BOARD (7/13) DIR_CLK DIR_HCE R734 R726 R735 C720...
  • Page 42: Schematic Diagram - Main Board (8/13)

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 • See page 72 for IC Block Diagrams. 6-13. SCHEMATIC DIAGRAM – MAIN Board (8/13) – MAIN BOARD (8/13) AMP_D1 AMP_D2 AMP_D3 AMP_BCKO MAIN BOARD AMP_LRCKO (3/13) AMP_MCKO (Page D-GND IC651 IC704...
  • Page 43: Schematic Diagram - Main Board (9/13)

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 • See page 70 for Waveforms. • See page 82 for IC Pin Function Description. 6-14. SCHEMATIC DIAGRAM – MAIN Board (9/13) – R2169 R2186 MAIN BOARD (9/13) IC1111 C1157 SPDIF (Page 41)
  • Page 44: Schematic Diagram - Main Board (10/13)

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 • See page 72 for IC Block Diagrams. 6-15. SCHEMATIC DIAGRAM – MAIN Board (10/13) – SW+3.3V MAIN BOARD (10/13) IC B/D RF+3.3V IC1107 +3.3V REGULATOR MAIN IC1107 BOARD TK11133CSCL-G (9/13) (Page 43)
  • Page 45: Schematic Diagram - Main Board (11/13)

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 6-16. SCHEMATIC DIAGRAM – MAIN Board (11/13) – MAIN BOARD (11/13) SW+3.3V D-GND REG01 MAIN R1231 BOARD RF+3.3V (10/13) R1232 R1230 SW+5V REG02 (Page 44) 100k FCS- R1223 FCS- FCS+ R1234 R1225...
  • Page 46: Schematic Diagram - Main Board (12/13)

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 • See page 72 for IC Block Diagrams. • See page 82 for IC Pin Function Description. 6-17. SCHEMATIC DIAGRAM – MAIN Board (12/13) – R1734 MAIN BOARD (12/13) C1717 0.01 R1736...
  • Page 47: Schematic Diagram - Main Board (13/13)

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 6-18. SCHEMATIC DIAGRAM – MAIN Board (13/13) – MAIN BOARD (13/13) R4505 R4514 ASDATA4 R4504 R4515 ASDATA1 R4503 R4516 ASDATA2 R4502 R4506 R4510 ABCK R4805 R4507 R4511 ALRCK R4501 R4508 FB4512 ACLK...
  • Page 48: Printed Wiring Board - Main Board (component Side)

    http://www.xiaoyu163.com HCD-HDX500/HDX501W • See page 34 for Circuit Boards Location. 6-19. PRINTED WIRING BOARD – MAIN Board (Component Side) – : Uses unleaded solder. 3 7 6 3 1 5 1 5 0 • Semiconductor Location Ref. No. Location (Page 50) (Page 66) D501 D-12...
  • Page 49: Printed Wiring Board - Main Board (conductor Side)

    http://www.xiaoyu163.com HCD-HDX500/HDX501W • See page 34 for Circuit Boards Location. 6-20. PRINTED WIRING BOARD – MAIN Board (Conductor Side) – : Uses unleaded solder. 3 7 6 3 1 5 1 5 0 • Semiconductor Location Ref. No. Location D502 (Page 66) (Page 67) (Page 67)
  • Page 50: Printed Wiring Board - Dsp Board

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 • See page 34 for Circuit Boards Location. 6-21. PRINTED WIRING BOARD – DSP Board – : Uses unleaded solder. • Semiconductor Location Ref. No. Location IC002 DSP BOARD (COMPONENT SIDE) IC703 IC782...
  • Page 51: Schematic Diagram - Dsp Board

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 • See page 70 for Waveforms. • See page 72 for IC Block Diagrams. • See page 82 for IC Pin Function Description. 6-22. SCHEMATIC DIAGRAM – DSP Board – DSP BOARD IC B/D IC703...
  • Page 52: Printed Wiring Board - Siripara Board

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 • See page 34 for Circuit Boards Location. 6-23. PRINTED WIRING BOARD – SIRIPARA Board – : Uses unleaded solder. SIRIPARA BOARD SIRIPARA BOARD (COMPONENT SIDE) (CONDUCTOR SIDE) R634 C621 R632 R648...
  • Page 53: Schematic Diagram - Siripara Board

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 • See page 72 for IC Block Diagrams. 6-24. SCHEMATIC DIAGRAM – SIRIPARA Board – CN626 SIRIPARA BOARD M+12V MGND C623 LD MTR NEG 1000p LD MTR POS U/D MTR NEG U/D MTR POS SW1 TRY OPEN SW SEN7...
  • Page 54: Printed Wiring Boards - Changer Section

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 • See page 34 for Circuit Boards Location. 6-25. PRINTED WIRING BOARDS – CHANGER Section – : Uses unleaded solder. • Semiconductor Location Ref. No. Location D701 D711 MOTOR BOARD IC701 IC711 IC751...
  • Page 55: Schematic Diagram - Changer Section

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 • See page 72 for IC Block Diagrams. 6-26. SCHEMATIC DIAGRAM – CHANGER Section – 1 3 9 4 2 2 9 6 5 1 3 SIRIPARA BOARD CN626 (Page 53) w w w u 1 6 3...
  • Page 56: Printed Wiring Board - Ccx Board

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 • See page 34 for Circuit Boards Location. 6-27. PRINTED WIRING BOARD – CCX Board – : Uses unleaded solder. • Semiconductor Location Ref. No. Location IC300 (Page 49) IC301 MAIN BOARD IC303...
  • Page 57: Schematic Diagram - Ccx Board

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 • See page 70 for Waveforms. • See page 72 for IC Block Diagrams. • See page 82 for IC Pin Function Description. 6-28. SCHEMATIC DIAGRAM – CCX Board – CCX BOARD IC301 IC301...
  • Page 58: Printed Wiring Board - Io Board (component Side)

