TurboChef i3 Service Manual page 22

8 DAILY MAINTENANCE
A
Step 7
Step 8
Step 9
Step 10
Step 11
Step 12
Step 13
Step 7: Clean and Dry the Oven Door
CAUTION: DO NOT spray cleaner directly onto the oven door gasket (A) or
saturate it with water.
CAUTION: DO NOT scrub, scrape, or attempt to clean the oven door gasket (A).
Doing so may cause the door to not close properly, resulting in a non-warranty
service call.
- Clean the oven door with oven cleaner and a nylon scrub pad.
- Wipe the oven door with a damp towel.
Step 8: Rinse the Oven Interior
CAUTION: DO NOT use a hose or water jet for cleaning. Doing so can
damage critical oven components, resulting in a non-warranty service call.
- Rinse the oven interior with clean water.
- Thoroughly dry the oven interior with a clean towel.
Step 9: Apply TurboChef Oven Guard
- Spray Oven Guard onto a clean towel.
- Wipe the oven's interior walls and the inside of the oven door.
CAUTION: DO NOT apply Oven Guard to the oven door gasket. Doing so
may damage the gasket, resulting in a non-warranty service call.
Step 10: Reinstall Components
- Reinstall the lower air diverter.
- Reinstall the lower jetplate. Screw in the two thumb screws to lock the lower
jetplate in place.
- Reinstall the wire rack and close the oven door.
Step 11: Clean the Drain Pan
- Remove the lower front panel.
- Remove the drain pan entirely from the bottom of the oven.
- Wipe down* the inside of the area the drain pan fits within.
- Empty, clean, and reinstall the drain pan.
- Reinstall the lower front panel.
Step 12: Clean the Oven Exterior
- Wipe the oven exterior with a clean, damp towel.
CAUTION: DO NOT spray chemicals into any openings, such as the louvers
on the side panels or the rear vent catalyst housing. Doing so can damage
critical oven components, resulting in a non-warranty service call.
Step 13: Clean the Air Filter (once per week)
- Remove the air filter from the back panel.
- Gently wash by hand in the sink or rinse with hot water.
CAUTION: DO NOT use a water jet. Doing so will shorten the life of the filter.
- Reinstall the air filter, or replace it if large holes are present or if the mesh is
becoming detached from the frame.
CAUTION: DO NOT operate the oven without the air filter in place.