Horizon Fitness HORIZON CT5.0 User Manual page 5

P R E- ASSE MBLY
DO NOT ATTEMPT TO LIFT THE TREADMILL!*
WARNING
from packaging until specified to do so in the assembly instructions. Failure to do
so may result in injury! Remove plastic wrap from console masts.
NOTE:
During each assembly step, ensure that ALL nuts and bolts are in place and partially threaded in before
completely tightening any ONE bolt. NOTE: A light application of grease may aid in the installation of hardware.
Any grease, such as lithium bike grease is recommended.
AS SE MB LY ST EP 1 AS SE MB LY ST EP 1
HARDWARE BAG 1 CONTENTS :
LEFT CONSOLE MAST
WAVY WASHER (F)
FLAT WASHER (E)
BOLT (D)
LEFT LINKAGE ARM
BOLT (A)
FLAT WASHER
TEFLON WASHER
A Open HARDWARE BAG 1.
B Cut banding straps. Do not move or lift treadmill from packaging.
C Move LEFT LINKAGE ARM into position. Insert 1 BOLT (A) and 1 FLAT WASHER (B) into LEFT
LINKAGE ARM followed by 1 TEFLON WASHER (C) and attach to ELEVATION FRAME.
D Lift LEFT CONSOLE MAST into upright position. Be sure to hold the console mast firmly, as
it will not stay in the upright position on its own.
E Insert 1 BOLT (D) and 1 FLAT WASHER (E) through LEFT CONSOLE MAST followed by
1 WAVY WASHER (F) and attach to MAIN FRAME.

CT5.0_Rev.1.1.indd 8-9
Do not move or lift treadmill
BOLT (A) FLAT WASHER (B) TEFLON WASHER (C)
15 mm 20 mm 18 mm
Qty: 1 Qty: 1 Qty: 1
BOLT (D) FLAT WASHER (E) WAVY WASHER (F)
Qty: 1 27 mm 29 mm
Qty: 1 Qty: 1
MAIN FRAME
ELEVATION FRAME
(B)
(C)
ASSEMBLY STEP 2
HARDWARE BAG 2 CONTENTS :
BOLT (D) FLAT WASHER (E)
Qty: 1 27 mm
Qty: 1
MAIN FRAME
RIGHT FOLDING FRAME
LOCK LATCH PIN (G)
A Open HARDWARE BAG 2.
B Attach LOCK LATCH PIN (G) into RIGHT FOLDING FRAME using T-wrench and
tighten completely.
C Pull LEAD WIRE through RIGHT CONSOLE MAST. After pulling the LEAD WIRE through the
mast, the top of the CONSOLE CABLE should be located at the top of the mast. Detach and
discard LEAD WIRE.
D Continue STEP 2 on next page.
WAVY WASHER (F) LOCK LATCH PIN (G)
29 mm Qty: 1
Qty: 1
LEAD WIRE
RIGHT CONSOLE MAST
CONSOLE CABLES

6/3/08 8:39:36 AM