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 • See page 34 for Circuit Boards Location. 6-29. PRINTED WIRING BOARD – IO Board (Component Side) – : Uses unleaded solder. IO BOARD (COMPONENT SIDE) IC376 C399 L305 R411 L306 R332...
  • Page 59: Printed Wiring Board - Io Board (conductor Side)

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 • See page 34 for Circuit Boards Location. 6-30. PRINTED WIRING BOARD – IO Board (Conductor Side) – : Uses unleaded solder. J301 IO BOARD (CONDUCTOR SIDE) J306 MONITOR J305 SAT/CABLE SAT/CABLE...
  • Page 60: Schematic Diagram - Io Board (1/2)

    3 7 6 3 1 5 1 5 0 • See page 72 for IC Block Diagrams. 6-31. SCHEMATIC DIAGRAM – IO Board (1/2) – IC301 IC301 IO BOARD (1/2) TORX147L (SONY) OPTICAL RECEIVER R414 OPTICAL DIGITAL IN L306 10uH...
  • Page 61: Schematic Diagram - Io Board (2/2)

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 • See page 70 for Waveforms. • See page 72 for IC Block Diagrams. 6-32. SCHEMATIC DIAGRAM – IO Board (2/2) – IO BOARD (2/2) R364 R356 BOARD (1/2) C342 R358 (Page...
  • Page 62: Printed Wiring Boards - Panel Section

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 • See page 34 for Circuit Boards Location. 6-33. PRINTED WIRING BOARDS – PANEL Section – : Uses unleaded solder. DIAT CON BOARD EN BOARD LED BOARD S910 D500 (ILLUMINATION) ROTARY ENCODER R501...
  • Page 63: Schematic Diagram - Panel Section

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 • See page 72 for IC Block Diagrams. 6-34. SCHEMATIC DIAGRAM – PANEL Section – DIAT CON BOARD LED BOARD CN1808 R500 CN500 DIAT+12V EN BOARD Q500 LED_CON POWER DIAT GND RT1P141C-TP-1 BOARD...
  • Page 64: Schematic Diagram - Fl Board (1/2)

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 6-35. SCHEMATIC DIAGRAM – FL Board (1/2) – FL BOARD (1/2) J800 FB803 PHONES R806 FB804 C801 C804 0.01 0.01 FB802 Q804,805 FB806 J801 MUTING AUDIO IN/ Q800-803 R809 MUTING A.CAL MIC R811...
  • Page 65: Schematic Diagram - Fl Board (2/2)

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 • See page 72 for IC Block Diagrams. 6-36. SCHEMATIC DIAGRA – FL Board (2/2) – FL BOARD (2/2) Q810-819 LED DRIVE Q811 Q815 Q810 Q813 Q814 RT1P141C-TP-1 Q818 Q819 RT1P141C-TP-1 Q812...
  • Page 66: Printed Wiring Board - Fl Board

    http://www.xiaoyu163.com HCD-HDX500/HDX501W Ver. 1.1 3 7 6 3 1 5 1 5 0 • See page 34 for Circuit Boards Location. 6-37. PRINTED WIRING BOARD – FL Board – : Uses unleaded solder. (Page 59) IO BOARD CN308 (Page 48) MAIN BOARD FL BOARD CN501...
  • Page 67: Printed Wiring Board - Power Board

    http://www.xiaoyu163.com HCD-HDX500/HDX501W • See page 34 for Circuit Boards Location. 6-38. PRINTED WIRING BOARD – POWER Board – : Uses unleaded solder. 3 7 6 3 1 5 1 5 0 (Page 62) (Page 49) (Page 49) (Page 62) (Page 62) CHOPPER MAIN BOARD CHOPPER...
  • Page 68: Schematic Diagram - Power Board (1/2)

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 • See page 72 for IC Block Diagrams. 6-39. SCHEMATIC DIAGRAM – POWER Board (1/2) – POWER BOARD (1/2) C938 C930 330p 100p JW928 250V JW981 250V CHOPPER C920 K901 BOARD TH901...
  • Page 69: Schematic Diagram - Power Board (2/2)

