Regency C34 Classic Owners & Installation Manual
Direct vent freestanding gas stove
Hide thumbs
Also See for C34 Classic:
- Owners & installation manual (60 pages) ,
- Brochure & specs (8 pages) ,
- Owners & installation manual (48 pages)
Table of Contents
Advertisement
Freestanding Gas Stove
WARNING:
If the information in these instructions are not followed ex-
actly, a fi re or explosion may result causing property damage,
personal injury or loss of life.
FOR YOUR SAFETY
Do not store or use gasoline or other fl ammable vapors and
liquids in the vicinity of this or any other appliance.
Installation and service must be performed by a qualifi ed
installer, service agency or the gas supplier.
Tested by:
918-512a
FPI FIREPLACE PRODUCTS INTERNATIONAL LTD. 6988 Venture St., Delta, BC Canada, V4G 1H4
C34 Classic Direct Vent
MODELS:
C34-NG3 Natural Gas
Installer: Please complete the details on the back cover
and leave this manual with the homeowner.
Homeowner: Please keep these instructions for future reference.
Classic C34 model shown above features optional
gold plated door and gold legs.
www.regency-fi re.com
C34-LP3 Propane
FOR YOUR SAFETY
What to do if you smell gas:
Do not try to light any appliance
Do not touch any electrical switch:
do not use any phone in your build-
ing.
Immediately call your gas supplier
from a neighbour's phone. Follow
the gas supplier's instructions.
If you cannot reach your gas sup-
plier, call the fi re department.
Owners &
Installation Manual
04/12/11
Advertisement
Table of Contents
Related Manuals for Regency C34 Classic
Summary of Contents for Regency C34 Classic
- Page 1 C34 Classic Direct Vent Owners & Freestanding Gas Stove Installation Manual Classic C34 model shown above features optional gold plated door and gold legs. www.regency-fi re.com MODELS: C34-NG3 Natural Gas C34-LP3 Propane WARNING: FOR YOUR SAFETY If the information in these instructions are not followed ex- What to do if you smell gas: ...
- Page 2 To the New Owner: ® Congratulations! You are the owner of a state-of-the-art Gas Stove by Fireplace Products International Ltd. The Regency Gas Series of hand crafted appliances has been designed to provide you with all the warmth and charm of a woodstove, at the fl ick of a switch.
- Page 3 INFORMATION FOR MOBILE/MANUFACTURED HOMES AFTER FIRST SALE ® This Regency product has been tested and listed by Warnock Hersey as a Direct Vent Room Heater to the following standards: CAN/CGA-2.17- M91, ANSI Z21.88a-2007/CSA 2.33a-2007. This Direct Vent System Appliance must be installed in accordance with the manufacturer's installation instructions and the Manufactured Home Construction and Safety Standard, Title 24 CFR, Part 3280, or the current Standard of Fire Safety Criteria for Manufactured Home Installations, Sites, and Communities ANSI/NFPA 501A, and with CAN/CSA Z240-MH Mobile Home Standard in Canada.
- Page 4 DIMENSIONS ® Regency CLASSIC C34-3 Direct Vent Freestanding Gas Stove...
-
Page 5: Table Of Contents
Converting Class-A Metal Chimney WARRANTY or Masonry Chimney to Direct Vent System ....26 System Data ..............28 Warranty ..............43 Gas Connection ............28 High Elevation .............28 Gas Pipe Pressure Testing ..........28 Installation of the DC Sparker........29 ® Regency CLASSIC C34-3 Direct Vent Freestanding Gas Stove... -
Page 6: Safety Label
SAFETY LABEL This is a copy of the label that accompanies ® NOTE: Regency units are constantly being each CLASSIC Direct Vent Freestanding Gas improved. Check the label on the unit and if Stove. We have printed a copy of the contents there is a difference, the label on the unit is here for your review. -
Page 7: Requirements
(e) A copy of all installation instructions for all Product Approved side wall horizontally vented gas fueled equipment, all venting instructions, all parts lists for venting instructions, and/or all venting design instructions shall remain with the appliance or equipment at the completion of the installation. ® Regency CLASSIC C34-3 Direct Vent Freestanding Gas Stove... -
Page 8: Installation
SERIOUS HOUSE FIRE. CHILDREN AND ADULTS SHOULD BE ALERTED TO THE HAZARDS OF HIGH SURFACE TEMPERATURES, ESPE- CIALLY THE FIREPLACE GLASS, AND SHOULD STAY AWAY TO AVOID BURNS OR CLOTHING IGNITION. ® Regency CLASSIC C34-3 Direct Vent Freestanding Gas Stove... -
Page 9: Important Message
State of Cali- used to install and provide mainte- fornia to cause cancer, birth defects or other reproductive harm. nance of this appliance. ® Regency CLASSIC C34-3 Direct Vent Freestanding Gas Stove... -
Page 10: Installation Checklist
2) Ensure proper grounding using the #8 ground lug provided. See "Optional Fan Installation" section. 3) Appliance must be anchored to the fl oor. See "Pedestal Assembly" & "Leg and Bottom" sections. ® Regency CLASSIC C34-3 Direct Vent Freestanding Gas Stove... -
