Jøtul GZ 550 DV II Acadia Installation And Operation Instructions Manual
  1. Manuals
  2. Brands
  3. Jøtul Manuals
  4. Indoor Fireplace
  5. GZ 550 DV II Acadia
  6. Installation and operation instructions manual
Jøtul GZ 550 DV II Acadia Installation And Operation Instructions Manual

Jøtul GZ 550 DV II Acadia Installation And Operation Instructions Manual

Direct vent gas fireplace
Hide thumbs Also See for GZ 550 DV II Acadia:
Table of Contents

Advertisement

Quick Links

f i r e - p a r t s . c o m
CAUTION: THESE INSTRUCTIONS ARE TO
REMAIN WITH THE HOMEOWNER.
WARNING: If the information in these
instructions is not followed exactly, a fire or
explosion may result causing property
damage, personal injury or loss of life.
Do not store or use gasoline or other
flammable vapors and liquids in the
vicinity of this or any other appliance.
WHAT TO DO IF YOU SMELL GAS:
• Do not try to light any appliance.
• Do not touch any electrical switch; do
not use any phone in your building.
• Immediately call you gas supplier from a
neighbor's phone. Follow the gas supplier's
instruction.
• If you cannot reach your gas supplier, call
the fire department.
Installation and service must be
performed by a qualfied installer, service
agency or the gas supplier.
In the Commonwealth of Massachusetts, a
carbon monoxide (CO) detector shall be
installed in the same room as the
appliance.
Installation and

Operation Instructions

ATTENTION : CES INSTRUCTIONS DOIVENT
DEMUERER AVEC LE PROPRIÉTERE D'UNE
MAISON.
AVERTISSEMENT: Assurez-vous de bien
suivreles instructions données dans cette
notice pour réduire auninimum le risque
d'incendie ou d'explosion ou pour éviter tout
dommage matériel, toute blessure ou la mort.
Ne pas entreposer ni utiliser d'essence ni
d'autres vapeurs ou liquides inflammables
dans le voisinage de cet appareil ou de tout
autre appareil.
QUE FAIRE SI VOUS SENTEZ UNE ODEUR
DE GAZ:
• Ne pas tenter d'allumer l'appareil.
• Ne touchez à aucum interrupteur. Ne pas
vous servir des téléphones se trouvant
dans le bâtiment où vous trouvez.
• Appelez immédiatement votre
fournisseur de gaz depuis un voisin. Suivez
les instructions du fournisseur.
• Si vou ne pouvez rejoindre le fournisseur
de gaz, appelez le service des incendies.
L'installatione l'entretien doivent être
assurés par un installateur ou un service
d'entretien qualifié ou par le fournisseur
de gaz.
Jøtul GZ 550 DV II
1

Advertisement

Table of Contents
loading

Related Manuals for Jøtul GZ 550 DV II Acadia

Summary of Contents for Jøtul GZ 550 DV II Acadia

  • Page 1: Operation Instructions

    Jøtul GZ 550 DV II Installation and Operation Instructions f i r e - p a r t s . c o m ATTENTION : CES INSTRUCTIONS DOIVENT CAUTION: THESE INSTRUCTIONS ARE TO DEMUERER AVEC LE PROPRIÉTERE D’UNE REMAIN WITH THE HOMEOWNER. MAISON.
  • Page 2 Jøtul GZ 550 DV II PLEASE READ THESE INSTRUCTIONS IN THEIR ENTIRETY AND MAKE THEM AVAILABLE TO ANYONE USING OR SERVICING THIS APPLIANCE. THIS FIREPLACE MUST BE INSTALLED AND MAINTAINED BY A QUALIFIED SERVICE AGENCY. IN THE COMMENWEALTH OF MASSACHUSETTS, THIS PRODUCT MUST BE INSTALLED BY A LICENSED PLUMBER OR GAS-FITTER.

  • Page 3: Table Of Contents

    Jøtul GZ 550 DV II Table of Contents Unpacking the Fireplace Specifications ........4 1. Before you remove the carton, remove the cast Installation / Service Tools .... 5 iron parts that are packed around the fireplace General Information ....... 5 cabinet.

  • Page 4: Specifications

    Jøtul GZ 550 DV II Jøtul GZ 550 DV II Acadia Direct Vent Gas Fireplace Manufactured and Distributed by: Jøtul North America Gorham, Maine U.S.A. Jøtul AS Fredrikstad, Norway Test Standards This appliance complies with Accepted For Use National Safety standards and is tested and listed by Intertek City of New York Dept.

  • Page 5: Installation / Service Tools

    Jøtul GZ 550 DV II General Information IMPORTANT: SAVE THESE INSTRUCTIONS. 1. The installation and repair of this appliance must 5. Do not operate the fireplace with the glass front be done by a qualified service person. Failure to removed, cracked or broken. Replacement of the properly install and maintain this heater could glass should be done by a licensed or qualified result in an unsafe or hazardous installation,...