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 • See page 72 for IC Block Diagrams. 6-40. SCHEMATIC DIAGRAM – POWER Board (2/2) – POWER BOARD (2/2) POWER BOARD (1/2) (Page IC921 IC B/D POWER CONTROL IC921 STR-V153 PC903 TLP421F(D4-GR)
  • Page 70 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 • Waveforms – IO Board – – MAIN Board – – DSP Board – – CCX Board – IC1101 <xcv (XTALI) IC3010 qf (XFSOOUT) IC002 <zvc (XTAL) IC1101 <z,x (R/Cr/Pr) IC300 wh (OSC OUT) IC309 5 (IN3) (SAT/CABLE mode)
  • Page 71 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 IC302 0 (CYin) IC302 wa (Y OUT) 1 Vp-p 2 Vp-p 500 mV/DIV, 20 µ s/DIV 2 V/DIV, 20 µ s/DIV IC302 qs (Cb in) IC302 wh (C OUT) 1.6 Vp-p 0.76 Vp-p 200 mV/DIV, 20 µ...
  • Page 72 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 • IC Block Diagrams – MAIN Board – IC503 PST3635NR IC502, 1105, 1107, 1703 TK11133CSCL-G IC1702, 3050 TK11133CSCL-G IC1707 TK11150CSCL-G OUT 1 VDD 2 OVER HEAT & – OVER CURRENT PROTECTION CONTROL – VREF CIRCUIT GND 3...
  • Page 73 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 IC704 SN74LVC257APWR INPUTS INPUTS 14 13 12 11 4A 4B 4Y 3A 3B 3Y 1A 1B 1Y 2A 2B 2Y INPUTS INPUTS IC772 PCM1808PWR ANTIALIAS VINR LOW-PASS FILTER ANTIALIAS VINL LOW-PASS FILTER DELTA-SIGMA ×...
  • Page 74 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 IC3010, 3020, 3030 CXD9843AR CLOCK CLOCK GENERATOR GENERATOR 36 XFSIIN (SECONDARY) (PRIMARY) XVSS 35 DVDD VSUBC 34 TEST 33 BFVSS VSSR OUTR2 32 BFVDD VDDR DATA FILTER & SAMPLING OUTR1 LINER GAIN ∆ Σ LOW CUT RATE S g P...
  • Page 75 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 IC3100, 3150, 3200, 3250, 3300, 3400, 3500 CXD9883M BST_A PVDD_A Over Current Fault GVDD_A PVDD_A /OTW PVDD_A VREG Gate Drive /HIZ_HS_A PGND /HIZ_LS_A Stuck Detect /RESET PGND Protection Logic Timing PGND PWM_A Control /OCH_A Programmable OC_ADJ...
  • Page 76 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 – DSP Board – IC1, 703 SI-3010KM-TL – VOUT IC782 74LVC1G79GW-125 L 13942296513 IC785 TC7WH157FK 11 7 11 6 SELECT EN G GND 4 u163 http://www.xiaoyu163.com...
  • Page 77 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 – SIRIPARA Board – IC621, 622 BH2210FV-E2 CTLIO 28 VDD RESETB 27 VSS LATCH 26 DI1 25 DO2 L 13942296513 24 P0 23 P1 22 P2 21 P3 20 P4 u163 19 P5 18 P6 17 P7 LATCHO...
  • Page 78 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 – REPLAY Board – – CCX Board – IC701, 711 BA6956AN IC301 NJM2887DL3 (TE2) THERMAL PROTECTION BANDGAP REFERENCE CONTROL LOGIC – – IO Board – IC312 TC74LCX125FT (EKJ) IC302 MM1758AFBE S-DC OUT 28 VCC2 S1/S2 14 VCC 1 OE...
  • Page 79 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 IC303, 304 MC14052 BDR2 IC309 MM1228XFBE VIN1 VOUT VIN2 2-COM BIAS CTL3 1-COM – FL Board – IC802 BU2099FV IC310 MM1508XNRE 6 IN1 17 16 15 14 13 12 12 BIT 4 IN2 CONTROL SHIFT CIRCUIT...
  • Page 80 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 – CHOPPER Board – IC001 SI8008TM-TL OVER CURRENT REGULATOR PROTECTOR LATCH RESET & DRIVER COMPARATOR OVER HEAT – ON/OFF PROTECTOR SOFT START – VREF ERROR AMP – POWER Board – L 13942296513 IC901 STR-F6138-LF1352 CURRENT MIRROR DELAY...
  • Page 81 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 IC921 STR-V153 UVLO INTERNAL − DELAY LATCH − BIAS OFF TIMER DRIVE POWER PRC LATCH MOS FET − − BLANKING BURST − DISCHARGE – − BUFFER 1 2 3 L 13942296513 IC941 – 943 SI-3010KM-TL –...
  • Page 82 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 • IC Pin Function Description MAIN BOARD IC501 M30626MHP-A70FPU0 (SYSTEM CONTROLLER) (HDX500) IC501 M30626MHP-B27FPU0 (SYSTEM CONTROLLER) (HDX501W) Pin No. Pin Name Description DAMP_SCDT/ DIAT_SDATA/ Serial data output to the stream processor, DIR-TC1 slot and digital audio interface receiver DIR_DIN DAMP_SHIFT/ Serial data transfer clock signal output to the stream processor, DIR-TC1 slot and digital audio...
  • Page 83 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 Pin No. Pin Name Description DRIVE_RST Reset signal output to the digital power amplifier "L": reset (EN) DRIVE_OCP Shut down state input from the digital power amplifier "L": shut down (DIAG) OVERFLOW1, 44, 45 Over flow status input from the stream processor OVERFLOW2 WRITE CE...
  • Page 84 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 Pin No. Pin Name Description IO_DO Serial data input from the changer control IO_CLK Serial data transfer clock signal output to the changer control CLINK_DET Connect detection signal input from the DMPORT1and DMPORT2 jack MONO/ST_DET MONO or STEREO detection signal input terminal Master/slave selection signal input terminal "L": DSP is master...
  • Page 85 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 MAIN BOARD IC1101 CXD9889R (RF AMP, SERVO DSP, MPEG DECODER) Pin No. Pin Name Description AGND Ground terminal DVDA AC coupled input path A DVDB AC coupled input path B DVDC AC coupled input path C DVDD AC coupled input path D DVDRFIP...
  • Page 86 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 Pin No. Pin Name Description USB_VDD3 Power supply terminal (+3.3V) SPFG Spindle motor hall sensor input from the motor driver CD/DVD selection signal output terminal "L": CD, "H": DVD CKSW Chucking detection switch input terminal Not used OCSW Disc table open/close detection switch input terminal Not used EEWP...
  • Page 87 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 Pin No. Pin Name Description DVDD3 Power supply terminal (+3.3V) DQM1 Data mask signal output to the SD-RAM Write enable signal output to the SD-RAM Column address strobe signal output to the SD-RAM Row address strobe signal output to the SD-RAM Chip select signal output to the SD-RAM 137, 138...
  • Page 88 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 Pin No. Pin Name Description Y signal output to the video amplifier DACVSSC Ground terminal Not used Full scale adjustment terminal VREF For reference voltage terminal DACVDDC Power supply terminal (+3.3V) ASDATA0 Audio serial data output to the HDMI transmitter TRG_SW Trigger detection switch input terminal Not used SCORE...
  • Page 89 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 Pin No. Pin Name Description LPFIN Data PLL loop filter input terminal LPFOP Data PLL loop filter output terminal ADCVDD3 Power supply terminal (+3.3V) ADCVSS Ground terminal RFVDD3 Power supply terminal (+3.3V) RFRPDC RF ripple detect output terminal RFRPAC RF ripple detect input terminal...
  • Page 90 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 MAIN BOARD IC1701 CXD9873Q (HDMI TRANSMITTER) Pin No. Pin Name Description DVSS Ground terminal (digital system) 2 to 9 C0 to C7 Digital chroma signal input terminal Not used DVDD33 Power supply terminal (+3.3V) (digital system) System clock (27 MHz) signal input from the servo DSP DVSS Ground terminal (digital system)
  • Page 91 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 Pin No. Pin Name Description DAC_AVDD3 Power supply terminal (+3.3V) (analog system) (for D/A converter) AVSS Ground terminal (analog system) (for D/A converter) DAC_AVDD3 Power supply terminal (+3.3V) (analog system) (for D/A converter) Component analog video signal (Y or green) output terminal Not used AVSS Ground terminal (analog system) (for D/A converter)
  • Page 92 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 DSP BOARD IC002 ADSST-AVR-1115 (DSP) Pin No. Pin Name Description VDDINT Power supply terminal (+1.2V) (for core) Core instruction rate to CLKIN (pin 142) ratio selection signal input terminal CLKCFG0 Fixed at "L" in this set Core instruction rate to CLKIN (pin 142) ratio selection signal input terminal CLKCFG1 Fixed at "H"...
  • Page 93 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 Pin No. Pin Name Description 56, 57 A17, A18 Not used Ground terminal VDDEXT Power supply terminal (+3.3V) (for I/O) VDDINT Power supply terminal (+1.2V) (for core) Ground terminal PF_CE Not used SPI_MAS Master/slave selection signal output terminal "L": DSP is master 64, 65 DPSOA, DPSOB...
  • Page 94 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 Pin No. Pin Name Description Ground terminal VDDINT Power supply terminal (+1.2V) (for core) Ground terminal VDDINT Power supply terminal (+1.2V) (for core) Ground terminal VDDINT Power supply terminal (+1.2V) (for core) Ground terminal VDDEXT Power supply terminal (+3.3V) (for I/O) Ground terminal...
  • Page 95 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 CCX BOARD IC300 F2602E-01-TR (XM RECEIVER) Pin No. Pin Name Description LSOPTXRX Not used Ground terminal SCTXOUT Serial data output to the system controller Power supply terminal (+3.3V) SCRXIN Serial data input from the system controller Ground terminal COMMSEL Command mode select signal input from the system controller...
  • Page 96: Exploded Views

