Installation Codes And Standards; Assembly - Vulcan-Hart MG12 Installation & Operation Manual

The range must be installed so that the flow of combustion and ventilation air will not be
obstructed. Adequate clearance for air openings into the combustion chamber must be
provided. Make sure there is an adequate supply of air in the room to allow for combustion of
the gas at the burners.

INSTALLATION CODES AND STANDARDS

For proper installation procedures in the United States of America, refer to:
1. State and local codes.
2. National Fuel Gas Code, ANSI-Z223.1 (latest edition). Copies may be obtained from The
American Gas Assn., Inc., 1515 Wilson Blvd., Arlington, VA 22209.
3. National Electrical Code ANSI/NFPA-70 (latest edition). Copies may be obtained from The
National Fire Protection Assn., Batterymarch Park, Quincy, MA 02269.
In Canada, refer to:
1. Local codes.
2. CAN/CGA-B149.1 Installation for Natural Gas Burning Appliances and Equipment (latest
edition).
3. CAN/CGA-B149.2 Propane Installation Code (latest edition), available from The Canadian
Standards Association, 178 Rexdale Blvd., Etobicoke, Ontario, Canada M9W 1R3.

ASSEMBLY

Installation of Standard Griddle Top Bricks
The griddle top section is extremely heavy. It will require three people to install the griddle and
griddle brick — two people to lift the griddle plate and one person to set the bricks and griddle
thermostat capillary bulb(s) in place.
The range griddle top section utilizes a two-fold baffle assembly to support the composite/mortar
fire bricks. There will always be only one small 6
griddle top order. There will be at least one 9
possibly more, depending on the griddle width.
1
⁄2" (16 cm) wide baffle will utilize two 10" x 4" (25 cm x 10 cm), and two 7" x 4" (17 cm x
The 6
10 cm) brick sets.
7
⁄8" (25 cm) wide baffle assembly will utilize two 10" x 4" (25 cm x 10 cm), and two 7" x 4"
The 9
(17 cm x 10 cm) brick sets.
1. The griddle bricks are shipped in a rectangular cardboard box. Locate the box and carefully
inspect quantities as explained above.
If a brick has been broken into two pieces, it can still be used. Just place the pieces
into position as shown in Fig. 1. However, if a brick is broken into more than two pieces, it will
need to be replaced. Contact your local Vulcan servicer.
2. Clean anti-rust coating from top of griddle, following the procedures described in the
__________________________________________________________________________________
1
⁄2" (16 cm) wide baffle assembly with every
7
⁄8" (24 cm) wide baffle assembly per griddle,
6