Table of Contents
Advertisement
Owner's Manual
Electric Boosted Solar Water Heater
Models:
2F136S
2F136SD
Installation Details
Owner's Information
Warranty
For advice, repairs and service, call:
1300 365 115 (Australia)
0800 729 389 (New Zealand)
Carefully remove all packaging and
transit protection from the heater before
installation. Dispose of the packaging
responsibly using re-cycling facilities
where they exist.
Specifications and materials may change without notice.
Effective for Dux electric boosted solar water heaters manufactured and sold after 1 January 2012.
H3161
025248
3F136S
3F136SD
Rev. D
4F136S
4F136SD
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for Dux SunPro 2F136S
Summary of Contents for Dux SunPro 2F136S
-
Page 1: Installation Details
Dispose of the packaging responsibly using re-cycling facilities where they exist. Specifications and materials may change without notice. Effective for Dux electric boosted solar water heaters manufactured and sold after 1 January 2012. H3161 025248 Rev. D... -
Page 2: Table Of Contents
Installation of the Tank Plumbing Connections Specifications Installation of Collectors Plumbing Connections to Collectors Temperature Sensor Panel Management Electrical Connections Hotlogic Controller Owner’s Information Troubleshooting Warranty Other Information © Dux Manufacturing Limited 2012. All rights reserved. H3161 025248 Rev. D... -
Page 3: Welcome To Dux Hot Water
– safely, economically, and for many years to come. To be upfront about it, we want Dux to be your brand of choice. So you can depend on us to provide more than just a hot water system. -
Page 4: Installation Of The Tank
Owner’s Manual – Dux Electric Boosted Solar Installation of the Tank Installer’s Guide A properly drained overflow tray must Full and detailed installation instructions be used where property damage could are in the Installer’s Guide, included occur from water spillage. (See AS/ inside the water heater’s carton. -
Page 5: Frost Protection
Owner’s Manual – Dux Electric Boosted Solar Installation of the Tank Frost Protection Consult the table right to determine if your system needs an anti-frost valve. Tank Anti-Frost Valve Model Needed? If your model does require frost protection, you must install an anti-frost 2F136S valve. -
Page 6: Plumbing Connections
Owner’s Manual – Dux Electric Boosted Solar Plumbing Connections Installation Requirements above, a pressure limiting device This water heater must be installed (complying with AS1357) must be fitted by a licensed tradesperson, and in in the cold water inlet supply. This device... -
Page 7: Cold Water Connection
Owner’s Manual – Dux Electric Boosted Solar Plumbing Connections The PTR Valve must not be tampered Cold Water Connection with or removed. The water heater must An approved isolating valve, non not be operated unless this valve is return valve, line strainer (optional but fitted and in working order. -
Page 8: Safety Information
Owner’s Manual – Dux Electric Boosted Solar Plumbing Connections Hot Water Connection Insulation of Pipes The hot water line should be connected All hot water pipes must be insulated to the “OUTLET” socket on the tank. with UV stabilized insulation suitable for solar working temperatures, e.g. -
Page 9: Specifications
Owner’s Manual – Dux Electric Boosted Solar Specifications TOP VIEW 59.5° RIGHT VIEW LEFT VIEW FRONT VIEW System Components Dimensions (mm) 250L 315L 400L Item Description Tank Height (A) 1444 1754 1704 Number Tank Diameter (B) Solar electric tank assembly... -
Page 10: Installation Of Collectors
Owner’s Manual – Dux Electric Boosted Solar Installation of Collectors Installer’s Guide • If the collectors are installed with an Full installation instructions for the east facing bias, the best solar input collectors are in the Installer’s Guide, is achieved in the morning and if included inside the water heater’s carton. - Page 11 Owner’s Manual – Dux Electric Boosted Solar Installation of Collectors Collector Orientation Compass True North 50° from true north 70° from 45° 45° true north West Surface Plate East A. Dux preferred range B. Industry accepted range C. If orientations A or B are not practical, an additional collector can be installed at the home owner’s discretion in range C (not required north...
- Page 12 Owner’s Manual – Dux Electric Boosted Solar Installation of Collectors Collector Rail Kit For installations requiring three The Collector Rail Kit that comes collectors, an additional Collector with this water heater is designed Rail Kit is required as an extension to...
-
Page 13: Plumbing Connections To Collectors
Owner’s Manual – Dux Electric Boosted Solar Plumbing Connections to Collectors Insulation 3. Fit the sealing washer and union Irrespective of the pipe length, both base fitting to the top right hand the solar flow and return lines must be socket of the collector array. - Page 14 Owner’s Manual – Dux Electric Boosted Solar Plumbing Connections to Collectors Connections To The Collectors Insulation Supplied with the water heater are the Pipes must be insulated with UV following: stabilized insulation suitable for solar working temperatures, e.g. Armaflex •...
-
Page 15: Temperature Sensor
Owner’s Manual – Dux Electric Boosted Solar Temperature Sensor Note: Ensure that the temperature Connections To The Tank Supplied in the collector rail kit are the sensor cable does not come in contact following: with the hot collector return pipe. - Page 16 Owner’s Manual – Dux Electric Boosted Solar Collector sensor connection for models 2F136S, 3F136S, 4F136S Terminal block secured to timber or metal truss inside roof cavity Attach collector sensor cable to terminal block H3161 025248 Rev. D...