Page 11: Optional Fan Installation
See diagram Diagram 1 Diagram 4 Caution: Ensure that the wires do not touch any hot surfaces. Note: The #8 ground lug is a dedicated ground for mobile home use only. ® Regency CLASSIC C34-3 Direct Vent Freestanding Gas Stove... -
Page 12: Pedestal Assembly
See diagram above. Anchoring Brackets Hold Down 4) Loosen the screws of the nutserts. ® 4) Push the Regency logo into the two holes Package Part# 846-585 in the front bottom left corner of the pedestal 5) Remove the fan assembly from the key slots cover plate. -
Page 13: Venting Introduction
1) Wear gloves and safety glasses for protec- tion. 2) Exercise extreme caution when using lad- ders or on roof tops. 3) Be aware of electrical wiring locations in walls and ceilings. ® Regency CLASSIC C34-3 Direct Vent Freestanding Gas Stove... -
Page 14: Exterior Vent Terminal Locations
* Clearance in accordance with local installation codes and the requirements of the gas supplier 3 feet (91cm) within a height of 15 feet (4.5m) above the meter / regulator assembly 3 feet (91cm) above - if within 10 feet (3m) horizontally ® Regency CLASSIC C34-3 Direct Vent Freestanding Gas Stove... -
Page 15: 4" X 6-5/8" Rigid Pipe Cross Reference Chart
46DVA-ES (N/A - FPI) 4DT-OS SV4SU Wall Thimble-Black 46DVA-WT 4DT-WT 4DWT 4DWT SV4RSM TE-4DE90 Wall Thimble Support/Ceiling Support 46DVA-DC SV4PF TE-4DE90B Firestop Spacer 46DVA-FS 4DT-FS 4DFSP 4DFS SV4BF Trim Plate-Black 4DT-TP 4DFPB 4DCP SV4LA ® Regency CLASSIC C34-3 Direct Vent Freestanding Gas Stove... - Page 16 Never allow the vent to run downward - this could cause high temperatures and may present a possible fi re hazard. Regency Fireplace Products . 6988 Venture St. . Delta, BC . Canada . V4G 1H4 . 604-946-5155 . www.regency-fi re.com ®...
-
Page 17: Rigid Pipe Venting Systems
Metal Products Ameri Vent Direct Vent, Security Secure Vent , Selkirk Direct-Temp. AstroCap is a proprietary trademark of FPI Fireplace Products International Ltd. Dura-Vent® and Direct Vent are registered and/or proprietary trademarks of Simpson Dura-Vent Co. Inc. ® Regency CLASSIC C34-3 Direct Vent Freestanding Gas Stove... -
Page 18: Venting Arrangements
Offset to Vertical Vent. A 15 ft. vertical run with 4 ft. horizontal offset distance falls within the shaded area and is an allowable installation with Vent Restrictor Position "R" (Right). ® Regency CLASSIC C34-3 Direct Vent Freestanding Gas Stove... - Page 19 7' Max. 5' Min. between 90 elbows is 5' Min. 8' Max. 6' Min. required. Lengths do not include elbow indicated. Vent restrictor position C (fully open), refer to "Vent Restrictor Position" section ® Regency CLASSIC C34-3 Direct Vent Freestanding Gas Stove...
-
Page 20: Dv Stove Horizontal Vent Kit
Be sure to check vent termina- have to be cut. tion area after snow falls, and clear to prevent accidental blockage of venting ® Regency CLASSIC C34-3 Direct Vent Freestanding Gas Stove... - Page 21 Note: pilot holes will need the 4" dia. fl ex liner. Mill-Pac. All outer joints may be to be drilled through the wall thimble on all sealed with high temperature sili- 4 corners. cone. ® Regency CLASSIC C34-3 Direct Vent Freestanding Gas Stove...
-
Page 22: Dura-Vent Termination Kit
Security Secure Vent ® , Selkirk Direct-Temp. AstroCap is a proprietary trademark of FPI Fireplace Products International Ltd. Dura-Vent® and Direct Vent are registered and/or proprietary trademarks of Simpson Dura-Vent Co. Inc. ® Regency CLASSIC C34-3 Direct Vent Freestanding Gas Stove... -
Page 23: Dura-Vent Horizontal Installations
Horizontal Termination. NEVER install Hint: Apply silicone to female end. the snorkel upside down. b) Horizontal runs of vent must be sup- ported every three feet. Wall straps are available for this purpose. ® Regency CLASSIC C34-3 Direct Vent Freestanding Gas Stove... -
Page 24: Vertical Termination
Note: If an offset is necessary in the attic to mark the spot where the vent will penetrate avoid obstructions, it is important to ® Regency CLASSIC C34-3 Direct Vent Freestanding Gas Stove... -
Page 25: Cathedral Ceilings
Any occupied areas above the fi rst fl oor, to the correct height as determined by the including closets and storage spaces, table and diagram below. through which the vertical vent passes, must be enclosed. ® Regency CLASSIC C34-3 Direct Vent Freestanding Gas Stove... -
Page 26: Converting Class-A Metal Chimney Or Masonry Chimney To Direct Vent System
Diagram 1 Diagram 5 ® Regency CLASSIC C34-3 Direct Vent Freestanding Gas Stove... - Page 27 fl ashing as needed to fi t chimney. Diagram ® Regency CLASSIC C34-3 Direct Vent Freestanding Gas Stove...
