Replacing The V-Belt - Yamaha 2012 TMAX XP500A Service Manual

Recommended antifreeze
High-quality ethylene glycol anti-
freeze containing
inhibitors for aluminum engines
Mixing ratio
1:1 (antifreeze:water)
Radiator capacity (including all
routes)
1.50 L (1.59 US qt, 1.32 Imp.qt)
Coolant reservoir capacity (up
to the maximum level mark)
0.27 L (0.29 US qt, 0.24 Imp.qt)
Handling notes for coolant
Coolant is potentially harmful and should
be handled with special care.
EWA13040
WARNING
• If coolant splashes in your eyes, thor-
oughly wash them with water and consult
a doctor.
• If coolant splashes on your clothes,
quickly wash it away with water and then
with soap and water.
• If coolant is swallowed, induce vomiting
and get immediate medical attention.
ECA13480
• Adding water instead of coolant lowers
the antifreeze content of the coolant. If
water is used instead of coolant check,
and if necessary, correct the antifreeze
concentration of the coolant.
• Use only distilled water. However, if dis-
tilled water is not available, soft water
may be used.
• If coolant comes into contact with painted
surfaces, immediately wash them with
water.
• Do not mix different types of antifreeze.
10. Install:
• Radiator cap
11. Fill:
• Coolant reservoir
(with the recommended coolant to the
maximum level mark "a")
corrosion
12. Install:
13. Start the engine, warm it up for several
14. Check:
TIP
Before checking the coolant level, wait a few
minutes until the coolant has settled.
15. Install:
EAS4B51007

REPLACING THE V-BELT

1. Remove:
3-31
PERIODIC MAINTENANCE
• Coolant reservoir cap
minutes, and then stop it.
• Coolant level
Refer to "CHECKING THE COOLANT
LEVEL" on page 3-29.
• Footboard (left)
Refer to "GENERAL CHASSIS" on page
4-1.
• Side cover (left)
Refer to "GENERAL CHASSIS" on page
4-1.
• Center cover
Refer to "GENERAL CHASSIS" on page
4-1.
• Center cover
Refer to "GENERAL CHASSIS" on page
4-1.
• Side cover (right)
Refer to "GENERAL CHASSIS" on page
4-1.
• Footboard (right)
Refer to "GENERAL CHASSIS" on page
4-1.
• Outer V-belt case
Refer to "V-BELT AUTOMATIC TRANS-
MISSION" on page 5-39.