Toshiba RAV-SM564UT-E Service Manual page 132

Toshiba SDI / DI tuotteiden jälleenmyyjä pääkaupunkiseudulla on Jäähdytinpalvelu RefGroup Oy.
[P12 error]
Turn off the power.
Is there no connection error or
disconnection on connectors CN333
and CN334 of indoor unit P.C. board
(MCC-1570)?
NO
Remove connectors CN333
and CN334 of indoor unit P.C. board
(MCC-1570).
Does the fan rotate without trouble
when handling the fan with hands?
YES
Are resistance values
between phases at fan motor connector
CN333 motor side of indoor P.C. board
(MCC-1570) correct?
Correct
∗1
• Are not coil windings between
• Is not grounded between cabinet and
Is resistance value of
fan motor connector CN334 motor side
of indoor P.C. board
(MCC-1570) correct?
∗2
Correct
Resistance value confirmation of the fan motor position detection circuit
Is not status between
→ The resistance should be approx. 5k to 20kΩ.
Is output of
indoor fan motor position
detection signal correct?
∗3
YES
Confirmation of the fan motor position detection signal
• Using a voltage tester, measure voltage between CN334
• Between
YES
NO
Incorrect
∗1
S
U
between (White lead) and
between (Black lead) and
→ The resistance should be the resistance value below.
SM40, SM45 → Approx. 70 to 100Ω
Incorrect
∗2
Q
(Yellow lead) and
NO
∗3
(MCC-1570) under condition that CN333 and CN334 are mounted and the power supply is turned on.
→ When rotating the fan slowly with hands, the pin voltage should shake between 0 and 5V.
R S
and : 5V
www.ilmalämpöpumput.com
Correct connection
of connector.
Replace indoor fan motor.
Q S
U
(Red lead) and (White lead),
Q
(Black lead),
(Red lead) opened or shorted?
Q S U
. → It should be 10MΩ or more.
, ,
R
(Pink lead) opened or shorted?
– 132 –
<In case of SP40, SP45>
CN333
Replace indoor fan motor.
Replace indoor fan motor.
Replace indoor fan motor.
Q S
and on the indoor P.C. board
Check indoor P.C. board
(MCC-1570).
Defect → Replace
CN334