Replacing The Air Filter Element; Replacing The V-Belt - Yamaha 2009 XP500Y TMAX Service Manual

Oil pressure (hot)
150.0 kPa/1200 r/min (21.8
psi/1200 r/min) (1.50
kgf/cm²/1200 r/min)
Oil temperature
70.0 °C (158.00 °F)
Out of specification → Adjust.
Engine oil pressure
Below specification
Above specification
6. Install:
• Engine oil pressure check point plug
Engine oil pressure check point
plug
12 Nm (1.2 m·kg, 8.7 ft·lb)
EAS20961

REPLACING THE AIR FILTER ELEMENT

1. Remove:
• Front lower inner panel
Refer to "GENERAL CHASSIS" on page 4-1.
2. Remove:
• Air filter case cover "1"
3. Check:
• Air filter element "1"
Damage → Replace.
TIP
• Replace the air filter element every 40000 km
of operation.
• The air filter needs more frequent service if you
are riding in unusually wet or dusty areas.
Possible causes
• Faulty oil pump
• Clogged oil filter
• Leaking oil passage
• Broken or dam-
aged oil seal
• Leaking oil passage
• Faulty oil filter
• Oil viscosity too
high
1
3-14
4. Install:
• Air filter case cover
ECA4B51003
NOTICE
Never operate the engine without the air filter
element installed. Unfiltered air will cause
rapid wear of engine parts and may damage
the engine. Operating the engine without the
air filter element will also affect throttle body
synchronization, leading to poor engine per-
formance and possible overheating.
TIP
When installing the air filter element into the air
filter case cover, make sure that the sealing sur-
faces are aligned to prevent any air leaks.
5. Install:
• Front lower inner panel
Refer to "GENERAL CHASSIS" on page 4-1.
EAS4B51007

REPLACING THE V-BELT

1. Remove:
• Right footrest board
Refer to "GENERAL CHASSIS" on page 4-1.
• Outer V-belt case
Refer to "V-BELT AUTOMATIC TRANSMIS-
SION" on page 5-35.
2. Check:
• V-belt
Cranks/damage/wear → Replace.
Grease/oil → Clean the primary and second-
ary pulleys.
Refer to "V-BELT AUTOMATIC TRANSMIS-
SION" on page 5-35.
TIP
Replace the V-belt every 20000 km of operation.
3. Install:
• Outer V-belt case
Refer to "V-BELT AUTOMATIC TRANSMIS-
SION" on page 5-35.
• Right footrest board
Refer to "GENERAL CHASSIS" on page 4-1.
ENGINE
1