Repair - Joyner JNSZ800DL Owner's Manual

Lubricate vehicle every 90 days of use, Apply several drops of oil in specific
points.
I. Storage Instruction
In the event your kart is not to be operated for periods in excess of 30 days or at the
end of each driving season prepare for storage as follows:
a. Drain fuel tank and carburetor by allowing engine to run out of fuel, or use a fuel
stabilizer.
b. Lubricate engine cylinder by removing the spark plug and pour one ounce of clean
lubricating oil through the spark plug hole into the cylinder. Crank the engine slowly
to spread oil and replace spark plug.
c. Do not save or store gasoline over winter. Using old gasoline, which has
deteriorated from storage, will cause hard starting and affect engine performance.
Do not drain fuel while engine is hot. Be sure to move ATV outside before draining fuel.
A. Clutch replacement
Do not remove the whole engine from vehicle when you replace the clutch, but
you'll need to remove rear suspension, driven shaft, clutch cable, muffler, wires
and rubber cushion that is in the middle of transmission and frame.
1. Remove bolt M14 (See Fig. 18)
27

REPAIR