Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Troubleshooting
Related Manuals for Bailey Motorhomes
Summary of Contents for Bailey Motorhomes
- Page 1 Owner’s Manual...
-
Page 2: Owner's Details
Owner’s Details Model _________________________________________________________________ Vehicle Identification Number V.I.N. _______________________________________ Owner’s Name __________________________________________________________ Address ________________________________________________________________ _______________________________________________________________________ _______________________________________________________________________ _______________________________________________________________________ _______________________________________________________________________ Tel. No. _________________________________________________________________ Key Nos: All Doors _____________________________________________________ Water Filler Cap ________________________________________________ Retailer’s Name _________________________________________________________ Address ________________________________________________________________ _______________________________________________________________________ _______________________________________________________________________ _______________________________________________________________________ _______________________________________________________________________ Tel. No. _________________________________________________________________... - Page 3 The essential accessory for your new caravan! Away from the rush of every day life and the busy tourist centres, you’ll find over 200 Club Sites in areas of outstanding natural beauty across the country. Some located in National Parks, on land owned by the National Trust or even in the grounds of stately homes.
-
Page 4: Table Of Contents
Contents Owner’s Details ............1 3.2.2 Types of gas ..........3-6 3.2.3 Changing Gas Cylinders ....... 3-7 Contents ..............3 3.2.5 Gas safety advice .......... 3-7 INTRODUCTION ........... 1-1 3.2.6 Awning Space LPG Appliance Exhaust ..3-7 WARRANTY ..........1-2 3.2.7 Gas Leaks ............. -
Page 5: Contents
Contents 4.10.3 12v Operation ..........4-17 4.16.15 Noises whilst driving ........4-36 4.10.4 Regulating the temperature ......4-17 4.16.16 Remedial Action .......... 4-36 4.10.5 On LP Gas operation ........4-17 4.16.17 Storing ............4-36 4.10.6 On 230v Operation ........4-17 4.16.18 Towing ball ........... - Page 6 Contents 5.1.10 For Containers ..........5-3 5.1.11 For Systems ..........5-3 FIRE AND SAFETY PRECAUTIONS ... 5-4 5.2.1 Children ............5-4 5.2.2 Fire Extinguishers .......... 5-4 5.2.3 In Case of Fire ..........5-4 5.2.4 Ventilation ............5-4 5.2.5 Petrol/Diesel Fumes ........5-5 5.2.6 Original Equipment Appliances .....
- Page 7 Congratulations on the purchase of a fine touring caravan! To ensure you enjoy your caravanning to the full, may we commend the following books from Haynes Publishing? They have been written by John Wickersham whose caravanning articles appear every month in several magazines, including the Members’...
-
Page 8: Introduction
Your caravan is designed to give many years of use, regular maintenance is however necessary to ensure trouble free service. Your Bailey Retailer is equipped to offer service facilities, repair work and any spare parts you may require. -
Page 9: Warranty
Bailey retailers sell our products of their own choice and not as agents. They are, therefore, unable to bind Bailey Caravans Ltd or make any representation or undertaking whatsoever on behalf of Bailey Caravans Ltd. -
Page 10: Terms And Conditions
Bailey Service Centre from Bailey Caravans Limited. No liability will exist with regard to any claims not authorised in this way. 8. Bailey Caravans Limited reserve the right to examine the tourer before any repairs commence or any replacement part fitted. -
Page 11: Caravan Registration And Identification Scheme (C.r.i.s)
Introduction CARAVAN REGISTRATION AND IDENTIFICATION SCHEME (C.R.I.S) This caravan has been security marked and recorded under the Caravan Registration and Identification Scheme that is organised by the Caravan Industry. Shortly after purchasing this caravan you should receive your Touring Caravan Registration Document. It will be sent by post to your home address. -
Page 12: Safety