    http://www.xiaoyu163.com HCD-HDX500/HDX501W SECTION 7 EXPLODED VIEWS 3 7 63 1515 0 NOTE: • Items marked “*” are not stocked since they The components identified by mark 0 or • -XX and -X mean standardized parts, so they dotted line with mark 0 are critical for safety. may have some difference from the original are seldom required for routine service.
  • Page 97: Front Panel Section

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 7-2. FRONT PANEL SECTION not supplied not supplied not supplied not supplied not supplied (LED board) not supplied not supplied (PW-SW board) not supplied supplied supplied supplied not supplied L 13942296513 supplied supplied not supplied (EN board) S910...
  • Page 98: Main Section

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 7-3. MAIN SECTION not supplied (HEATSINK A board) not supplied (HEATSINK B board) not supplied not supplied (SIRIPARA board) not supplied not supplied not supplied (SPEAKER board) not supplied DVD mechanism deck section-1 (CDM81C-DVBU101) not supplied L 13942296513...
  • Page 99: Dvd Mechanism Deck Section-1 (cdm81c-dvbu101)

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 7-4. DVD MECHANISM DECK SECTION-1 (CDM81C-DVBU101) not supplied supplied not supplied L 13942296513 DVD mechanism deck section-2 (CDM81C-DVBU101) Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 4-251-849-01 LEVER (SW2) 4-985-672-01 SCREW (+PTPWH M2.6), FLOATING 4-251-991-01 SPRING (SW2), TORSION 4-251-923-01 YOKE (310)
  • Page 100: Dvd Mechanism Deck Section-2 (cdm81c-dvbu101)

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 7-5. DVD MECHANISM DECK SECTION-2 (CDM81C-DVBU101) not supplied not supplied (MOTOR board) M761 M762 L 13942296513 DVD mechanism deck section-3 (CDM81C-DVBU101) S771 not supplied (ENCODER board included in RELAY board) not supplied Ref. No. Part No.
  • Page 101: Dvd Mechanism Deck Section-3 (cdm81c-dvbu101)

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 7-6. DVD MECHANISM DECK SECTION-3 (CDM81B-DVBU101) not supplied base unit (DVBU101) not supplied (SW (2) board) not supplied L 13942296513 (SW (1) board) S781 not supplied (SENSOR board) Ref. No. Part No. Description Remark Ref.
  • Page 102: Base Unit

    http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 7-7. BASE UNIT not supplied not supplied (sled motor) not supplied (spindle motor) (including spindle motor, spindle motor) L 13942296513 not supplied Note: If wire (flat type) is replaced, install it after bending it in the same form as thet before replacement.
  • Page 103: Q Qelectrical Parts List