  • Page 6: Safety Information

    Jøtul GZ 550 DV II Safety Information Installation Requirements This appliance and its vent system must be installed Due to the high operating temperatures this within a totally enclosed structure. The fireplace appliance should be located out of traffic and must be connected to the specified vent and termi- away from furniture, draperies, etc.
  • Page 7 Jøtul GZ 550 DV II Figure 1. Cabinet Dimensions. Figure 2. Minimum horizontal vent 25” allowance through wall. 635 mm 16 1/4” 410 mm Header / Wallboard 5/8 Vent Adaptor Standoff Height: 35 3/4” 35 3/4” 6” Vent 900 mm Section Wall Cutout : 4/6 Pipe - 10”x10”...

  • Page 8: Mantel Clearances

    Jøtul GZ 550 DV II Hearth Protection The GZ550 DV II Acadia is approved for installation Mantel and Trim Clearance without hearth protection. Combustible materials may be used on the floor directly under and in front of the fireplace. 12” 8 ”...

  • Page 9: Vent Requirements

    Jøtul GZ 550 DV II Vent Requirements This appliance is approved for use with direct vent components produced by the following manufactur- ers: • Simpson Dura-Vent Corporation, 5/8 and 4/6 pipe • Security Vent Ltd. International, 5/8 and 4/6 pipe •...

  • Page 10: Vertical Termination

    Jøtul GZ 550 DV II f i r e - p a r t s . c o m Figure 12. Vent Window for vertical termination Figure 13. Vent Window for offset vertical using 5/8 or 4/6 pipe. termination using 5/8 or 4/6 pipe. Vertical Termination Figure 14.

  • Page 11: Horizontal Termination

    Jøtul GZ 550 DV II Figure 15. Horizontal termination -5/8 pipe. Figure 16. Horizontal Termination - 4/6 Pipe. Minimum 1 ft. rise required. Horizontal Termination Clearance f i r e - p a r t s . c o m Figure 18.

  • Page 12: Vent Restrictor

    Jøtul GZ 550 DV II Fireplace Installation Variable Vent Restriction Optional Blower Vent restriction is accomplished by sliding a restrictor Install the optional Blower (155630) before installing panel over the combustion air intake ports located at the gas supply line. the back of the firebox.
  • Page 13 Jøtul GZ 550 DV II Final Cabinet Positioning 1. If appropriate, attach the 4/6 Vent Adaptor Collar: • Remove the 5/8 Collar supplied with the unit. • Align the 4/6 Collar as shown in fig. 23 and secure to the unit using the original screws. Remove the retainer screws.

  • Page 14: Gas Connection

    Jøtul GZ 550 DV II Connect the Gas Supply Leak test: • Mix a 50-50 solution of water and dish soap. Gas Supply Requirements • Light appliance- see lighting instructions on page ALL INSTALLATIONS MUST COMPLY WITH LOCAL 23 of this manual or on the fireplace’s rating plate. CODE OR IN THE ABSENCE OF LOCAL CODE, MUST •...

  • Page 15: High Altitude Adjustment

    Jøtul GZ 550 DV II THE DERATING KIT MUST BE INSTALLED BY The appliance must be isolated from the gas AN AUTHORIZED SERVICE TECHNICIAN IN ACCOR- supply line by closing its individual manual gas DANCE WITH THE MANUFACTURER’S INSTRUCTIONS shutoff valve (gas cock) during any pressure testing AND ALL CODES AND REQUIREMENTS OF THE of the gas supply piping system that is equal to or AUTHORITY HAVING JURISDICTION.

  • Page 16: Fuel Conversion

    Jøtul GZ 550 DV II Fuel Conversion This appliance is designed to for use with either Natural gas or Propane. It is shipped from the factory Conversion Kit Contents: configured to use Natural gas. A conversion kit is • 1 Regulator Tower labeled for Propane included for conversion to Propane use if desired.
  • Page 17 Jøtul GZ 550 DV II • • • • • FROM WITHIN THE FIREBOX, disengage the Pilot Hood by releasing the retainer clip as shown in fig. 32. Using the 4 mm hex key supplied, unscrew the pilot orifice (counter- clockwise).
  • Page 18 Jøtul GZ 550 DV II Slip the end of the tube into the Air Shutter and SLIDE TUBE FORWARD TO COMPLETELY COVER THE BURNER ORIFICE. See fig. 33. • Slide the shutter BACK to open the inlet, slide FORWARD to close. The standard settings are: Natural gas - 1/4”...

