1. Manuals
  2. Brands
  3. Nabco Manuals
  4. Door Opening System
  5. GT-1400
  6. Installation manual

Nabco GT1400 Installation Manual

Standard single/hurricane single folding door
Hide thumbs Also See for GT1400:
Table of Contents

Advertisement

Quick Links

Download this manual
Associated Manuals Part Numbers: Opus Control Wiring and Programming Manual; P/N C-00139
• Turn OFF all power to the Automatic Door if a Safety System is not working.
WARNING
• Instruct the Owner to keep all power turned OFF until corrective action can be achieved
• NEVER leave a Door operating without all Safety detection systems operational.

Table of Contents

CHAPTER 1: WARNING LABELS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
CHAPTER 2: GENERAL SAFETY RECOMMENDATIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
CHAPTER 3: SCOPE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
CHAPTER 4: GETTING STARTED . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
CHAPTER 5: INSTALL THE DOOR FRAME . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
CHAPTER 6: SHUT OFF CIRCUIT BREAKER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
CHAPTER 7: 120 VAC GENERAL WIRING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
CHAPTER 8: HANDING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
CHAPTER 9: INSTALL THE FOLDING DOOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Nabco Entrances Inc. S82 W18717 Gemini Drive Muskego, Wisconsin 53150
Phone: (877) 622-2694 Fax: (888) 679-3319 www.nabcoentrances.com
NABCO hours of Operation: Monday to Friday 8:00 a.m.- 4:30 p.m. (Central Time)
GT Folding Door Owners Manual; P/N C-00111
NABCO Price Book" for Sensors, Switches, and Accessories; P/N 16-9244-30
by a NABCO trained technician. Failure to follow these practices may result in serious
consequences.
Section 3.1 To the Installer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Section 3.2 Objective . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Section 4.1 Type of Fold Door . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Section 4.2 Folding Door Configuration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Section 4.4 Emergency Egress . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Section 4.5 Folding Door Standard Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Section 4.6 Parts of the Header . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Section 5.1 Prepare the Header . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Section 5.2 Secure Jamb Tubes to Rough Opening . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Section 5.3 Secure Header to Rough Opening . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Section 8.1 How to Determine Handing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Section 8.2 The Handing Harness . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Section 9.1 Install the (Floor Portion) of Bottom Pivot . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Section 9.2 Install the Bottom Pivot (Door Portion) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Section 9.3 Secure Spindle Drive Bar to Folding Door . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Section 9.4 Secure Folding Door to Frame . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Section 9.5 Secure Guide Channel to Folding Door . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
GT1400 Standard Single/Hurricane Single
Folding Door Installation Manual
P/N C-00177 Rev 6-14-21
1 of 26

Advertisement

Table of Contents
loading

Related Manuals for Nabco GT1400

Summary of Contents for Nabco GT1400

  • Page 1: Table Of Contents

    WARNING • Instruct the Owner to keep all power turned OFF until corrective action can be achieved by a NABCO trained technician. Failure to follow these practices may result in serious consequences. • NEVER leave a Door operating without all Safety detection systems operational.
  • Page 2 GT1400 Standard Single/Hurricane Single Folding Door Installation Manual www.NabcoEntrances.com P/N C-00177 Rev 6-14-21 CHAPTER 10: ADJUST FOLDING DOOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13 CHAPTER 11: INSTALL WEATHERING .

  • Page 3: Chapter 1: Warning Labels

    . Any sharp objects that come in contact with glass may cause the glass to shatter . NABCO Entrances is not responsible for glass that is broken during the installation of this Unit .

  • Page 4: Section 3.2 Objective

    All installation changes and adjustments must be made by qualified, NABCO trained technicians. Note: As an Option, the GT-1400 Fold door can be certified to have a “Hurricane High Impact Compliant Version” manufactured to meet the High Velosity Hurricane Zone (HVHZ) requirements of the Florida building codes.

  • Page 5: Section 4.5 Folding Door Standard Components

    GT1400StandardSingle/HurricaneSingleFoldingDoorInstallationManual Rev 6-14-21 P/N C-00177 Section 4 .5 Folding Door Standard Components Sensor on Sensors Header Non-Foldout side Top Rail Jamb Tube Strike S le Door Hinge Thumbturn Lock Non-Foldout side Slide Panel Swing Panel Mun n Keyed Lock Flush Bolt Assembly...