-
Page 17: Panel Management
Owner’s Manual – Dux Electric Boosted Solar Panel Management (Available only for models 2F136SD, 3F136SD and 4F136SD) designed to provide a compression The Solar Module The solar module provides protection connection, so soldering should not against both cold and hot temperature be necessary. - Page 18 Owner’s Manual – Dux Electric Boosted Solar Panel Management (Available only for models 2F136SD, 3F136SD and 4F136SD) Plumb to waste as per AS3500.4 Pipes with Do not connect to the the PTR flared fittings. drain line. Remove pipes from valve if...
-
Page 19: Electrical Connections
Owner’s Manual – Dux Electric Boosted Solar Electrical Connections This water heater requires the following Regulations electrical connections: All electrical work must: • comply with local regulations and 1. Solar Pump Module – AS3000 CONTINUOUS SUPPLY GPO must be used. - Page 20 Owner’s Manual – Dux Electric Boosted Solar Electrical Connections Electrician: Press the reset button on thermostat(s) to ensure over- temperature cut-out is set. Power Cables Power cables should be routed away from any hot water pipes. If this is not...
-
Page 21: Hotlogic Controller
Owner’s Manual – Dux Electric Boosted Solar Hotlogic Controller Hotlogic Controller The Hotlogic controller should be plugged in to a weatherproof approved power outlet for 10amps, 230 to 250 volt, 50Hz supply. Hotlogic Controller Diagnosis Codes The Hotlogic controller must be wired according to the diagram shown right. - Page 22 Owner’s Manual – Dux Electric Boosted Solar Hotlogic Controller For models 2F136SD, 3F136SD, 4F136SD: Observation Explanation Power LED Solid green Operating normally No power Red flashing Internal Hotlogic error Sensors LED Solid green Operating normally Green fast flashing Over temperature protection operating...
-
Page 23: Owner's Information
Owner’s Manual – Dux Electric Boosted Solar Owner’s Information How Does My System Work? What Does The Circulation Pump Do The main components of your solar In The System? water heater are the water storage tank, The circulating pump draws cold water... - Page 24 Owner’s Manual – Dux Electric Boosted Solar Owner’s Information The Hotlogic Controller What Should I Do During Holidays? This device ensures optimum system The system can monitor and control efficiency and safety. The basic the solar collector temperature while functions are: you are away.
-
Page 25: Water Quality
Owner’s Manual – Dux Electric Boosted Solar Owner’s Information Water Quality System Maintenance Your Dux water heater has been The solar water heater is designed such manufactured to suit water conditions of that there is little to do regarding system most Australian metropolitan supplies. - Page 26 Owner’s Manual – Dux Electric Boosted Solar Owner’s Information all fittings, fill the heater and Five Year Service – By Authorised Personnel Only restore the electricity supply. The five year service must be carried Draining the Water Heater out by a licensed tradesperson. It is...
-
Page 27: Troubleshooting
Owner’s Manual – Dux Electric Boosted Solar Troubleshooting What Should I Check Before Insufficient Hot Water Making A Service Call? • Is the Pressure & Temperature Relief If there is not enough hot water, it is Valve discharging too much water? recommended that the following points be •... - Page 28 Owner’s Manual – Dux Electric Boosted Solar Troubleshooting 450 litres of water it is possible that Condensation in Collectors there will be certain times of the In winter, or in times of heavy rain, day where there is insufficient hot water vapour may form in the warm and water.
-
Page 29: Warranty
5 Year Replacement Guarantee If an inner cylinder or solar collector Terms of Warranty and Replace- fails on a Dux hot water unit within a ment Guarantee further four (4) years after the end of the initial one (1) year warranty period,... - Page 30 If Dux fails to meet a guarantee under including excessive water pressure or the ACL, your remedy for such failure temperature, neglect of any kind or...
- Page 31 Owner’s Manual – Dux Electric Boosted Solar Warranty include the following details: As required by legislation, including under the ACL, any claims for damage • Date of Purchase; to furniture, carpets, walls, foundations • Location of Purchase; or any other consequential loss either directly or indirectly due to defects •...
-
Page 32: Other Information
Privacy Act Amendment (2000): If and whenever warranty service is required, your personal details will be given to an Authorised Dux Service Agent only for the express purpose of carrying out the arranged warranty service work agreed by you the client and Dux Manufacturing Limited. - Page 33 Owner’s Manual – Dux Electric Boosted Solar H3161 025248 Rev. D...
- Page 34 Owner’s Manual – Dux Electric Boosted Solar H3161 025248 Rev. D...
- Page 35 Owner’s Manual – Dux Electric Boosted Solar H3161 025248 Rev. D...
-
Page 36: Preventative Maintenance
Owner’s Manual – Dux Electric Boosted Solar Electric Boosted Solar Water Heater For advice, repairs and service, call: 1300 365 115 (Australia) 0800 729 389 (New Zealand) Please Register Your Water Heater Please take a moment to fill out your details for warranty registration at: www.dux.com.au/warranty...
Need help?
Do you have a question about the SunPro 2F136S and is the answer not in the manual?
Questions and answers
Why does the hot water boost sometimes not come on when the switch is on Dux Sun Pro 3F136S
The hot water boost may not activate on the Dux SunPro 2F136S if the electrical supply to the pump module is not continuous. Off Peak power must not be used for the boost to work. The system requires a continuous tariff connection to ensure the boost function is available, especially for heavy daytime users.
This answer is automatically generated