Introduction SAFETY This handbook contains the information that you will require for safe enjoyment of your tourer. All of the information contained herein is important. However to draw your attention to specific items we have prefixed them with the following symbols to indicate a warning, caution or note respectively: Warnings are items that if ignored can cause the user(s) physical harm. -
Page 13: Introduction
▲ The towing vehicle and towing hitch handbooks/manufacturers must be consulted for their specification prior to towing. ▲ The maximum static nose weight for all Bailey caravans is 100Kg. This should never be exceeded regardless of whether the towing vehicle’s upper limit is greater. -
Page 14: Measurement Of Nose Weight
Nose weight may be measured using a proprietary brand of nose weight indicator. Such equipment is obtainable from your Bailey Dealer. Another simple method is to use bathroom scales and a suitable piece of strong timber as a platform to rest the tow hitch on. -
Page 15: Recommended Tow Ball Height
▲ Always consult your tow vehicle manufacturer for advice on towing and the loads that the vehicle is capable of towing. 2.2.4 Recommended tow ball height The recommended tow ball height for Bailey Caavans is 415 +/- 35mm (i.e. between 380mm and 450mm). 2.2.5 Secondary braking cable (Break away device) Purpose - To apply a trailer’s brakes if it becomes separated from its towing vehicle. -
Page 16: Loading And Distribution Of Weight In The Caravan And Car
Caravan & Tow Vehicle Where no designated Fig c Fig b attachment point has been provided on the towbar: Fixed ball - Loop the cable around the neck of the towball. If you fit the cable like this, use a single loop only. See Figs. -
Page 17: Noseweight
Caravan & Tow Vehicle ▲ Always load the caravan in such a way that maximises towing safety. Incorrect caravan loading and/or overloading of the towing vehicles rear suspension will also result in poor towing stability. The weight should be distributed so that each side of the caravan carries, approximately, the same LIGHT MEDIUM... -
Page 18: Hitching The Caravan To The Tow Vehicle
Caravan & Tow Vehicle All lockers and cupboard doors are closed and secured All bunks are secure All rooflights, extractor fans and sunroofs are closed and secured Tables are securely stored in their transit positions Fridge is on 12v operation and door lock is set (if required) All windows are fully closed and latched. - Page 19 Caravan & Tow Vehicle When reversing aim the tow ball of the car directly at the caravan towing hitch. When the car’s tow ball is as close to the caravan’s towing hitch as possible fully apply the car’s handbrake, turn off the engine and leave the car in first gear (Park or ‘P’ Position for Automatics). The final positioning should be carried out by manoeuvring the caravan by hand.
-
Page 20: Towing
Caravan & Tow Vehicle Pick up any levelling pads or levelling boards. Check round the caravan for anything left behind. Fully release the caravan’s handbrake. Carry out a second check that the hitch is secure and the secondary braking cable is connected. Adjust all of the car’s driving mirrors from driving seat to ensure good rear wards visibility. -
Page 21: Mirrors
Caravan & Tow Vehicle Reduce speed in high winds, cross winds, downhill or in poor visibility. High sided vehicles such as lorries or coaches can cause air buffeting, so extra care must be taken when passing or being passed. Give as much space as is possible between your caravan and the high sided vehicle. -
Page 22: Stabilisers
INTERIOR 2.3.11 Types of tyres fitted BROWN NO CONNECTION FRIDGE TUBES The tyres fitted by Bailey Caravans are suitable BLACK RETURN FOR FRIDGE ONLY PINS for towing at sustained speeds of up to 81 mph (130 kph) to allow for use in countries which permit this speed. -
Page 23: Tyre Pressures
If a wheel or tyre has to be changed it should be of the same type of construction and size as originally fitted. ▲ Only use a spare wheel and tyre recommended by Bailey Caravans, which should be of the same specification as those fitted to the caravan. -
Page 24: Changing A Wheel
Caravan & Tow Vehicle ▲ Always ensure that the spare wheel carrier’s black plastic nut is fully tightened and the split pin in place before towing. Ranger and Discovery models have dedicated spare wheel and tyre storage area in the nearside of the gas bottle box. -
Page 25: Levelling The Caravan
Caravan & Tow Vehicle Fully apply the caravan handbrake. Unclamp and lower the jockey wheel to the ground. Re-clamp it in this position. Operate the locking button on the hitch head and move the handle forward to release the mechanism. Operate the jockey wheel handle until the coupling head is clear of the towing ball. - Page 26 Caravan & Tow Vehicle 2-14...