  • Page 6: Chapter 5: Install The Door Frame

    1. Position Jamb tubes on either side of Header so the Weathering faces up, and the open end at the bottom of each Jamb Tube is facing the breakout side of opening. 2. Secure Jambs Tubes to Header with 1/4 inch Star Washers and 1/4-20 x 3/4 inch Bolts, provided by NABCO. 6 of 26...

  • Page 7: Section 5.3 Secure Header To Rough Opening

    GT1400StandardSingle/HurricaneSingleFoldingDoorInstallationManual Rev 6-14-21 P/N C-00177 Magne c Latch Bo om of Jamb Tube (towards Exterior opening) Weathering must face up (towards Exterior opening) Door Opening Figure 5 Orientate Frame to Breakout Side of Rough Opening DN 0989 EXTERIOR 3. Lift to position the assembled Frame into the rough opening.

  • Page 8: Chapter 6: Shut Off Circuit Breaker

    Header End Cap . Attention:  Electrical circuit to Nabco operator must not be not shared with other equipment such as lighting, cash registers, or any device that might cause electrical interference on the circuit .

  • Page 9: Chapter 7: 120 Vac General Wiring

    CHAPTER 9: INSTALL THE FOLDING DOOR Section 9 .1 Install the (Floor Portion) of Bottom Pivot 1. Obtain the Bottom Pivot Parts Box provided by NABCO. (2) 1/4 - 20 round head screws provided by the Pivot Manufacturer are not required. 2. Insert the Bottom Pivot into the Notch located at the bottom of Jamb tube. Secure with (1) 1/4-20 x 7/8 inch screw.

  • Page 10: Section 9.2 Install The Bottom Pivot (Door Portion)

    Section 9 .3 Secure Spindle Drive Bar to Folding Door Note: The Drive Bar is installed to the Channel Guide at the NABCO Factory for shipping purposes only and must be removed from the Channel Guide before the Folding Door can be installed.

  • Page 11: Section 9.4 Secure Folding Door To Frame

    GT1400StandardSingle/HurricaneSingleFoldingDoorInstallationManual Rev 6-14-21 P/N C-00177 Guide Channel Guide Channel Spindle Drive Bar - 90 Out (Lowered down from Header) Figure 12 Release Spindle Drive Bar from Guide Channel DN 0844 Bolt Spindle Drive Bar Section 9 .4 Secure Folding Door to Frame 1. With the Folding Door still on a flat surface, go to the Pivot End of the Top Web.
  • Page 12 6. Go to the Spindle Drive Bar located inside the Top Web, at the Pivot end. 7. Obtain (1) Split Plastic Bushing that was provided by NABCO. 8. Push the Split Plastic Bushing around the Spindle between the Guide Channel and Spindle Drive Bar.

  • Page 13: Chapter 10: Adjust Folding Door

    P/N C-00177 CHAPTER 10: ADJUST FOLDING DOOR Note: Each Push Rod has been pre-installed at the NABCO Factory to ensure the Folding door will fully close under normal operation. However, after installation, adjustments may be necessary. 1. Go to the Push Rod that needs to be adjusted. Loosen both Hex Locknuts.
  • Page 14 2. Measure (6) inches up from the Pivot End of Bottom Rail, towards the Top Rail. Mark that spot. 4. For each marked spot, place (1) Setting Block (not provided by NABCO) on top of the Base Glass Stops. 5. Place the Glass Panel up against the Vinyl and sits on top of the Setting Blocks.

  • Page 15: Service Parts: Bag P/N A-00514

    GT1400StandardSingle/HurricaneSingleFoldingDoorInstallationManual Rev 6-14-21 P/N C-00177 SERVICE PARTS: BAG P/N A-00514 Floor Pivot Assembly DN 1359 Single Fold Door Part Bag A-00514 Item Part Description Used To A-01089 FLOOR PIVOT,CENTER HUNG,MACHINED Connect Floor Pivot Assembly to bottom of Swing Door A-01047...

  • Page 16: Service Parts: Opus Control

    GT1400 Standard Single/Hurricane Single Folding Door Installation Manual www.NabcoEntrances.com P/N C-00177 Rev 6-14-21 SERVICE PARTS: OPUS CONTROL A-01135 with Switch; A-00136 without Switch DN 1592 Opus Control Item Part Finish/Sizes/Notes Description BRACKET,BIFOLD,OPUS M-01736 V-00552 Used on Opus Control FUSE;5A;GMA;5X20mm V-00288 Used on Brake Module...