    http://www.xiaoyu163.com HCD-HDX500/HDX501W SECTION 8 3 7 63 1515 0 ELECTRICAL PARTS LIST NOTE: • Due to standardization, replacements in the • RESISTORS The components identified by mark 0 or dotted line with mark 0 are critical for safety. parts list may be different from the parts All resistors are in ohms.
  • Page 104 http://www.xiaoyu163.com HCD-HDX500/HDX501W MAIN 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R726 1-216-809-11 METAL CHIP 1/10W R727 1-216-805-11 METAL CHIP 1/10W R1132 1-216-845-11 METAL CHIP 100K 1/10W R728 1-216-864-11 SHORT CHIP R1133 1-216-864-11 SHORT CHIP R1135...
  • Page 105 http://www.xiaoyu163.com HCD-HDX500/HDX501W CHOPPER 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark < COIL > R403 1-218-879-11 METAL CHIP 0.5% 1/10W L300 1-469-525-11 INDUCTOR 10uH R404 1-218-879-11 METAL CHIP 0.5% 1/10W R405 1-218-879-11 METAL CHIP 0.5% 1/10W...
  • Page 106 http://www.xiaoyu163.com HCD-HDX500/HDX501W CHOPPER DIAT CON 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark < RESISTOR > 1-107-826-11 CERAMIC CHIP 0.1uF 1-107-826-11 CERAMIC CHIP 0.1uF R001 1-216-809-11 METAL CHIP 1/10W 1-107-826-11 CERAMIC CHIP 0.1uF R002 1-216-829-11 METAL CHIP...
  • Page 107 http://www.xiaoyu163.com HCD-HDX500/HDX501W ENCODER 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R004 1-216-801-11 METAL CHIP 1/10W R784 1-216-821-11 METAL CHIP 1/10W 1-216-821-11 METAL CHIP 1/10W R785 1-216-864-11 SHORT CHIP R788 1-216-864-11 SHORT CHIP R005 1-216-801-11 METAL CHIP 1/10W...
  • Page 108 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark CN804 1-779-978-11 PIN, CONNECTOR 3P CN805 1-564-718-11 PIN, CONNECTOR (SMALL TYPE) 2P < FLUORESCENT INDICATOR TUBE > < DIODE > ND800 1-451-590-21 VACUUM FLUORESCENT DISPLAYS D800 6-501-579-01 DIODE MC2837...
  • Page 109 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R844 1-216-845-11 METAL CHIP 100K 1/10W S803 1-771-349-41 SWITCH, KEYBOARD (.) S804 1-771-349-41 SWITCH, KEYBOARD (FUNCTION) R845 1-216-825-11 METAL CHIP 2.2K 1/10W R846 1-216-833-11 METAL CHIP...
  • Page 110 C356 1-107-826-11 CERAMIC CHIP 0.1uF < IC > C357 1-126-933-11 ELECT 100uF C358 1-107-826-11 CERAMIC CHIP 0.1uF IC301 6-600-466-01 IC TORX147L (SONY) C359 1-126-965-11 ELECT 22uF (SAT/CABLE OPTICAL DIGITAL IN) C360 1-107-826-11 CERAMIC CHIP 0.1uF IC302 6-710-470-01 IC MM1758AFBE C361...
  • Page 111 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R316 1-216-829-11 METAL CHIP 4.7K 1/10W R385 1-216-833-11 METAL CHIP 1/10W R318 1-218-285-11 METAL CHIP 1/10W R386 1-216-821-11 METAL CHIP 1/10W R387 1-216-821-11 METAL CHIP 1/10W...
  • Page 112 http://www.xiaoyu163.com HCD-HDX500/HDX501W MAIN 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R502 1-216-833-11 METAL CHIP 1/10W C725 1-162-917-11 CERAMIC CHIP 15PF ************************************************************ C727 1-107-826-11 CERAMIC CHIP 0.1uF A-1244-176-A MAIN BOARD, COMPLETE (for SERVICE) C751 1-162-970-11 CERAMIC CHIP 0.01uF...
  • Page 113 http://www.xiaoyu163.com HCD-HDX500/HDX501W MAIN 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C1163 1-162-970-11 CERAMIC CHIP 0.01uF C1713 1-164-172-11 CERAMIC CHIP 0.0056uF 10% C1164 1-162-970-11 CERAMIC CHIP 0.01uF C1169 1-107-826-11 CERAMIC CHIP 0.1uF C1714 1-107-826-11 CERAMIC CHIP...
  • Page 114 http://www.xiaoyu163.com HCD-HDX500/HDX501W MAIN 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C3040 1-107-826-11 CERAMIC CHIP 0.1uF C3159 1-112-246-11 ELECT 100uF C3051 1-115-339-11 CERAMIC CHIP 0.1uF C3052 1-165-908-11 CERAMIC CHIP C3162 1-112-246-11 ELECT 100uF C3053 1-162-964-11 CERAMIC CHIP...
  • Page 115 http://www.xiaoyu163.com HCD-HDX500/HDX501W MAIN 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C3412 1-112-246-11 ELECT 100uF D505 6-500-334-01 DIODE MC2836-T112-1 C3413 1-104-329-11 CERAMIC CHIP 0.1uF D701 6-501-579-01 DIODE MC2837 C3414 1-136-177-00 FILM C3415 1-136-177-00 FILM D3111...
  • Page 116 http://www.xiaoyu163.com HCD-HDX500/HDX501W MAIN 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark IC502 6-702-302-01 IC TK11133CSCL-G L3501 1-456-680-11 INDUCTOR 10uH IC503 6-708-922-01 IC PST3635NR L3502 1-456-680-11 INDUCTOR 10uH IC504 6-709-034-01 IC NJM2887DL3 (TE2) L3901 1-457-077-11 AIR-CORE COIL L3902...
