Advertisement
MAINTENANCE
PERIODIC MAINTENANCE CHART
Always wear safety glasses or approved eye protection when servicing the
vehicle. Wear a full-face shield and gloves when working with or around
batteries and electrical connectors. Always use insulated tools when working
with or near batteries. Failure to follow these instructions could result in serious
Damage to electrical connections and components will occur if they are
unplugged before the main power connector is disconnected.
Before servicing the vehicle's electrical system, always disconnect the main
power connector first, then disconnect any electrical accessory connections,
then disconnect the negative cable from the 12-volt battery (if equipped), then
disconnect the negative terminal from the main battery pack. See page 37.
Careful periodic maintenance will help keep your vehicle in the safest, most
reliable condition. Inspect, clean, lubricate, adjust and replace parts as
necessary. When inspection reveals the need for replacement parts, genuine
GEM parts are available from your authorized GEM dealer.
Record maintenance and service in the Maintenance Log at the back of the
book.
Service and adjustments are important for proper vehicle operation. If you're
not familiar with safe service and adjustment procedures, your authorized
MONTHLY MAINTENANCE
Check battery fluid level (on flooded
batteries)
Wash tops and terminals of batteries
and allow to dry (flooded)
Check cables and terminal
connections
WARNING
injury or death.
NOTICE
WARNING
dealer can perform these operations.
TIP
MAINTENANCE
SEE
page 78
page 80
page 76
63
Advertisement