-
Page 27: The Water System
Caravan Service Systems THE WATER SYSTEM 3.1.1 Water Supply All models are supplied with a 12 volt submersible pump, controlled by a pressure switch. The water inlet is located in the off-side exterior wall, protected by a lift up lid. 3.1.2 The Submersible Pump Operation... -
Page 28: Inline Filter (Whale Aquasource Wf1230)
Caravan Service Systems 3.1.5 InLine Filter (Whale Aquasource WF1230) ● The InLine Filter is located beneath the kitchen sink on the cold feed to the tap, (this ensures drinking water only is filtered extending the life of the filter). ● The Filter should be replaced every season. ●... -
Page 29: Adjusting Pressure Switch
Always ensure that the in board water tank is empty when towing. 3.1.10 Aquasource Direct Mains Water Connection: (This is not included as standard equipment, but is available from your nearest Bailey retailer). ● The Aquasource fits simply and securely to your Whale socket system. -
Page 30: Draining And Winterisation Of The Water System
Caravan Service Systems 3.1.11 Draining and Winterisation of the Water System Caravans may be in use all year round, but when not in use, even for short periods, this procedure should be followed. One night of freezing temperatures is all that is required for expensive, permanent damage to water system components. -
Page 31: Waste (Grey) Water System
Upon arrival at the caravan site advice should always be sought from the site manager as to where waste (Grey) water is to be disposed of. THE GAS SYSTEM All gas appliances fitted to your Bailey caravan are suitable for operation on both Butane and Propane without the need for adjustment. 3.2.1... -
Page 32: Types Of Gas
Caravan Service Systems 3.2.2 Types of gas ● Butane Butane is supplied in the UK in Green or Blue bottles. Continental bottles usually have a male left hand thread similar to but not identical with UK Butane. Butane is suitable for use at temperatures down to 2°C but will not work below that temperature. ●... -
Page 33: Changing Gas Cylinders
Caravan Service Systems Your caravan is fitted with a regulator as standard equipment. This is located in the caravan gas box mounted on the front bulkhead of the caravan between the gas bottles. The gas regulator has a working pressure of 30mbar and is suitable for both propane and butane liquefied petroleum gas. -
Page 34: Gas Leaks
Caravan Service Systems 3.2.7 Gas Leaks If a smell of gas becomes apparent, the supply should be turned off at the cylinder immediately. Extinguish naked lights including cigarettes and pipes. Do not operate electrical switches. Open all doors and windows to disperse any gas escape. Butane/Propane gas is heavier than air, any escaping gas will therefore collect at a low level. -
Page 35: The Electrical System - 230 Volt
Caravan Service Systems THE ELECTRICAL SYSTEM – 230 VOLT As in the home, care must be exercised when handling mains electricity. Your attention is drawn to the following notice as laid down by the Institute of Electrical Engineers. Instructions for electricity supply - low voltage (230 v) 3.3.1 On arrival at caravan site ▲... -
Page 36: On Leaving Caravan Site
Caravan Service Systems 3.3.2 On leaving caravan site ● first switch off the site supply. ● switch off the caravan RCD unit. ● then disconnect the pitch lead. In case of difficulty consult an approved electrical installation contractor (who may be the local electricity board). -
Page 37: Mains Unit
Caravan Service Systems A means of checking the polarity of the mains supply when overseas is useful. There are available several proprietary makes of equipment for the purpose (e.g. Martindale tester unit). If it can be achieved, it is preferable to connect live to live, and neutral to neutral to maintain full electrical protection. -
Page 38: The Electrical System - 12 Volt
Caravan Service Systems 230V Mains equipment typical consumption figures: Fridge ..........0.5 amps Colour TV ....... 2.5 amps Charger ........... 0.5 amps Microwave ....... 10 amps Water heater ......... 3.75 amps Air conditioning ....4 amps Blown/convection air heating ..8.7 amps THE ELECTRICAL SYSTEM –... -
Page 39: 12-Volt Control Panel
Caravan Service Systems 3.4.1 12-volt Control Panel The system is fitted with an automatic relay to select the power source. When the car is connected via the ‘s’ plug the car power will be used. When the car is not connected the battery and or the power supply will be used to power the caravan. - Page 40 Caravan Service Systems DIY modifications/additions to the wiring systems are not recommended, always consult your Dealer who will be pleased to carry out such work. Do not continuously charge the battery when caravan is not in use. ▲ Switch off all appliances before disconnecting battery. ▲...
