Service Schedule - Windsor chariot iSCRUB CS24 10060210 Operating Instructions Manual

MAINTENANCE

SERVICE SCHEDULE

MAINTENANCE
Check water level of batteries after charging;
add distilled water if necessary. (Wet cell only)
Check that dome and cover seal tightly.
Visually check for damaged or worn tires.
Check brushes or pads for proper installation.
Check vacuum hose connections.
Check that squeegee is securely attached and
properly adjusted.
Check for securely attached drain hoses, plug
and cap.
Check both pedals, brake and steering for
proper operation.
Clean out recovery tank and dome basket.
Clean and inspect float shutoff.
Clean out solution tank and filter, check flow.
Clean and inspect solution filter strainer.
Run vacuum motors to dry.
Clean brushes or pads and check wear.
Clean squeegee blades and check wear.
Clean outside of tanks, check for damage.
Store with dome off tank.
Charge batteries.
Clean off top of batteries.
Check battery cells with hydrometer. (Wet cell
only)
Inspect scrub deck skirts and Aqua-Mizers.
Clean solution strainer inside tank.
Check battery connections are tight.
Clean battery cases and battery compartment.
Clean and check drive tension chain for wear
and tension.
Check parking brake.
Clean chains, cables and pulleys for
squeegee lift.
Clean pivot points on squeegee and scrub
deck.
Check all motors for carbon brush wear.
Check motor commutators.
Check steering chain tensioner.
NOTE: Traction drive, wheels and batteries should be serviced based on traction drive hour meter
(Deluxe). The scrub brush hour meter should be used for all other service schedule items.
4-1
BEFORE EACH
WORK PERIOD
*
*
*
*
*
*
*
*
86037660 CHARIOT 11/09/06
AFTER EACH
WORK 50
PERIOD HRS
*
*
*
*
*
*
*
*
*
*
*
*
*
*
*
100 200
HRS HRS
*
*
*
*
*
*
*
*