-
Page 28: System Data
6) When fi nished reading manometer, turn off the gas valve, disconnect the hose and tighten the screw (clockwise) with a 1/8" fl at screwdriver. Screw should be snug, but do not over tighten. ® Regency CLASSIC C34-3 Direct Vent Freestanding Gas Stove... -
Page 29: Installation Of The Dc Sparker
Box by opening the battery compartment. NOTE: The battery in the DC Sparker Box will need to be replaced annually. With Bottom Shield: Battery Compartment 3) Attach the Piezo Ignition wire to the DC Sparker box. ® Regency CLASSIC C34-3 Direct Vent Freestanding Gas Stove... -
Page 30: Log Installation
(Use Extreme Caution and ensure proper the log facing the back of the unit. Carefully 2) The securing bracket keeps the door light off of burner.) push the log down onto the pins. See diagram closed. ® Regency CLASSIC C34-3 Direct Vent Freestanding Gas Stove... -
Page 31: Door Handle
fi ring rate (rate noted on label) at 15 minutes. wires ® Use the Regency Remote Control Kit approved for this unit. Use of other systems may void 2) If required, adjusting the primary air to ensure your warranty. -
Page 32: Wiring Diagrams
Do not cut or remove the grounding prong from this plug. NATURAL GAS Units and Units Equipped with DC Spark Boxes ® Regency CLASSIC C34-3 Direct Vent Freestanding Gas Stove... - Page 33 *For installation of the DC Spark Box refer to instructions in this manual. CAUTION: Label all wires prior to disconnection when servicing controls. Wiring errors can cause improper and dangerous operation. ® Regency CLASSIC C34-3 Direct Vent Freestanding Gas Stove...
-
Page 34: Operating Instructions
(it does not have to be touching the burner). adjust the fl ame height higher or lower. wait for purging. Note: If you have an incorrect fl ame pat- ® tern, contact your Regency dealer for further instructions. SHUTDOWN PROCEDURE... -
Page 35: Copy Of The Lighting Plate Instructions
fl ame. The burner aeration is factory set Note: Aeration Adjustment should only be ® but may need adjusting due to either the local performed by an authorized Regency gas supply or altitude. Installer at the time of installation or service. -
Page 36: Maintenance Instructions
The pilot light generates enough heat to burn by a qualifi ed fi eld service person, to ensure someone. If for any reason a log should need that the fl ow of combustion and ventilation replacement, use only Regency ® replacement air is not obstructed. -
Page 37: Gold-Plated Doors
In the event that you break your glass INSTALLING by impact, purchase your replacement glass from VALVE ASSEMBLY ® an authorized Regency dealer only. 1) To install a new valve assembly, reverse instructions for removing valve. See as- sembly steps 1-10. -
Page 38: Parts List
Air Baffl e Plate Capscrew 1/4 x 1-3/4" NC Upper Air Passage Assembly 490-081 Flue Restrictor 490-520 Top Assembly 490-042 Rear Panel 918-512 Manual *Not available as a replacement part. FAN ASSEMBLY (OPTIONAL) DOOR ® Regency CLASSIC C34-3 Direct Vent Freestanding Gas Stove... -
Page 39: Burner Assembly & Log Set
Defl ector-Top Rear Log - LP 490-932 Complete Log Set Front Log Rear Log Top Log 902-151 Ember 902-153 Rockwool 904-537 Gas Inlet Pipe (12") *Not available as a replacement part. ® Regency CLASSIC C34-3 Direct Vent Freestanding Gas Stove... -
Page 40: Base Options
PARTS LIST BASE OPTIONS Part # Description Part # Description 490-926 Complete Pedestal 490-921 Complete Floor Shield 100) 948-216 Regency® Logo 100) 948-216 Regency ® Logo 102) 904-257 Magnetic Catch (Large) 102) 904-257 Magnetic Catch (Large) 103) 11" Pedestal Hinge 103) 11"... - Page 41 NOTES ® Regency CLASSIC C34-3 Direct Vent Freestanding Gas Stove...
- Page 42 NOTES ® Regency CLASSIC C34-3 Direct Vent Freestanding Gas Stove...
-
Page 43: Warranty
It is the general practice of FPI to charge for larger, higher priced replacement parts and issue credit once the replaced component has been returned to FPI and evalu- ated for manufacturer defect. The authorized selling dealer is responsible for all in-fi eld service work carried out on your Regency product. FPI will not be liable for results or costs of workmanship from unauthorized service persons or dealers. - Page 44 Dealer Name & Address: ______________________________________________ ___________________________________________________________________ Installer: ___________________________________________________________ Phone #: ___________________________________________________________ Date Installed: ______________________________________________________ Serial No.: __________________________________________________________ Regency and Classic are trademarks of FPI Fireplace Products International Ltd. Printed in Canada © Copyright 2011, FPI Fireplace Products International Ltd. All rights reserved.