-
Page 41: The Truma Ultrastore Water Heater
Caravan Equipment THE TRUMA ULTRASTORE WATER HEATER Operating Instructions 4.1.1 Filling the Truma Ultrastore with water ● Check that the safety/drain valve in the cold water intake is closed. The yellow lever should be in the horizontal position, position (e). ●... -
Page 42: Gas Operating Instructions
Caravan Equipment 4.1.2 Gas operating instructions ▲ Never operate the water heater without water in it! ● Remove exterior cowl cover. ● Open gas cylinder and open quick-acting valve in the gas supply line. ● Select required water temperature at rotary knob (a) infinitely variable from approx. 30 to 70 rotating the inner ring (b). -
Page 43: Electrical Operating Instructions (230V)
Caravan Equipment 4.1.4 Electrical operating instructions (230v) Ensure that the water heater is full then switch the isolation switch on. (Usually mounted on the bunk face adjacent to the gas control switch.) ▲ The water temperature cannot be selected, temperature is automatically limited to 70 C. -
Page 44: Important Operating Notes
Caravan Equipment 4.1.7 Important Operating Notes: ● If the cowl is positioned close to an opening hatch (window), keep this closed during operation . See warning plate. Always mount the cowl cover if the heater is not being used. Nonobservation of this point can lead to the function of the appliance being impaired through water, dirt or insects. -
Page 45: Technical Data
Caravan Equipment 4.1.9 Technical Data Water contents: ........10 litres Gas and electrical operation ... approx. 25 mins Water pressure: ....up to max. 2.8 bar Power consumption ........12V Type of gas: ..Liquid Gas (propane or butane) Ignition: ........... 0.17 A Operating Pressure: ...... -
Page 46: The Truma S 3002 El Space Heater
Caravan Equipment THE TRUMA S 3002 EL SPACE HEATER 4.2.1 Gas Operation Switching on ● Turn on gas cylinder. a = Control knob ● For space heaters fitted with manual piezo ignition b = Integrated control panel for Trumavent fan TEB (Discovery and Ranger) turn control knob to c = Piezo ignitor thermostat setting 1-10 and press it down as far... -
Page 47: General Safety Notes
Caravan Equipment ● Any alteration to the appliance (including exhaust duct and cowl) or the use of spare parts and accessories which are important to the function of the heater and which are not original Truma parts, as well as the non-observance of the installation and operating instructions, will lead to the cancelling of the guarantee and exclusion of liability claims. -
Page 48: Technical Data
Caravan Equipment ● Do not operate appliance when refuelling the vehicle and when in the garage. ● Always connect the pressure regulator to the gas cylinder with great care. Inspect the regulator connection hoses regularly for signs of weakness. Caravanning gas cylinders must always be upright. 4.2.5 Technical data Gas Consumption : ...... -
Page 49: Truma 12V Fan Operation
Caravan Equipment ▲ Any alteration to the appliance (including exhaust duct and cowl) or the use of spare parts and accessories which are important to the function of the heater and which are not original Truma parts, as well as the non-observance of the installation and operating instructions, will lead to the cancelling of the guarantee and exclusion of liability claims. -
Page 50: Truma Triomatic Automatic Propane Gas Change-Over System
Caravan Equipment greater heat requirement. This means that the air output can be used to the full on this side. By adjusting the air flap (Fig. 1:d) the quantity of air can be increased individually. This means that the air output on the other side is reduced. -
Page 51: Checking For Leaks
Caravan Equipment 4.3.4 Checking for leaks ● Switch off all appliances. ● Open both the gas cylinder valves ● Read off the pressure on the gauge and close both the cylinder valves ● If the pressure gauge indicates the same pressure after a period of 10 minutes there are no leaks. If the pressure drops the gas system is leaking. -
Page 52: The Midi Oven & Grill
Caravan Equipment Butane - Normally on initial lighting, a small amount of yellow tipping will occur and then slightly increases as the burner heats up. Although each burner will support pans from 10 to 22cm, care should be taken not to overload the appliance as reduced performance may result. When using small pans, the flames should not spread beyond the base of the pan as this will reduce the efficiency of the burner. -