  • Page 19: Wall Thermostat

    Jøtul GZ 550 DV II Wall Thermostat Installation Remote Control Use Jøtul Thermostat #129706 or a The optional Jøtul Remote Control can be installed to automatically control on the Acadia gas fireplace. Using the wire supplied your fireplace operation. The thermostat should be with the remote, connect the remote directly to the placed in the same room as the heater, typically 5’...

  • Page 20: Antique Brick Kit

    Jøtul GZ 550 DV II Brick Panel Assembly Install the optional 155805 Brick Panels before placing the Logset. Place the panels in position in the order as numbered in fig. 37. No fasteners or Pull Frame Latches to Release Frame tools are required.

  • Page 21: Log Set Installation

    Jøtul GZ 550 DV II Logset Assembly Unpack and arrange the five logs as outlined below. 1. 1. 1. 1. 1. Seat Right Log (1) on the pin on the right side of the Burner Skirt. fig. 41. 2. 2. 2. 2. 2. Set Rear Log (2) on the pins at the rear of the Burner Skirt.

  • Page 22: Surround Assembly

    Jøtul GZ 550 DV II Surround Assembly 1. 1. 1. 1. 1. Cut and r and r emov v v v v e e e e e the plastic wir the plastic wir the plastic wire e e e e tie fr the plastic wir tie fr tie fr...

  • Page 23: System Check

    Jøtul GZ 550 DV II System Check 1. PURGING THE GAS LINE: When lighting the Flame Appearance / Air Shutter appliance for the first time it will take a few Adjustment moments to clear the gas line of air. Once this purge is complete, the appliance will operate as THE ACADIA GAS FIREPLACE IS SHIPPED FROM THE described in the lighting instructions located on...
  • Page 24 Jøtul GZ 550 DV II Air Shutter Adjustment Stem Air Shutter Adjustment 1. Open the Lower Grill panel and locate the Air Shutter adjustment stem extending down from the right side of the firebox floor. See figs. 49. 2. Loosen the locknut and push the stem BACK (to the rear of the firebox) to open the air inlet increasing airflow into the burner.

  • Page 25: Operation

    Jøtul GZ 550 DV II Operation 1. Your Acadia gas fireplace can be operated manu- ally using the On/Off/T-stat rocker switch or it can be automatically controlled using an optional wall-mounted thermostat and/or remote control device. A separate switch is provided for the Pilot Assembly optional forced air blower kit.

  • Page 26: Maintenance

    Jøtul GZ 550 DV II Maintenance The Acadia gas fireplace and its venting system Glass Panel or Gasket Removal should be inspected before use and at least annually 1. Open the Lower Grill Panel. by a qualified service technician. 2. Release the glass clips at either side of the bottom of the firebox.

  • Page 27: Service Log

    RETAIN THIS MANUAL FOR REFERENCE AND MAKE SERVICE LOG: IT AVAILABLE TO ANYONE USING OR SERVICING THE First Year FIREPLACE. Name of Technician________________________ MODEL NAME: Jøtul GZ 550 DV II Acadia Gas Fireplace Company Name____________________________ SERIAL NUMBER:__________________________ Date of service_____________________________ DATE OF PURCHASE:_______________________...

  • Page 28: Illustrated Parts Breakdown

    Jøtul GZ 550 DV II f i r e - p a r t s . c o m...

  • Page 29: Replacement Parts List

    Jøtul GZ 550 DVII Acadia Parts Jøtul GZ 550 DV II Surround Leg, Right / Matte Black 10395792 Surround Leg, Right / Blue Black 10395727 Description Part Number Surround Leg, Right / Jøtul Iron 10395785 Screw, #8 x 1/2 Sheet metal 117917 Surround Leg, Left / Matte Black 10395992...

  • Page 30: Accessories

    Jøtul GZ 550 DV II Optional Accessories • Antique Brick Kit ..........155805 • Variable Speed Blower, 125 / 60 c.f.m..155630 • 4” x 6-5/8” Adaptor Kit ........154974 • High Altitude Conversion Kit - NG ....155610 •...

  • Page 31: Lighting Instructions

    LIGHTING INSTRUCTIONS Jøtul GZ 550 DV II FOR YOUR SAFETY, READ BEFORE LIGHTING. WARNING: IF YOU DO NOT FOLLOW THESE INSTRUCTIONS EXACTLY, A FIRE OR EXPLOSION MAY RESULT CAUSING PROPERTY DAMAGE, PERSONAL INJURY, OR LOSS OF LIFE. A. A. A. A. A. This appliance has a pilot which must be lit •...
  • Page 32 Jøtul GZ 550 DV II This appliance must be installed in conformance with local and national building regulations. Before beginning the installation, it is important that the these instructions be carefully read and understood. Jøtul maintains a policy of continual product development. Consequently, products may differ in specification, color or type of accessories from those illustrated or described in various publications.

Table of Contents