  • Page 117 http://www.xiaoyu163.com HCD-HDX500/HDX501W MAIN 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R511 1-216-821-11 METAL CHIP 1/10W R512 1-216-833-11 METAL CHIP 1/10W R590 1-216-295-00 SHORT CHIP R513 1-216-821-11 METAL CHIP 1/10W R591 1-216-864-11 SHORT CHIP R593 1-216-833-11 METAL CHIP...
  • Page 118 http://www.xiaoyu163.com HCD-HDX500/HDX501W MAIN 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R1601 1-216-295-00 SHORT CHIP R1602 1-216-295-00 SHORT CHIP R2126 1-216-827-11 METAL CHIP 3.3K 1/10W R1603 1-216-295-00 SHORT CHIP R2127 1-216-827-11 METAL CHIP 3.3K 1/10W R2128...
  • Page 119 http://www.xiaoyu163.com HCD-HDX500/HDX501W MAIN 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R3037 1-216-805-11 METAL CHIP 1/10W R3040 1-216-864-11 SHORT CHIP R3151 1-216-809-11 METAL CHIP 1/10W R3041 1-216-864-11 SHORT CHIP R3152 1-216-809-11 METAL CHIP 1/10W R3153 1-216-864-11 SHORT CHIP...
  • Page 120 http://www.xiaoyu163.com HCD-HDX500/HDX501W MAIN MOTOR POWER 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R3551 1-216-845-11 METAL CHIP 100K 1/10W < COMPOSITION CIRCUIT BLOCK > R3552 1-216-837-11 METAL CHIP 1/10W R3553 1-216-833-11 METAL CHIP 1/10W RB1103 1-234-371-21 RES, NETWORK 47 (1005X4) RB1104 1-234-371-21 RES, NETWORK 47 (1005X4)
  • Page 121 http://www.xiaoyu163.com HCD-HDX500/HDX501W POWER 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 0 D921 6-501-424-01 DIODE STO2D-140 0 C925 0 D922 1-107-974-11 CERAMIC 47PF 8-719-063-74 DIODE D1NL20U-TR2 0 C928 1-113-896-11 CERAMIC 220PF 250V 0 D923 6-501-174-01 DIODE UDZW-TE17-10B...
  • Page 122 http://www.xiaoyu163.com HCD-HDX500/HDX501W SENSOR POWER PW-SW RELAY 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 0 R903 1-215-926-00 METAL OXIDE 0 R904 1-215-926-00 METAL OXIDE < THERMISTOR > 0 R905 1-216-797-11 METAL CHIP 1/10W 0 R906 1-216-827-11 METAL CHIP...
  • Page 123 http://www.xiaoyu163.com HCD-HDX500/HDX501W SIRIPARA SPEAKER SW (2) SW (1) 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R662 1-216-809-11 METAL CHIP 1/10W SIRIPARA BOARD R663 1-216-809-11 METAL CHIP 1/10W *************** ************************************************************ < CAPACITOR > SPEAKER BOARD ************** C621...
  • Page 124 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark MISCELLANEOUS ************** 1-693-728-11 TUNER (FM/AM) 0 11 1-830-190-11 CORD, POWER 1-828-317-11 WIRE (FLAT TYPE) (11 CORE) 1-828-410-11 WIRE (FLAT TYPE) (29 CORE) 1-828-293-11 WIRE (FLAT TYPE) (5 CORE) 1-828-009-11 WIRE (FLAT TYPE) (11 CORE) 1-828-953-11 WIRE (FLAT TYPE) (9 CORE)
  • Page 125 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 US Model HCD-HDX500/HDX501W Canadian Model SERVICE MANUAL HCD-HDX500 Ver. 1.1 2007.03 SUPPLEMENT-1 File this supplement with the service manual. Subject: • Change of MAIN and CCX boards (Suffix-12) • Change of EN, LED, DIAT CON, SPEAKER, PW-SW and CHOPPER boards (Suffix-13) In this set, MAIN, CCX, EN, LED, DIAT CON, SPEAKER, PW-SW and CHOPPER boards have been changed in the midway of production.
  • Page 126 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 1. NEW/FORMER DISCRIMINATION – MAIN BOARD (Component Side) – Former : 1-872-103-11 : 1-872-103-12 – CCX BOARD (Component Side) – L 13942296513 Former : 1-872-121-11 : 1-872-121-12 – EN BOARD – – LED BOARD – (Component Side) (Component Side) Former : 1-782-114-11, 12...
  • Page 127 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 DIAGRAMS • Note for Printed Wiring Boards and Schematic Diagrams – SPEAKER BOARD (Component Side) – – PW-SW BOARD – (Component Side) Note on Printed Wiring Board: Note on Schematic Diagram: Former : 1-872-292-11, 12 Former : 1-872-115-11, 12 •...
  • Page 128 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 2-1. SCHEMATIC DIAGRAM – MAIN Board (1/13) – MAIN BOARD (1/13) R3906 C3911 0.01 C3901 1000p L3901 0.6uH C3912 0.01 C3902 1000p 0.6uH TB3901 L3902 CENTER 0.6uH C3913 0.01 C3903 1000p L3903 SPEAKER...
  • Page 129 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 2-2. SCHEMATIC DIAGRAM – MAIN Board (2/13) – MAIN BOARD (2/13) CN3100 Q3101,3102,3151,3152,3201,3202,3401,3402 OVER LOAD DETECT C3173 1000p FL + C3172 1000p R3225 R3425 R3175 FL - 100k 100k 100k C3123 1000p...
  • Page 130 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 2-3. SCHEMATIC DIAGRAM – MAIN Board (3/13) – MAIN BOARD NSPMUTE (3/13) P-GND R3045 R3044 R3046 R3501 100 R3912 SWR+ R3502 100 R3911 C3033 SWR- MAIN R3914 BOARD SWL+ (1/13) R3401 R3913...