Page 53: Oven
Caravan Equipment 4.7.2 Oven 1. Ensure the gas cylinder is connected and turned on. In the event of a gas smell turn off at gas cylinder and contact supplier. 2. Remove all accessories and packing that may be in the oven and clean the interior before using it for the first time. -
Page 54: Cooking Guidelines
Caravan Equipment DISH GAS MARK SHELF POSITION COOKING TIME scones 8-15 mins small cakes 15-25 mins victoria sandwich 20-30 mins puff 15-30 mins flaky 15-30 mins shortcrust 15-55 mins shortbread fingers 25-30 mins rice pudding 100-120 mins baked custard 50-60 mins fruit crumble 30-40 mins beef... -
Page 55: Maintenance & Servicing
Caravan Equipment 4.7.5 Maintenance & Servicing This appliance needs little maintenance other than cleaning. All parts should be cleaned using warm soapy water. Do not use abrasive cleaners, steel wool or cleansing powders. When cleaning the burner ring it is essential to ensure that the holes do not become blocked. The control knobs are a push fit and can be removed for cleaning. -
Page 56: Refrigerators
Caravan Equipment REFRIGERATORS Winter Operation - Thetford and Electrolux Refrigerators ▲ Please check that the ventilation grilles or the flue outlets are not blocked by snow, leaves etc. Your caravan is supplied with winter covers as standard equipment. These covers should be fitted when the outside temperature is below 10°C. -
Page 57: Operation
Caravan Equipment ● Keep the button (D) pressed for a further 10 to 15 seconds then release it. The flame, which should be blue, can be seen through the sight glass (inside the refrigerator bottom left hand corner). ● To terminate gas operation turn knob (D) to ‘•’. 4.10.2 230v Operation ●... -
Page 58: Electrolux Refrigerator Model Rm 7291
Caravan Equipment 4.11 ELECTROLUX REFRIGERATOR MODEL RM 7291 4.11.1 Cleaning Before using the refrigerator, it is advisable to clean the appliance both inside and out. ● Use a soft cloth and lukewarm water with a mild detergent. ● Then rinse the appliance with clean water and dry thoroughly. ●... -
Page 59: Energy Selection
Caravan Equipment 4.11.4 Energy Selection 12V Electrical Operation (DC) ▲ The refrigerator should only be used while the motor is running, otherwise the on-board- battery would be discharged within a few hours! 1. Set energy selector switch (A) to 12V. 3. -
Page 60: Temperature Setting Cooling Compartment
Caravan Equipment ▲ Gas Faults In the event of a gas fault (e.g. gas cylinder empty), the operating display (C) flashes yellow. Remedies: Set the energy selector switch (A) to position “OFF”. 1. Is there any gas in the gas bottle? 2. -
Page 61: Storing Food
Caravan Equipment 4.11.6 Storing food ● Always store food in sealed containers, aluminium foil or similar. ● Never put hot food into the refrigerator, always let it cool down first. ● Products that could emit volatile, flammable gases must not be stored in the refrigerator. ●... -
Page 62: Positioning The Storage Rack
Caravan Equipment 4.11.9 Positioning the storage rack Dismantling: 1. Loosen the front and back securing 2. Move the storage rack to the left and remove it. brackets. To fit the storage rack, the reverse order applies. 4.11.10 Door locking open close park-position / vent-position 4.11.12 Switching off... -
Page 63: Winter Operation
Caravan Equipment 4.11.13 Winter operation 1. Check that the ventilation grills and the extractor have not been blocked by snow, leaves or similar. ° 2. When the ambient temperature falls below +10 C, the optional winter covers should be fitted. This protects the unit from excessively cold air. -
Page 64: Troubleshooting
Caravan Equipment 4.11.15 Troubleshooting Before calling the authorised Service Department please check whether: ▲ The instructions in the section “Using the refrigerator” have been followed. ▲ The refrigerator is not tilted excessively. ▲ It is possible to operate the refrigerator with an available power source. Failure: The refrigerator does not work in gas operation mode. -
Page 65: Maintenance
Caravan Equipment 4.11.16 Maintenance ● Works on gas components and electrical installation may only be carried out by authorised personnel. We recommend to contact your Dometic Service Centre. ● EN 1949 stipulates that the appliance’s gas equipment and its associated fume system must be inspected after installation and a certificate issued. -
