Advertisement
Every 600 hours—Replace
the secondary air cleaner
element(Briggs engines)
(May need more often
under severe conditions.
See the Engine Owner's
Manual for additional
information.)
1.
Stop engine, wait for all moving parts to stop, and
remove key. Engage parking brake.
2.
See the Engine Owner's Manual for maintenance
instructions.
Check Air Filter Assembly (if
equipped)
Service Interval: As required
Important: To prevent engine damage, always
operate the engine with both air filters and cover
installed.
1.
When checking or replacing the air filter element,
make sure the air filter assembly is installed in the
brackets.
2.
Position the air cleaner cover so that the
breather valve does not interfere with the throttle
mechanism.
1. Air cleaner cover
2. Throttle mechanism
3.
Secure the cover with latches.
Figure 47
3. Breather valve
Change Kohler and Kawasaki
Engine Oil
Service Interval: After the first 5 hours
1.
Stop engine, wait for all moving parts to stop, and
remove key. Engage parking brake.
2.
Drain oil while engine is warm from operation.
3.
Remove dip stick. The oil drain hose is located on
right hand side of engine at the rear. Place pan
under machine to catch oil. Remove plug from
end of drain hose. Allow oil to drain.
4.
Replace the oil filter every other oil change. Clean
around oil filter and unscrew filter to remove.
Before reinstalling new filter, apply a thin coating
of Exmark 4–Cycle Premium Engine oil on the
surface of the rubber seal. Turn filter clockwise
until rubber seal contacts the filter adapter then
tighten filter an additional 1/2 to 3/4 turn.
5.
Clean around oil fill cover and remove cap. Fill to
specified capacity and replace cap.
6.
Use oil recommended in the Check Engine Oil
Level section. Do Not overfill. Start the engine
and check for leaks.
7.
Wipe up any spilled oil from engine deck
mounting surfaces.
Change Briggs EFI Engine
Oil
Service Interval: Every 500 hours (May need
1.
Stop engine, wait for all moving parts to stop, and
remove key. Engage parking brake. Disconnect
the spark plug wire and keep it away from the
spark plug.
g016165
2.
Drain oil while engine is warm from operation.
3.
Remove dip stick from the oil tank.
4.
Turn and remove the oil drain cap. Located at the
bottom of the oil reservoir. Drain into approved
container (no hose included).
63
Maintenance
Every 100 hours/Yearly
(whichever comes first)
(May need more often
under severe conditions.)
more often under severe
conditions.)
Every 500 hours
Advertisement