  • Page 131 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 2-4. SCHEMATIC DIAGRAM – MAIN Board (4/13) – MAIN BOARD (4/13) FR-A FR-B FL-B FL-A SR-A MAIN SR-B BOARD (2/13) SL-B (Page 7) SL-A P-GND +12V P-GND R3201 R3043 R3251 R3202 R3042...
  • Page 132 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 2-5. SCHEMATIC DIAGRAM – MAIN Board (5/13) – MAIN BOARD (5/13) (Page 11) D3.3V (Page 4) MAIN BOARD (8/13) MAIN DC-DET DSP_DIR BOARD DC-DET (1/13) DIAT D3.3V OVF2 OVF2 OVF1 OVF1 MAIN...
  • Page 133 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 2-6. SCHEMATIC DIAGRAM – MAIN Board (6/13) – (Page 7) MAIN MAIN BOARD (6/13) 3.3V BOARD IC504 Q631,632 (4/13) DC DETECT (Page 5) +5V REGULATOR A12V MAIN BOARD IC504 DIAG NJM2887DL3 (1/13)
  • Page 134 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 2-7. SCHEMATIC DIAGRAM – MAIN Board (7/13) – DIR_RST MAIN BOARD (7/13) DIR_CLK DIR_HCE R726 R734 R735 C720 C721 C723 0.01 R741 DIR_SDATA DI(I) R740 DIR_DO DO(O) R739 R719 DISEL(I) DIR_ERR DIN0(I)
  • Page 135 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 2-8. SCHEMATIC DIAGRAM – MAIN Board (8/13) – MAIN BOARD (8/13) AMP_D1 AMP_D2 AMP_D3 AMP_BCKO MAIN BOARD AMP_LRCKO (3/13) AMP_MCKO (Page 6) D-GND IC651 IC704 AND GATE IC704 SN74LVC257APWR IC651 SAT_AUDIO_SEL R787...
  • Page 136 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 2-9. SCHEMATIC DIAGRAM – MAIN Board (9/13) – R2169 R2186 MAIN BOARD (9/13) IC1111 C1157 SPDIF MAIN (Page 10) 0.01 SPDIF OSC BUFFER BOARD FB1123 (7/13) IC1111 TC7PAU04FU(TE85R) IC1110 FL1111 R1142 XSYSRST...
  • Page 137 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 2-10. SCHEMATIC DIAGRAM – MAIN Board (10/13) – SW+3.3V MAIN BOARD (10/13) RF+3.3V IC1107 +3.3V REGULATOR MAIN IC1107 BOARD TK11133CSCL-G (9/13) (Page 12) LDO1 LDO2 IC1104 SD-RAM IC1104 A2V64S40CTP-G75 RF+3.3V SW+5V MAIN...
  • Page 138 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 2-11. SCHEMATIC DIAGRAM – MAIN Board (11/13) – MAIN BOARD (11/13) SW+3.3V D-GND REG01 MAIN R1231 BOARD RF+3.3V (10/13) R1232 R1230 SW+5V REG02 (Page 13) 100k FCS- R1223 FCS- R1225 100k FCS+...
  • Page 139 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 2-12. SCHEMATIC DIAGRAM – MAIN Board (12/13) – R1734 MAIN BOARD (12/13) C1717 0.01 R1736 C1718 R1731 IC1703 0.01 IC1702 +3.3V REGULATOR +1.8V REGULATOR IC1703 TK11133CSCL-G IC1702 TK11118CSCL-G FB1701 R1740 C1702 SW+5V...
  • Page 140 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 2-13. SCHEMATIC DIAGRAM – MAIN Board (13/13) – MAIN BOARD (13/13) R4505 R4514 ASDATA4 R4504 R4515 ASDATA1 R4503 R4516 ASDATA2 R4502 R4506 R4510 ABCK R4805 R4507 R4511 ALRCK R4501 R4508 FB4512 ACLK...
  • Page 141 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 2-14. PRINTED WIRING BOARD – MAIN Board (Component Side) – • Semiconductor Location Ref. No. Location (Refer to page 50 on (Refer to page 66 on D501 D-12 original service manual) original service manual) D9712 DSP BOARD...
  • Page 142 http://www.xiaoyu163.com HCD-HDX500/HDX501W 2-15. PRINTED WIRING BOARD – MAIN Board (Conductor Side) – 3 7 6 3 1 5 1 5 0 • Semiconductor Location Ref. No. Location (Refer to page 67 on (Refer to page 67 on (Refer to page 66 on D502 (Refer to page 59 on (Page 21)
  • Page 143 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 2-16. PRINTED WIRING BOARD – CCX Board – • Semiconductor Location Ref. No. Location IC300 (Page 18) IC301 MAIN BOARD IC303 CCX BOARD CCX BOARD (COMPONENT SIDE) (CONDUCTOR SIDE) CN706 IC312 IC340...
  • Page 144 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 2-17. SCHEMATIC DIAGRAM – CCX Board – CCX BOARD IC301 IC301 NJM2887DL3 +5V REGULATOR ET380 ET300 (CHASSIS) (CHASSIS) R315 CN310 330k C352 C354 C344 C351 C353 1000p 1000p DMPORT2 R323 C342 R313...
  • Page 145 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 2-18. PRINTED WIRING BOARDS – PANEL Section – DIAT CON BOARD EN BOARD LED BOARD S910 D500 (ILLUMINATION) ROTARY ENCODER R501 Q500 (DIR-TC1 SLOT) CN1809 A910 JR006 R500 C500 R502 JR007 CN1806...
  • Page 146 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 6 3 1 5 1 5 0 2-19. SCHEMATIC DIAGRAM – PANEL Section – DIAT CON BOARD LED BOARD (Refer to page 69 on original service manual) CN1808 R500 CN500 DIAT+12V EN BOARD Q500 LED_CON POWER DIAT GND RT1P141C-TP-1 BOARD...