  • Page 17: Service Parts: Header (Top Half)

    GT1400StandardSingle/HurricaneSingleFoldingDoorInstallationManual Rev 6-14-21 P/N C-00177 SERVICE PARTS: HEADER (TOP HALF) Viewed from Non-Break Out Side Sold as an Option DN 0997 17 of 26...
  • Page 18 GT1400 Standard Single/Hurricane Single Folding Door Installation Manual www.NabcoEntrances.com P/N C-00177 Rev 6-14-21 Header Top Half Item Part Finish/Sizes/Notes Description M-01220 OPERATOR,MOUNT,WELDMENT,RH BI-FOLD M-01219 OPERATOR,MOUNT,BIFOLD,LH T-00126 “HHCS,5/16-240.625L.,ZINC” A-01185 Sold as an Option XFMR;24V;40A;W-MTG.BKT.& HDW. A-01290 OPER,SWGR,W/ENCOD,ROF,LH,NO CLUTCH,BFOLD OPER,SWGR,W/ENCOD,ROF,RH,NO CLUTCH,BFOLD A-01291...

  • Page 19: Service Parts: Header (Bottom Half)

    GT1400StandardSingle/HurricaneSingleFoldingDoorInstallationManual Rev 6-14-21 P/N C-00177 SERVICE PARTS: HEADER (BOTTOM HALF) Viewed from Non-Break Out Side 21 22 DN 0998 19 of 26...
  • Page 20 GT1400 Standard Single/Hurricane Single Folding Door Installation Manual www.NabcoEntrances.com P/N C-00177 Rev 6-14-21 Header Bottom Half Item Part Finish/Sizes/Notes Description T-00064 HHCS,1/4-20x0.750L.,ZINC T-00087 WASHER, LOCK, EXT, 1/4 ID, ZINC A-60739 Clear “END CAP,HEADER,BIFOLD,204” Dark Bronze “END CAP,HEADER,BIFOLD,313” A-70739 M-01335 ARM, BELL CRANK, BI-FOLD SPINDLE T-00126 “HHCS,5/16-240.625L.,ZINC”...

  • Page 21: Service Parts: Single Fold Door

    GT1400StandardSingle/HurricaneSingleFoldingDoorInstallationManual Rev 6-14-21 P/N C-00177 SERVICE PARTS: SINGLE FOLD DOOR Viewed from Non-Break Out Side DN 0996 21 of 26...

  • Page 22: Service Parts: Left Hand Single Door

    GT1400 Standard Single/Hurricane Single Folding Door Installation Manual www.NabcoEntrances.com P/N C-00177 Rev 6-14-21 SERVICE PARTS: LEFT HAND SINGLE DOOR Viewed from Non-Break Out Side Bottom Lock Rod Used on Hurricane Doors Only DN 0986 22 of 26...

  • Page 23: Service Parts: Right Hand Single Door

    GT1400StandardSingle/HurricaneSingleFoldingDoorInstallationManual Rev 6-14-21 P/N C-00177 SERVICE PARTS: RIGHT HAND SINGLE DOOR Viewed from Non-Break Out Side Bottom Lock Rod Used on Hurricane Doors Only DN 0985 23 of 26...
  • Page 24 GT1400 Standard Single/Hurricane Single Folding Door Installation Manual www.NabcoEntrances.com P/N C-00177 Rev 6-14-21 Single Fold Door Item Part Finish/Sizes/Notes Description M-01142 DRIVEBAR, WLDMNT NH COMP W/8969-8970 T-00172 FHMS,1/4-20x2.000L.,PHIL,ZINC T-00087 WASHER, LOCK, EXT, 1/4 ID, ZINC M-00952 PIN, HINGE, BI-FOLD T-00271 RING,RETAINING,EXT,SHAFT, 0.394 DIA...
  • Page 25 GT1400StandardSingle/HurricaneSingleFoldingDoorInstallationManual Rev 6-14-21 P/N C-00177 Single Fold Door Item Part Finish/Sizes/Notes Description M-60278 Order by length, Clear HOLDER,WEATHERING BRUSH,204,EXTRU M-70278 Order by length, Dark Bronze HOLDER,WEATHERING BRUSH,313,EXTRU T-00222 Zinc PHSMS,6x0.500L.,PHIL,TEKS,ZINC T-00260 Black Zinc PHSMS,6x0.500L. PHIL,TEKS BLK ZN M-00461 CLIP,MUNTIN,.386 HOLE...
  • Page 26 GT1400 Standard Single/Hurricane Single Folding Door Installation Manual www.NabcoEntrances.com P/N C-00177 Rev 6-14-21 NOTES 26 of 26...

This manual is also suitable for:

00177

Table of Contents