Antique Brick Panel Kit; Installation Instructions - Jøtul GI 450 DV Katahdin Installation And Operation Instructions Manual

CAUTION!
THE BRICK PANELS AND LOG PARTS ARE EX-
TREMELY FRAGILE. USE BOTH HANDS TO SUPPORT
EACH PIECE AS YOU HANDLE THEM.

Installation Instructions

1. Remove the Glass Frame. Disengage the two com-
pression latches located in the control compartment
and lift the frame off of the tabs at the top of the
firebox.
2. Remove the Andirons and Logset.
These parts are not fastened. Simply lift them out of
the firebox.
3. Remove the Cast Iron Side Panels.
Use a 10mm socket wrench to remove the retainer
brackets located at the rear corner of each panel. These
panels will not be reinstalled, however, you must replace
the two 6 mm bolts to plug the holes.
4. Install the Right Side Panel.
Position the panel bottom first against the firebox
wall and slide it forward against the firebox front.
5. Install the Lower Rear Panel.
Orient the panel so that the beveled edge is on top
and the mortar joints align with those on the side
panel. Engage the bottom edge with the cutout in
the side panel.
6. Install the Left Side Panel. Lift the lower panel up
enough to allow the side panel to clear it. Be sure to
push the side forward, up against the firebox front.
7. Install the Upper Rear Panel.
This will be a snug fit. Set the panel up high and then
carefully lower it to seat its bottom edge against the
top of the other rear panel. The side panels will hold it
in place.
8. Reinstall the Logset and Andirons.
Refer to the Owner's Manual if necessary.
9. Replace the Glass Frame.
First engage the top of the frame with the retainer tabs at
the top of the firebox. Seat the frame against the firebox
and pull the latches forward to engage with the slots in the
frame bottom.
24
T T T T T ools R ools Requir ools R ools R ools R equir equir equired: equir ed: ed: ed: ed: 10 mm socket wrench
Safety glasses and gloves
Kit Kit Kit C C C C Con on on ten tents ts ts ts ts ten
Kit Kit on onten ten
Upper Rear Panel, 220622
Left Side
Panel,
Lower Rear
220620
Panel, 220621
Figure 32. Brick Panel Identification
Figure 33. Install the Right Side Panel.
r r r r r
Figure 34. Install Lower Rear Panel.
Right Side
Panel,
220619