Weil-McLain GOLD CGt Manual page 36

GOLD CGt Gas-Fired Water Boiler — Boiler Manual
9c
Operation — operating instructions
Figure 30 Operating instructions
FOR YOUR SAFETY READ BEFORE OPERATING
A. This appliance is equipped with an ignition
device which automatically lights the pilot.
try to light the pilot by hand.
not
B. Before , smell all around the
OPERATING
appliance area for gas. Be sure to smell next to
the floor because some gas is heavier than air
and will settle on the floor. See below.
• Do not try to light any appliance.
• Do not touch any electric switch; do not use
any phone in your building.
1. Read the safety information above on this label.
Stop!
2. Set the thermostat and tankless heater low limit control to lowest settings.
3. Turn off all electrical power to the appliance.
4. Remove jacket front panel.
5. This appliance is equipped with an ignition device which automatically lights the burner.
Do not try to light the burner by hand.
6. Turn
Gas control knob
7. Wait five (5) minutes to clear out any gas. Then smell for gas, including near the floor. If
you smell gas, Follow
STOP!
go to the next step.
8. Turn
Gas control knob
9. Turn on all electric power to the appliance.
10. Set thermostat and tankless heater low limit control to desired setting.
11. If the appliance will not operate, follow the instructions
below and call your service technician or gas supplier.
12. Replace jacket front panel.
1. Set the thermostat and tankless heater low limit control to lowest settings.
2. Turn off all electric power to the appliance if service is to be performed.
3. Remove jacket front panel.
4. Turn
Gas control knob
5. Replace jacket front panel.
36
If you do not follow these instructions exactly, a fire or explosion may
result causing property damage, personal injury or loss of life.
Do
WHAT TO DO IF YOU SMELL GAS
OPERATING INSTRUCTIONS
clockwise to .
OFF
in the safety information above. If you don't smell gas,
"B"
counterclockwise to
ON
TO TURN OFF GAS TO THE APPLIANCE
clockwise to . Do not force.
OFF
C. Use only your hand to turn the gas control knob. Never use
tools. If the knob will not turn by hand, don't try to repair it,
call a qualified service technician. Force or attempted repair
may result in a fire or explosion.
D. Do not use this appliance if any part has been under water.
Immediately call a qualified service technician to inspect the
appliance and to replace any part of the control system and
any gas control, which has been under water.
• Immediately call your gas supplier from a neighbor's phone.
Follow the gas supplier's instructions.
• If you cannot reach your gas supplier, call the fire department.
.
"To Turn Off Gas To Appliance"
White-Rodgers
36E Gas valve
Position indicator
(shown in "ON" position)
Gas control knob
Honeywell
VR8204
Gas valve
Position indicator
(shown in "ON" position)
Gas control knob
029005
Part Number 550-110-290/0501