Page 66: Thetford Refrigerator Model N100
Caravan Equipment 4.12 THETFORD REFRIGERATOR MODEL N100 4.12.1 Switching on the refrigerator ● Clean the inside of the refrigerator before you switch it on. ● Let the refrigerator cool for at least eight hours before you place food in it for the first time. ●... -
Page 67: Power With Gas
Caravan Equipment ● Mains voltage (230 V): set the power selector switch (A) to ● Set the temperature by means of the thermostat, rotary switch (B). Position 5 is the coldest temperature setting. Open the valve of the gas bottle and the gas taps. Set the gas control button to the 5th position. Set the energy source selector switch (A) to Ignite the gas flame: 4.12.4 Power with gas 1 Open the valve of the gas bottle and the gas taps. -
Page 68: Door Locking Mechanism
Caravan Equipment 4.12.7 Door locking mechanism The refrigerator door has an automatic locking mechanism. The door locks automatically when you press it shut firmly. The lock releases unnoticed when you open the refrigerator with your hand. This automatic locking mechanism also keeps the refrigerator door shut during driving. For some models an additional security device is fitted below the refrigerator. -
Page 69: The Thetford Cassette C-200 Cw / Cwe
Caravan Equipment 4.14 THE THETFORD CASSETTE C-200 CW / CWE The unit consists of two sections, a permanently installed toilet system and a slide out waste holding tank. The toilet section of the C-200 CW includes a rotatable bowl, removable seat and cover, a console with flush handle, a built in flush water tank and a waste level warning indicator. - Page 70 Caravan Equipment 4-30...
-
Page 71: Operation
Caravan Equipment vii. Open the water fill door and add 50ml. of Aqua Rinse. This results in a better flush and improves the hygiene of the toilet. Then fill the tank with fresh water using a jerry can or hose. Tank Capacity is 7 litres (fig.7). -
Page 72: Winterising / Storage
Caravan Equipment Cassette toilet: Use Thetford Bathroom cleaner or diluted washing-up liquid to clean the bowl, seat and cover and the outside of the toilet. When the toilet is not going to be used for a long time, leave the cap off the pour-out spout and leave the blade open so the cassette can dry. -
Page 73: The Alko Caravan Chassis
Caravan Equipment 4.16 THE ALKO CARAVAN CHASSIS 4.16.1 Chassis members The recommended tow vehicle coupling height is 415 +/- 35mm from the ground to the centre of the ball. Manufactured from high quality steel, the chassis has extra deep sections to provide strength at points of maximum stress. -
Page 74: Operation : Type Ak 10/2 - Ak 300 Coupling Head
4.16.8 Brake drum/hub assembly The Euro Axle fitted to your Bailey caravan comes complete with maintenance-free wheel bearings greased and serviced for life. Adjustment is not required during the design life of the sealed bearing (100,000 km). -
Page 75: Stabiliser Unit
Caravan Equipment 4.16.11 Stabiliser Unit: 2) To operate the Stabiliser (once coupled to the towball), simple press the stabiliser lever down as far as it will go (Fig. 4/Item 2). 4.16.12 Uncoupling 1) Pull the stabiliser lever handle up as far as it will go, open the coupling handle and lift the AKS2004 from the towball. -
Page 76: Noises Whilst Driving
Caravan Equipment down by hand force only DO NOT use your foot or an extension bar, this will damage the components (Fig. 6). 3) When opening or closing the stabiliser lever, please ensure your hand does not touch the coupling handle - you may accidentally trap your fingers! (Fig. -
Page 77: Jockey Wheel
Caravan Equipment 4.16.20 Jockey wheel Lubricate wheel and screw thread periodically with grease. 4.16.21 Brake linkage All moving parts should be lubricated periodically to ensure their satisfactory operation. 4.16.22 Corner steadies The screw and pivot pins should be lubricated periodically to ensure their satisfactory operation. 4.16.23 Braking system adjustment (At 500 miles, then every 3,000 miles or 1 year) Ensure the towing shaft with coupling heads... - Page 78 Caravan Equipment Check the brake rod support bracket, (fixed to the floor) is supporting the brake rod evenly. The brake rod must always run straight, never bent or curved under any fittings. On tandem axles, using the double balance bar, a brake rod support tube (Part No.
-
Page 79: Chassis Lubrication Points
Caravan Equipment ▲ In order to operate the Al-Ko braking system correctly adequate traction of caravan wheels is required when reversing. Therefore surface conditions that would result in a lack of traction should be avoided. Example: Peas, shingle/loose gravel. ▲ Care should be taken when traversing ramps or other obstacles in order to prevent damage to the caravan under gear. -
Page 80: Cleaning
Caravan Equipment Using the lower bar finger grip gently pull the screen downwards and around the curve towards the closed section of the door. Push firmly and the bar will clip onto and guide the screen back to the top position. -
Page 81: Bad Weather Setting
Caravan Equipment 4.19.4 Bad weather setting The handle/lock may be locked into the centre recess of the holder screwed into the frame. The cover is then open 15mm. Rain cannot enter nor can the wind raise the cover further. 4.19.5 Cleaning Use a damp cloth, and if necessary, a normal household cleaner without abrasives or solvents. -
Page 82: Retensioning
Caravan Equipment 4.21.1 Retensioning 4.22.3 Alarm Keypad - IDM3 REMIflair blinds are delivered with the correct amount of tension in the spring. However, it may be necessary in the future to adjust the spring. On the left hand side of the cassette you will find two tensioning screws. -
Page 83: Changing The Siren-On Time
Caravan Equipment 4.22.7 Changing the Siren-on Time 1. Press “F”, press “3”. 2. Enter your personal code, 3. Enter the preferred time as 3 digits, i.e. 2 minutes is entered 200, (please note the maximum time allowed is 4 minutes, i.e. 400) 4. -
Page 84: Testing
Caravan Equipment 2. If all indicators flash twice the system has been quiet. 3. If any indicator flashes 5 times, the corresponding sensor has been active. 4. A random flashing of indicators followed by 5 flashes for sensor(s) means that the system has had to reset (i.e. -
Page 85: Testing The Pir
Caravan Equipment 4.22.15 Testing the PIR 1. Press “F”, press “6”. 2. Walk in front of the PIR. The light on the keypad marked PIR will illuminate five times, and give a audible signal. 4.22.16 Testing the Siren 1. Press “F”, press “7”. 2. -
Page 86: Clearing The System Back To Manufacturers Settings
Caravan Equipment 4.22.20 Clearing the System back to Manufacturers Settings If for any reason you wish to set the IDM back to its factory settings then the following procedure should be used: 1. Press “F”, keep finger on the “F” key until 5 bursts are heard from the keypad buzzer. The IDM has now reverted to factory settings. -
Page 87: General Maintenance
▲ Under no circumstances use any abrasive agents, methylated spirit, white spirit, other solvents or washing up liquid to the exterior of your caravan. ▲ No touch up painting should be carried out prior to consulting with a Bailey Service Centre for approved methods. -
Page 88: Mattresses
General 5.1.4 Mattresses Mattresses are made from fire retardant fabric and are C.M.H.R. foam filled. Cotton print cushion covers are removable for dry cleaning only. (Zips along back edge.) It is recommended that mattresses be stored on edge during winter. 5.1.5 Care of your upholstery In the manufacturing of the fabrics used on the soft furnishings of your caravan a silicone coating is... -
Page 89: Guidance On Cleaning Portable Water Tanks And The Water System And In Touring Caravans
General ▲ Domestic cleaning products are not to be used to clean the shower/vanity unit plastic items. 5.1.9 Guidance on Cleaning Portable Water Tanks and the Water System and in Touring Caravans The water systems, and in particular storage tanks, in caravans are susceptible to contamination by bacteria if care is not taken with their use and cleaning. -
Page 90: Fire And Safety Precautions
General Suitable sterilising chemicals are available from your caravan dealer, accessory shop, chemists or home-brew shops. It is not, however, recommended to use bleach or sodium metabisulphite. This guidance has been prepared with the kind co-operation and assistance of The Environmental Health Department of The Borough Council of King’s Lynn and West Norfolk. -
Page 91: Petrol/Diesel Fumes
General ▲ Under no circumstances should the caravan ventilation be covered, blocked or tampered with in any way. 5.2.5 Petrol/Diesel Fumes The fitting of a tail pipe deflector to your exhaust will reduce the possibility of fumes entering your caravan through the front fixed ventilation points. However, an extension fitted to an exhaust tail pipe will be illegal if it projects excessively beyond the vehicle body or bumper. -
Page 92: Assembling The Bunks
General ASSEMBLING THE BUNKS... -
Page 93: Lift Up Bunk
General 5.3.1 Lift up Bunk Remove cushions and draw the curtains and close the blind if fitted. ii/iii. Holding bunk in both hands pull it inwards whilst lifting upwards. The bunk mechanism will automatically lock in the up position. Release retaining straps on the underside of bunk base. The second half of the bunk base can now be unfolded towards the caravan wall. -
Page 94: Water System - Fault Finding
General WATER SYSTEM - FAULT FINDING FAULT - Water not flowing from any tap when operated but pump runs 5.4.1 Cause Cure Freshwater tank empty Check Pump wired in reverse Check wiring, refer to pump manufacturers’ instructions Pump not primed Refer to pump manufacturers’... -
Page 95: Fault - Water Flows From Hot Tap But Has Reduced Flow From Cold
General 5.4.4 FAULT - Water flows from hot tap but has reduced flow from cold Cause Cure Cold water pipe kinked preventing flow Check and re-route if necessary Blockage in cold pipe line Disconnect pipes after 1st Y connector and check up to tap Cold tap not connected Refer to installation instructions... -
Page 96: Fault - Water Heater Pressure Relief Valve Venting Water
General 5.4.8 FAULT - Water Heater pressure relief valve venting water Cause Cure Pressurised water system pump switching Refer to water supply note pressure too high Switched tap water system pump flow rate Refer to water supply note is greater than tap flow rate capacity 5.4.9 FAULT - Water heater difficult to drain Cause... -
Page 97: Room Heater - Fault Finding
General ROOM HEATER - FAULT FINDING FAULT - Heater will not light 5.5.1 Symptoms Cause Cure Spark visible No gas. Bottle temperature too low Check bottle and taps. See gas supply notes. Regulator malfunction. See gas supply notes. Overgassed. Refer to lighting instructions. -
Page 98: Brake Fault Finding Chart - Al-Ko
General BRAKE FAULT FINDING CHART - AL-KO FAULT - Braking is one-sided 5.6.1 Cause Cure Incorrect adjustment at wheel. Adjust as described. Brake cable seized. Free off cable or replace. Brake lining contaminated with grease. Replace brake shoe assemblies. 5.6.2 FAULT - The trailer brakes during mild decelerations Cause Cure... -
Page 99: Fault - Trailer Brakes Inoperative
General 5.6.6 FAULT - Trailer brakes inoperative Cause Cure Brakes underadjusted. Check action and rectify. Lining contamination. Replace brake shoe assemblies. Seized cables. Free off or replace. Linings worn out. Replace brake shoe assemblies. 5.6.7 FAULT - Hot brakes Cause Cure Brakes overadjusted. - Page 100 Index Alarm 4-42 Safety 1-5 Arming/Disarming the System 4-43 Smoke Alarm 4-15 Space Heater 4-6 Blinds, window 4-41 Bunks, assembling 5-6 Toilet Thetford Cassette C-200 CW/CWE 4-29 Towing 2-8 Tyres 2-10 Caravan and towing vehicle terms 2-1 Caravan Chassis 4-33 Braking adjustment 4-37 Manoeuvring 4-35 Ventilation 3-8...
- Page 101 Bailey Caravans, South Liberty Lane, Bristol BS3 2SS www.bailey-caravans.co.uk...