  • Page 147 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 ELECTRICAL PARTS LIST NOTE: • RESISTORS • Due to standardization, replacements in the When indicating parts by reference number, parts list may be different from the parts All resistors are in ohms. please include the board. METAL: Metal-film resistor.
  • Page 148 http://www.xiaoyu163.com HCD-HDX500/HDX501W CHOPPER 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark < COIL > R405 1-218-879-11 METAL CHIP 0.5% 1/10W L300 1-469-525-11 INDUCTOR 10uH R406 1-218-879-11 METAL CHIP 0.5% 1/10W R407 1-218-879-11 METAL CHIP 0.5% 1/10W...
  • Page 149 http://www.xiaoyu163.com HCD-HDX500/HDX501W MAIN CHOPPER DIAT CON 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R002 1-216-829-11 METAL CHIP 4.7K 1/10W A-1244-176-A MAIN BOARD, COMPLETE (for SERVICE) R003 1-216-829-11 METAL CHIP 4.7K 1/10W (HDX500) R004...
  • Page 150 http://www.xiaoyu163.com HCD-HDX500/HDX501W MAIN 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C751 1-162-970-11 CERAMIC CHIP 0.01uF C1170 1-124-779-00 ELECT CHIP 10uF C752 1-107-826-11 CERAMIC CHIP 0.1uF C771 1-162-970-11 CERAMIC CHIP 0.01uF C1171 1-107-826-11 CERAMIC CHIP 0.1uF...
  • Page 151 http://www.xiaoyu163.com HCD-HDX500/HDX501W MAIN 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C1715 1-126-947-11 ELECT 47uF C3051 1-115-339-11 CERAMIC CHIP 0.1uF C1716 1-127-715-11 CERAMIC CHIP 0.22uF C1717 1-162-970-11 CERAMIC CHIP 0.01uF C3052 1-165-908-11 CERAMIC CHIP C1718 1-162-970-11 CERAMIC CHIP...
  • Page 152 http://www.xiaoyu163.com HCD-HDX500/HDX501W MAIN 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C3159 1-112-246-11 ELECT 100uF C3407 1-115-185-11 CERAMIC CHIP 0.033uF C3162 1-112-246-11 ELECT 100uF C3163 1-104-329-11 CERAMIC CHIP 0.1uF C3408 1-104-329-11 CERAMIC CHIP 0.1uF C3164 1-137-198-81 FILM...
  • Page 153 http://www.xiaoyu163.com HCD-HDX500/HDX501W MAIN 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark < DIODE > < IC > D501 6-501-193-01 DIODE 1SS355WTE-17 D502 6-501-193-01 DIODE 1SS355WTE-17 IC501 6-807-501-01 IC M30626MHP-B27FPU0 D504 6-501-193-01 DIODE 1SS355WTE-17 IC502 6-702-302-01 IC TK11133CSCL-G D505...
  • Page 154 http://www.xiaoyu163.com HCD-HDX500/HDX501W MAIN 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark L3401 1-456-680-11 INDUCTOR 10uH L3402 1-456-680-11 INDUCTOR 10uH R509 1-216-809-11 METAL CHIP 1/10W R510 1-216-833-11 METAL CHIP 1/10W L3501 1-456-680-11 INDUCTOR 10uH R511 1-216-821-11 METAL CHIP...
  • Page 155 http://www.xiaoyu163.com HCD-HDX500/HDX501W MAIN 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R598 1-216-296-11 SHORT CHIP R732 1-216-827-11 METAL CHIP 3.3K 1/10W R733 1-216-857-11 METAL CHIP 1/10W R599 1-216-295-00 SHORT CHIP R601 1-216-864-11 SHORT CHIP R734 1-216-809-11 METAL CHIP...
  • Page 156 http://www.xiaoyu163.com HCD-HDX500/HDX501W MAIN 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R1139 1-216-864-11 SHORT CHIP R1701 1-216-809-11 METAL CHIP 1/10W R1140 1-216-833-11 METAL CHIP 1/10W R1702 1-216-864-11 SHORT CHIP R1141 1-216-855-11 METAL CHIP 680K 1/10W R1142...
  • Page 157 http://www.xiaoyu163.com HCD-HDX500/HDX501W MAIN 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R2134 1-216-864-11 SHORT CHIP R3045 1-216-864-11 SHORT CHIP R2135 1-216-829-11 METAL CHIP 4.7K 1/10W R3046 1-216-864-11 SHORT CHIP R2150 1-216-827-11 METAL CHIP 3.3K 1/10W R2151...
  • Page 158 http://www.xiaoyu163.com HCD-HDX500/HDX501W MAIN 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R3165 1-216-864-11 SHORT CHIP R3557 1-216-845-11 METAL CHIP 100K 1/10W R3166 1-216-864-11 SHORT CHIP R3558 1-216-833-11 METAL CHIP 1/10W R3175 1-216-845-11 METAL CHIP 100K 1/10W...
  • Page 159 http://www.xiaoyu163.com HCD-HDX500/HDX501W MAIN PW-SW SPEAKER 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark RB1108 1-234-371-21 RES, NETWORK 47 (1005X4) RB1109 1-234-400-21 CONDUCTOR, NETWORK (1005X4) RB1110 1-234-400-21 CONDUCTOR, NETWORK (1005X4) RB1111 1-234-371-21 RES, NETWORK 47 (1005X4) RB1112 1-234-400-21 CONDUCTOR, NETWORK (1005X4) RB1113 1-234-400-21 CONDUCTOR, NETWORK (1005X4) RB1114 1-234-371-21 RES, NETWORK 47 (1005X4)
  • Page 160 http://www.xiaoyu163.com HCD-HDX500/HDX501W 3 7 63 1515 0 REVISION HISTORY Clicking the version allows you to jump to the revised page. Also, clicking the version at the upper right on the revised page allows you to jump to the next revised page.

This manual is also suitable for:

Hcd-hdx500

Comments to this Manuals

Symbols: 0
Latest comments: