This appliance may be installed in an aftermarket,
permanently located, manufactured home (USA
only) or mobile home, where not prohibited by
local codes.
This appliance is only for use with the type of gas
indicated on the rating plate. A conversion kit is
available for the appliance.
Contents
Safety Alert Key ..................................................................................................................................................... 2
Introduction .......................................................................................................................................................... 2
Section A: Before You Begin ....................................................................................................................................................4
Installation Checklist ...................................................................................................................................................................4
Standard Installation Checklist ................................................................................................................................................5
Rating Plate Sample ....................................................................................................................................................................6
Section 1: Dimensions .......................................................................................................................................... 7
DelRay Square 42 Dimensions .................................................................................................................................................7
DelRay Square 46 Dimensions .................................................................................................................................................8
Section 2: Framing ................................................................................................................................................ 9
Wall framing Dimensions ..........................................................................................................................................................9
Corner framing.............................................................................................................................................................................9
Elevated surface temperatures ............................................................................................................................................10
Standard installation ................................................................................................................................................................10
Recess installation .....................................................................................................................................................................11
Full load Versions: .....................................................................................................................................................................12
Disable fans via remote ...........................................................................................................................................................12
Disable fans via harness ......................................................................................................................................................12
Example fireplace locations ....................................................................................................................................................13
Clearance to Sprinkler ..............................................................................................................................................................14
Clearances...................................................................................................................................................................................14
Section 3: Venting ............................................................................................................................................... 14
Restrictor plate ..........................................................................................................................................................................15
Flue collar ....................................................................................................................................................................................15
Section 3-3-1: Venting Layout ............................................................................................................................ 16
DRSQ42 5/8 TOP Venting - .....................................................................................................................................................16
Wall and roof termination .......................................................................................................................................................16
DRSQ42 Rear Venting ..............................................................................................................................................................17
45° Corner Installation 5''/8'' ..................................................................................................................................................17
DRSQ46 5/8 TOP Venting - .....................................................................................................................................................18
Wall and roof termination .......................................................................................................................................................18
DRSQ46 Rear Venting ..............................................................................................................................................................19
45° Corner Installation 5''/8'' ..................................................................................................................................................19
Section 3-2-1: Venting Layout ................................................................................................................................................20
Flexmaster as alternate venting ............................................................................................................................................24
Section 4: Wiring ................................................................................................................................................. 25
DRSQ (N/L) I Wiring Diagram ..................................................................................................................................................25
Installation of the wall switch .................................................................................................................................................25
DRSQ (N/L) I-2 Wiring Diagram ..............................................................................................................................................26
Installation of Electrical Supply ..............................................................................................................................................26
Fuel Type .....................................................................................................................................................................................27
Gas Pressure ..............................................................................................................................................................................27
Section 5-3: GAS CONNECTION .............................................................................................................................................27
Primary air adjustment ............................................................................................................................................................27
Section 6: Finishing ............................................................................................................................................. 28
Finishing Around the Fireplace ..............................................................................................................................................28
DRSQ42, DRSQ46 Mantels ......................................................................................................................................................28
Sidewall clearances ...................................................................................................................................................................29
Finishing Safety Zone ...............................................................................................................................................................29
Full load Versions: .....................................................................................................................................................................29
Disable fans via remote ...........................................................................................................................................................29
XG0232 - 043021
Young children should be carefully supervised when they are in the
same room as the appliance. Toddlers, young children, and others
may be susceptible to accidental contact burns. A physical barrier is
recommended if there are at-risk individuals in the house. To restrict
access to a fireplace or stove, install an adjustable safety gate to keep
toddlers, young children, and other at-risk individuals out of the room
Disable fans via harness ......................................................................................................................................................29
Cement Board Install ................................................................................................................................................................30
1" Adjustable trim kit ................................................................................................................................................................31
Removing the Screen ...............................................................................................................................................................32
Reinstalling the Screen ............................................................................................................................................................32
Removing the door ...................................................................................................................................................................32
Reinstalling the door ................................................................................................................................................................32
Airflow Bracket Installation .....................................................................................................................................................33
Propane Conversion ............................................................................................................................................ 34
Installing glass media ...............................................................................................................................................................36
(glass and stone) ........................................................................................................................................................................37
Split Oak Logset Installation ...................................................................................................................................................38
Birch Logset Installation 42 ....................................................................................................................................................39
Birch Logset Installation 46 ....................................................................................................................................................40
Driftwood Logset Installation 42 ...........................................................................................................................................41
Driftwood Logset Installation 46 ...........................................................................................................................................42
Black Reflective Glass ...............................................................................................................................................................43
Brick Liner Install .......................................................................................................................................................................44
Temperature Indication Display ............................................................................................................................................46
Turn On the Fireplace ..............................................................................................................................................................46
Turn Off the Fireplace ..............................................................................................................................................................46
Remote-Flame Control .............................................................................................................................................................46
Disabling Thermostat ...............................................................................................................................................................47
Fan Speed Control ....................................................................................................................................................................47
Accent Light Control .................................................................................................................................................................47
Pairing Issues ............................................................................................................................................................................48
Solution: ......................................................................................................................................................................................48
Disabling functions (Wi-Fi) .......................................................................................................................................................48
General ........................................................................................................................................................................................50
Cleaning .......................................................................................................................................................................................50
Pilot Burner Adjustment. .........................................................................................................................................................50
POD - Pilot on Demand ........................................................................................................................................ 51
What is POD and CPI mode? ..................................................................................................................................................51
Installing the CPI Jumper Cable..............................................................................................................................................51
DRSQ*I BASIC Exploded Parts ............................................................................................................................. 52
See through fireplace ...............................................................................................................................................................54
Notes ............................................................................................................................................................................................54
Single sided fireplace ...............................................................................................................................................................54
Appendix B: Warranty ......................................................................................................................................... 56
Appendix B: Warranty Continued ...................................................................................................................... 57
Appendix C: Amendment .................................................................................................................................... 58
General
CAUTION
and away from hot surfaces
3